Professional Documents
Culture Documents
a) Is primarily to protect the service break from excess heat and save wear
b) Can stall the engine if the specified engine speed is not maintained
d) All above
2) What is the minimum height of Roof in case of flat roof Rest Shelters?
e) ‘a’, ‘b’, ‘c’ & ‘d’ are correct f) ‘a’ & ‘b’ are correct
g) ‘c’ & ‘d’ are correct h) ‘a’ & ‘d’ are correct
4) No drill shall be used for boring a shot hole unless it allows a clearance of atleast over the
diameter of the cartridge of explosive which it is intended to use.
6) Sound level of Audio Visual Alarm (AVA) should be at least higher than theambient noise
level.
a) 5 to 20% b) 10 to 15% c) 20 to 25% d) 5 to 10%
9) As per Reg.177 of MMR 1961 Every Fence erected on the surface shall once at least inevery week be
examined by
11) What are the “UNSAFE WORKING CONDITIONS” at Mines? Choose from the following.
12) A vehicle transporting EXPLOSIVES shall not be driven at speed exceeding KMPH.
a) 25 b) 20 c) 15 d) 30
13) Voltage shall not exceed Volts for hand held portable apparatus used in theMines as per
CEA Regulations. 2010
c) Effective administrative controls d) All ‘a’, ‘b’ & ‘c’ are correct
15) Which of the following are the main factors responsible for Blast induced ground vibrations?
19) First-Aid Room shall have floor space not less than .
20) Notice of accident causing death or serious bodily injury in connection with miningoperations, in
Form IV
hours.
a) 24 b) 48 c) 72 d) 12
22) Who will set permanent or temporary speed limits, for any area of the Mine or anyvehicle or class
of vehicle?
23) If any employee contracts a notified occupational disease, the Mine Management shallsend notice
to Regional Inspector in
a) 60 b) 200 c) 45 d) 500
27) Pointing out of contraventions by Chief Inspector or Regional Inspector of Mines shall be
entered in
28) Operator’s Seat in the Vehicle / HEMMs should be designed tohave adequate
comforts while driving continuously.
30) In Opencast Mining, the width which is extracted from the working bench is termed as
31) Minimum length of safety fuse at the firing end shall not be less than
32) Who are the persons not holding position of supervision or Management, choose fromfollowing,
33) As per Regulation- 36 of MMR 1961, in opencast mines worked by HEMM, MechanicalEngineer shall
be appointed, where aggregate H.P. of all machineries exceeds
a) 1st Apr to 31st Mar b) 1st Jan to 31st Dec c) 1st Jan to 30th Sep d) 1st Oct to 31st Dec
a) Improves mine efficiency, reduces down time and cuts maintenance costs
d) All above
Mines.
38) Notice of Medical examination under 29D of Mines Rules 1955 shall be given in
39) Every Women employed in a mine above ground shall be allowed an interval of not less
than hours between the termination of employment on any one day thecommencement of the
next period of employment.
a) 11 b) 12 c) 24 d) 16
40) For employees engaged in Driving / HEMM operation jobs, eye refraction test should beconducted
one in Years.
a) 2 b) 1 c) 3 d)5
41) The explosives shall be transported to the site of blasting not more than
commencement of charging of the holes.
before the
42) Which of the following are the examples of an inadequately maintained haul road?
a) Pot holes or washouts b) Inadequate berms
d) All above
43) The energy shall not be transmitted in to a Mine at a voltage exceeding andshall not be used
therein at a voltage exceeding .
44) Pit slope is the angle made by the imaginary line joining the –
b) Top most toe of the bench to the bottom most toe of the benc
45) Maximum Exposure Limit of dust prescribed for 8 hrs time weighted average in Mine
workingenvironment.
47) Your colleague is complaining of breathlessness and a tight pain in the chest. You suspect aheart
attack.
48) A successful accident investigation must answer three questions: What are they?
c) Why did they do? 2. Why they couldn’t avoid it 3. What went wrong?
49) Which of the following features should be shown in water danger plan?
e) All above
51) If the mine wherein 1600 persons are ordinarily employed, the number of WorkmenInspector
required as per as per Rule 29 Q of Mines Rules 1955.
a) 2 b) 3 c) 4 d) 5
53) Pit slope is the angle made by the imaginary line joining the –
f) Top most toe of the bench to the bottom most toe of the benc
54) As per 106 of MMR 1961, No tree, loose stone or debris shall remain within a distance of ———
from the edge or side of excavation.
a) 5 m b) 4m c) 3 m d) 2 m
55) If the percentage of free respirable silica present is 10% in the atmosphere , what is thepermissible
limit of free silica in milligrams per cubic meter of air sampled.
a) 1.5 b) 3 c) 10 d) 5
56) As per 173 of MMR 1961, the hydraulic test for the air receiver to be done at a pressure ofat least
—- times the maximum permissible working pressure.
Medical certificates should be retained for 5 years from the date of medical examination
Medical certificates should be maintained as long as the person employed and 10 years thereafter.
Medical certificates should be maintained as long as the person employed and 5 years thereafter.
58) The annual returns submitted to the DGMS as per – First Schedule of which form?
61) Miner died due to heart- attack during his duty hours without any injury . which of thefollowing
statements is are not true ?
If post mortem report fails to submit to DGMS … it is considered as accident in the Mine.
In case of Semi – Mechanised – area of maximum of 4 Mate districts with 2 KM flat area as radius.
64) The bench height is 6m, depth of the hole is 6.6 m (includes sub grade drilling), spacing is 4 m,
burden is 5 m, the density of the rock is 2, and explosive used is 24kg. Find thepowder factor.
a) 12 b) 10 c) 24 d) 11
65) As per Reg.177 of MMR 1961 Every Fence erected on the surface shall once at least inevery week be
examined by .
66) Which of the following is in the part of ISO (Internal Safety Organisation)
i. Managing Director
a) 1 & 2 b) 3 c) 1, 2 &3 d) 4
67) Which of the following is true regarding the workers participation in safety management?
b) Committee
c) Tripartite committee
68) The number of man days in the year 2014 is 26500, rest days are 54, and non working daysdue to
sick are
Find the persons ordinarily employed in the Mine. Consider the yearmeans 365 days.
70) The handling figures of the Mine for the year 2014-15 are as below.
The OB hanlding = 5,00,000 Tonnes , ore production = 2,00,000 Tonnes and densities of OB and Ore are
2.5 and 3respectively . Find the stripping ratio for the year 2014-15.
a) 1: 2.5 b) 2.5 : 1 c) 1: 1 d) 5 : 2
71) Which of the following are not the safety features of Belt conveyors?
72) As per DGMS Circular No 36/1972, find the minimum width of the bench with the followingdata?
The Height of the bench is 7 m , The boom reach of the machine is 6 m , the tipper plying on the bench ,
where tipperwidth is 2.5 m and the widest machine Hitachi – Ex800 working on the bench , where the
EX – 800 width is 5.5 m.
a) 7.5 m b) 6 m c) 7 m d) 5.5 m
74) If the depth of pit reaches —– meters the scientific study on slope stability will bedone by scientific
agency.
a) 60 m b) 75 m c) 50 m d) 100 m
========================================================================