Professional Documents
Culture Documents
IndustryDIY.com
Supply List
IndustryDIY.com
Cut List
You can make these cuts all at once or as you need them.
The jig and drill bit should both be set at the ¾” board
thickness setting.
IndustryDIY.com
Step 1
IndustryDIY.com
Step 2 - Assemble Shelf
Use a Kreg clamp to hold each end piece to the long shelf
board as you drive the screws.
Mark where the shelf is on the back of the board, and drive
in screws from the back. I used 8 1½” screws.
IndustryDIY.com
Step 3 - Assemble Letter Holder
IndustryDIY.com
Step 4 - Sand and Prepare for Stain
Step 5 - Pre-Stain
Brush the wood conditioner on and follow the directions on
the can.
Screw on your coat hooks along the bottom, and the key
hooks along the top. You can customize this as you would
like. See the project page for more info.
IndustryDIY.com