Professional Documents
Culture Documents
DEMANDS
Description Ru Pu Load type
kN kN
GEOMETRIC CONSIDERATIONS
Dimensions Unit Value Min. Max. Sta. References
End plate
Length [mm] 140.00 87.38 164.21 p. 10-49
Beam
Top cope length [mm] 104.17 - 411.99
dctmax = min(d/2, dtop - w) = min(205.99 [mm] /2, 33 [mm] - 3.18 [mm] ) = 29.82 [mm]
dcbmax = min(d/2, d - L - dtop - w) = min(205.99 [mm] /2, 205.99 [mm] - 140 [mm] - 33 [mm] - 3.18 [mm] ) = 29.82 [mm]
DESIGN CHECK
Verification Unit Capacity Demand Ctrl EQ Ratio References
Beam
Welds rupture [kN/m] 1549.53 199.14 LC-32-31 0.13 p. 9-5
Rn = *Fy*Snet/e = 0.9*276 [N/mm2] *51295.73 [mm3] /110.17 [mm] = 115.65 [kN] p. 9-6
Support
Welds rupture [kN/m] 1992.25 190.11 LC-32-31 0.10 p. 9-5
NOTATION
Ag : Gross area
Aw : Effective area of the weld
c : Coped length
cmax : Maximum coped length
d : Nominal bolt diameter
dc : Coped depth
dcb : Bottom cope depth
dcbmax : Maximum bottom coped depth
dct : Top cope depth
dctmax : Maximum top coped depth
dtop : Beam top edge distance
d : Beam depth
D : Number of sixteenths of an inch in the weld size
Dmin : Number of sixteenths of an inch in the minimum weld size
e : Load eccentricity
E : Elastic modulus
f : Plate buckling model adjustment factor
Fcr : Critical stress, flexural stress buckling
FEXX : Electrode classification number
Fu : Specified minimum tensile strength
Fw : Nominal strength of the weld metal per unit area
Fy : Specified minimum yield stress
ho : Reduced beam depth
HasWeldsOnBothSides : Has welds on both sides
IsTopFlangeBeamCoped : Is the top beam flange coped
k : Plate buckling coefficient
kBot : Outside corner radius of the bottom flange
kTop : Outside corner radius of the top flange
L : Length
L : Angle length
Lmax : Maximum length
Lmin : Minimum length
Lp : Plate length
L : Length of weld
: Poisson's ratio
P : Required axial force
: Design factors
Rn : Design or allowable strength
Rn : Nominal strength
Ru : Required strength
Snet : Net section modulus
tp : Thickness of the connected material
T : Clear distance between web fillets
tp : Plate thickness
tw : Web thickness
wmax : Maximum weld size required
wmin : Minimum weld size required
w : Weld size
Znet : Net plastic section modulus
REFERENCES
[11] AISC 2005, Design Examples Version 13.0, pp. IIA-38