raat
+ Elevator Parts List
+ Download Catalog
» Order Online
».*
htp:swaw.if-spare-parss.comiElevator Parts-ListKONE-rror-code-Fallur
KONE error code Failure reason Elevator Paris List-Ots pats, Thyssen parts Kone pars, Schindler parls,LG Sigma parts
<> ELEVATOR
TECHNOLOGY
Lift Spare Parts Home
Jufeng levator Lift Spare Parts Products, Lift Serviees Contact Jufeng
Home > Lit Services > Elevator Pars List
KONE error code Failure reason
KONE error code (fullversion)
Failure reason code
(000: driver long ime ater a period ofthe positon signal 30/830 runing time does not change. Immeslataly stop power
off
(0004 three consecutive synchronous operation falled. Thvee consecuive synchronous operation ofthe system are not
receiving proper leveling signal slowdown arth failed to stop at he and ofthe station . OF power
(0007 Area $08,090 ewich stuck after the start ime fs not detected fling edge 30/630 signal, Door zone has been
focive operation ofthe switch othe destination 307830
(0008 NVRAM damaged or capac isnot enough when the power ansmission capaci isnot enough tod
NVRAM. Replace NVRAM
(0014 Area check the circuit id nat ralease any of to consecutive 486.443.1.442:2 without (ACO / ACL) un othe
estinaton floor shut of eleticalsovico
(0015 Area check crcut does not pull any one 486.443.1.443:2 consecutive times without (ACO / ACL) run tothe
destination floor shutoff elaticalsarvice
002! safety circu fals . Safely crcut input a no voltage is immeséataly stopped. Safety crcl switched
(0022 Hall door barr. 3 no-wotage input safty cial stop immeditaly. Hal door tums
(028 car door lock wil ot work. Satay cell voltage input 2no stop immediatly. oor Sodan tuned
(0025 stat of system aur when he elevator did net stop the main contactr release does at stat. Main contactor
fain row
0028 drive systom flue. rivan system detects fault (SFCK no ght) doesnot start. Of power or pay overhaul
(0089 shored 77 buttons slick, Sorted 77 butlons car refuses to slar LCEBOPU board, Uni the release button
(042 car lighting monitor Ightng no electric to run the car to the destination floor. From service unl he signal
isappears
(0044 closad barior several attempls . Closed doar bates ve times bt fale. Door opening doesnot go a eletety
corplaying back door opener repair 0048 remain valid reverse signal lasts more than one minute to open the door to
sop the doo closed unil tho signal disappoars electricity
(005: stat start invalé times unsuccessful, suchas landing door may not shut the door and then ty ve automatic
recovery
(0082 down synctronous switching while otfectvaly.77 U and 77N while afectivaly sop immediatly. ROF can only start
atthe end ofthe station automatically restores
(0088 ready to runout Had requested bu tie elevate didnot start tuning more than 100 seconds to stop immediately
‘Attempt to runoff atter ten seconds or playing slecrc acceleration signal OD60V3F 18 overhaul didnot receive
‘acceleralod loss of signal c-and operation ofthe diva system power off or play slaion overhaul
(007% distet oss of signal Aer several ayers 61U/N when the rising edge ofthe signal ean nat be found 30/630 run
to the destination flor. Door shut without elactrty or playing overhasl
(0072 61U Signal stuck 61 U signal ater leaving te gate area is sill not released fr some time to run tothe destination
‘oor. Ten open the lest floor as sl stuck, then shut off lactrical service or repair 07 hit tea through several
layers of signal loss 61U /N can nol be found when the rising 9dge ofthe signal to run 30/830 destination lor. door
shut without elect or playing overhaul
(0073 61N signal stuck. Passes through soveral layers ofthe docr area 61N can not fir the sing edge ofthe signal
Off eletey or playing overhaul
(0073 61N signal suck. Passes through several layers ofthe docr area 61N can not fi the sing edge ofthe signal
Off electcy or playing overhaul
(0074 61N signal stuck. N signal ater leaving the gate area fr some time stil not released. Of power or Play
overhaul
(0075 61U Signal stuck. Passes through several layers ofthe door area. 61 can not tnd the sng edge of the signal
Off electrity or playing overhaul
‘Automate recovery ater the 0076 area survelance forthe frst me not to release without releasing (ADO / ACL (
reason hil 18raat KONE error code Failure reason Elevator Paris List-Ots parts, Thyssen parts Kone pars, Schindler parls,LG Sigma parts
allowed } to un othe destination flor 15 seconds 486,443:1.449:2 any runtime
(0077 open iit faut been ineffective ). Door open but cannot receve a sinal
Button stuckin te 0078 car. Buttons stuck inside any car more than 60 seconds to cance the wit service unl button
to retum 0 normal
(0079 Outbound bution stuck. Arbirary outbound button stuck more than 60 secands to cancel th twisted services back
to normal unl the button
Montor automaticaly restored 0082 area dose not pull no fs pull (ADO / ACL) (alowed) to run othe destination Noor
15 soconds ator running ether 486-443:1.643.2
(0083 to calelate the positon of losing the signal doesnot match withthe wells run othe end station
(0084 open lit aut bean effectively) shul the door open bu sil receives signal
(0089 Hal Ianding door leks open excult manitring (non-ear poston }run to the destination floor, Shutoff electrical
service or overhaul fight
(0145 EBD EBD equipment damage
0148 EBD EBD ater cell damage
Drive faire
0101 drivers to stp driving the systom detects fault the
(0102 moter overcurrent
(0103 braking resistor braking resistors damaged, check te brake resstor
(0104 moter overheated motor thermistor
(0105 AC power supply intermasiate DC voltage is too low
0108 VaF baa
0107 lead boarng device failure signal vliage is lass than 0.5V regulator load dovico
(0108 motor! tachometer speed reverse polaty wrong! bad car balance /oad allowed J not open brake Jive
parameters right overspesc
(0108 Poston location is lst is ost dive system under Investigation deceleration, aveing switch
0110 raciator overheating. Overheating radiator driver module
‘The dive contol process falures
(0111 deck 61: N at 61: Under UU /N swapped Chapin ayer switching sequence
011261: UN overlapring layer switch postion too Chapin
(0113 simultaneous switching oro error synchronous swileh synchronous swith synchronous switch fais
investigation
(0114 foor stance i oo short to check the poston of the magnet
0115 he proportion of errors
(0116 ost runs tolear counting ero Noor redone lors unsuccesstullearing
Network ature
Aside door 3 side
1101 bad ercuit board input board i damaged, electrical wring erors can nol be contacted or no normal deceleration
stop layer, close contac does not move again unt the
1202/2201 frst boars fault cicut board is damaged . lecrical wing errors can nel be contacted ordi not resume
normal service untl the single staircase contacted again
1202/2202 second board fault circuit board is damaged elecical wiring emors can not be conta
rormal service unl th single staircase contacted again
1203/2203 The tid board fault circuit board is damaged, electical wiring emors can not be contacted o did not
resume normal service unl the single staircase contacted again
130% / 230% output boards bad circuit board is damaged, elacirical wing erors can not be contacted odd nat rach
the target ayer, he door dose not mave again unl the contact
1401 / 2401 fst board fault ccut board is damaged , electical wring errors cannot be contacted oF di not resume
normal service operation signals detected by the frst xx 14/24ox boards fault circuit oardis damaged, electcal
wing errors can nol be contacted of dl not resume noxmal serves aperaton signal detection by
150% / 2501 rst boara fault circuit board is damaged , slecrical wing errors cannot be contacted ordi not resume
normal service operation signals delactes by
1530/25. frst x boards fault ccult board is damaged , electrical wiring errors can not be contacted or didnot resume
rormal service operation signal detected by
1801 bad ercuit board exoansion board is damaged, electrical wring erors can not be contacted or didnot resume
normal service uti the single stiase contact again on
170% / 270% frst board faut circuit board is damaged aut wing or no power can nol be contacted again untl contact
{Taad2Toc frst x boards faut ccui board is damaged , faulty wing oF no power can not be contacted again uni
contact on
ato stoppedto check the drive shaft falre
13 oF did not resume
®@ we ors 2 @ WM, coc gy
Severs Schindler -myssescupe
msi uergoioh ss Skype ne sen Ema sabs@ieapowsamniam
hitp:swaw.if-spare-parss.comiElevator Parts-LisKONE-eror-code-Failure-eason.himl 29raat KONE error code Failure reason Elevator Paris List-Ots parts, Thyssen parts Kone pars, Schindler parls,LG Sigma parts
Julong Elevator Technology co. hd, supply all Os Parts Elevator Partsfone stop elevator pats supplier
(Gjufeng elevator technology co, te 2014) HEE
hitp:swaw.if-spare-parss.comiElevator Parts-LisKONE-eror-code-Failure-eason.himl
38