Professional Documents
Culture Documents
Operating Instructions
© Ericsson AB 2016, 2017. All rights reserved. No part of this document may
be reproduced in any form without the written permission of the copyright
owner.
Disclaimer
The contents of this document are subject to revision without notice due to
continued progress in methodology, design and manufacturing. Ericsson shall
have no liability for any error or damage of any kind resulting from the use of
this document.
Trademark List
All trademarks mentioned herein are the property of their respective owners.
These are shown in the document Trademark Information.
Contents
1 Introduction 1
1.1 Conditions 1
2 Procedure 2
2.1 Using the RBS EM 2
2.2 Using the Maintenance Button 3
3 Additional Information 4
1 Introduction
This document describes how to unlock boards or units using the RBS
Element Manager (EM) or the maintenance button.
Danger!
Electric shock risk. If the antenna port is configured to supply DC power for a TMA,
TMF, or RET unit and the maintenance button is pushed, DC power is still being
supplied on the antenna port.
1.1 Conditions
Before starting the procedure to unlock a board or a unit, ensure that the
following conditions are met:
2 Procedure
Steps
1. Identify the instance of the Managed Object (MO) for the relevant board or
unit. Table 1 shows the MOs.
If the board is disabled, investigate the reason for this by examining the
availabilityStatus attribute.
3 Additional Information
When the status of the board is UNLOCKED, any active alarms are generated.
When the status of the board changes to UNLOCKED, the optical indicator turns
off. More information about optical indicators can be found in Indicators,
Buttons, and Switches.