Professional Documents
Culture Documents
Solidworks:: Lesson II - Revolutions, Fillets, & Chamfers
Solidworks:: Lesson II - Revolutions, Fillets, & Chamfers
UCF Engineering
SolidWorks Review
You should see a yellow wire frame and if you don’t, select FULL PREVIEW
from the properties manager.
Fillets and Chamfers Exercise
As you can see, you get a
preview of what it is going
to do. Click on the inside
hole edge. You should see
the yellow wire frame there
as well. Click, EXIT
SKETCH. You get a nice
rounded edge.
Chamfers as well
give you nice part
features. Click
Chamfer, then select
the bottom edge of
your part.
Fillets and Chamfers Exercise
There are 2 different ways
to define a Chamfer.
Extrudes? Revolve?
Fillets and Chamfers Exercise
Let’s save our current part. Then exit out.
Click NEW, choose Part, then OK. Now
careful inspection of our design we see
that we are possibly NOT using meters
as a unit. Let’s change the units to
millimeters.
Click OK in property
manager and the final
part will be shown.
Fillets and Chamfers Exercise