Professional Documents
Culture Documents
b. 214.5 Hz
2. A unit of noisiness related to the 7. A certain machine with a slightly out-of-
perceived noise level balance motor rotating at 1800/min is
fixed on a perfectly elastic mount with a 11. The sound power level of a certain jet
a. Noy static compression of 2.50 mm. Calculate plane flying at a height of 1km is 160 dB
the resonant frequency of mount. (re10-12W). Find the maximum sound
pressure level on the ground directly
3. An agreed set of empirical curves a. 10 Hz below the flight path assuming that the
relating octave-band osund pressure level aircraft radiates sound equally in all
to the center frequency of the octave directions.
bands 8. Calculate the lowest resonant frequency
for a brick partition 120 mm thick, 4m by d. 89.1 dB
c. Noise rating curves 2min area with longitudinal wave velocity 12. Speaker is a device that
of 2350 m/s. (Assume that it is supported
at its edges.) b. Converts current variations into sound
4. The frequency of free vibration waves
d. 40 Hz
b. Natural frequency
a. 7.6 dB
a. 0.15 W a. 20 log P/ Pref
b. 0.21 W b. 30 log P/ Pref
30. Speed that is faster than speed of
sound. c. 0.24 W c. 10 log P/ Pref
d. 0.18 W d. 20 log I/Iref
a. Ultrasonic 33. Crest-to-crest distance along the 36. The most important specification of
direction to wave travel. loudspeakers and microphones.
b. Supersonic
c. Subsonic
a. Compression a. Frequency response
d. Transonic
b. 57.78 dB SPL 48. What is the audio frequency range? 51. What is the dB SPL of a voice paging in
an office?
c. 115.56 dB SPL
c. Treble
a. Volume
d. Loudness a. 1000 mels
b. Loudness
57. If the distance between the listener b. 500 mels
c. Sharpness and the source of the sound is doubled,
c. 2000 mels
d. Strength the intensity is reduced to
d. 100 mels
55. The loudness of a sound depends upon
the energy of motion imparted to 60. If the sound waves are converted to
a. ½
________ molecules of the medium electrical waves by a microphone, what is
transmitting the sound. b. 1/3 the frequency of the electric current?
c. 2/3
56. _________ is affected by the distance 61. For a music lover concert “A” is 440 Hz.
between the listener and the source of the a. 2 times as great If a musical note one octave higher were
played, it would be _______ that d. Octaves c. Microprocessors
frequency.
64. _________ is an undesired change in d. Exciters
wave form as the signal passes through a
67. Half construction and internal finishes
device.
a. One – half affect the final sound quality ________.
b. One-fourth
a. Noise
c. Double a. poorly
b. Vibration
d. Triple b. mildly
c. Distortion
62. In a 220 Hz, if a note was played one c. significantly
octave lower, it would be ______. d. Harmonics
d. badly
65. Distortion enhances intelligibly when
an ________ is added. 68. Positioning a loudspeaker near a wall
a. 22 Hz can dramatically alter its frequency
response in two distinct ways namely;
b. 27.5 Hz
a. Equalizer
c. 440 Hz
b. Igniter a. Gump and dump
d. 110 Hz
c. Exciter b. Hump and notch
63. Much of music is generally referred to
in d. Emulsifier c. Fade and gone
71. All microphone have two basic b. Stephen and Bate 76. The wavelength of a sound of 20 kHz
components namely, ___________. c. Norris-Eyring frequency is
d. Notch
a. Wired and body 74. At room temperature, what is the a. 16.5 m
c. Pitch d. Sone
a. Rarefaction
d. Frequency 107. a large speaker having a large
b. Reflection diameter(15 cm and above)
102. The term that describes the highness
or lowness of a sound in the study of c. Refraction
acoustics is called a
d. Diffraction a. coaxial speaker
d. Loudness b. Wavelength
a. Distance method
c. Volume
106. The unit of pitch
b. Bounce back to back method
d. Pitch
c. Impedance method
a. Decibel 109. The lowest frequency produced by an
d. Reverberation chamber method instrument
112. _____ is the transmission of sound c. Pitch
from one room to an adjacent room thru
a. Harmonic common walls, floors, or ceilings. d. SPL
c. Midrange a. Reverberation
d. 0 Hz a. Converts current variations into sound
b. Refraction
waves
110. Sound intensity is given as c. Flanking transmission
b. None of these
d. Reflection
c. Converts electrical energy to mechanical
a. df/dp 113. The midrange frequency range of energy
b. dE/dP sound is from
d. Converts sound waves into current and
c. dA/dP voltage
c. Radioscope d. dBk
a. Threshold of sense
d. Audioscope 123. Which type of microphone operates
b. Threshold of pain on the principle that the electrical
118. In the study of acoustics, the velocity resistance of carbon granules varies as the
of sound is dependent to one of the c. Hearing threshold pressure on the granules vary?
following
d. Sensation intensity
d. 1.2 W
125. Required time for and sound to decay b. Hump and notch 130. The minimum sound intensity that
to 60 dB can be heard
c. Fade and gone
126. If the distance between the listener a. Piezoelectric effect 131. The ____ of a sound is a subjective
and the source of the sound is doubled, effect which is a function of the ear and
the intensity is reduced to b. Doppler effect brain.
c. Haas effect
d. 1/4 d. Loudness
127. Positioning a loudspeaker near a wall a. Sabine 132. A term which is subjective but
can dramatically alter its frequency independent mainly on frequency and also
response in two distinct ways namely b. Stephen and bate affected by intensity
135. What is the velocity of sound in dry b. 1 sone
air for a temperature change of 45 degrees
a. Pitch Celsius? c. 0.5 sone
b. Frequency d. 16 sones
d. 1.86 mels a. 13 Hz
a. Echo
134. At a sensation level of 40 dB 1000 Hz b. 11 Hz
b. Reverberation
tone is c. 15 Hz
c. Pure sound
d. 14 Hz
d. Jitter
a. 1000 mels 137. 40 phons is equivalent to how many
b. 10000 mels sones? 140. An instrument designed to measure a
frequency weighted value of the sound
c. 250 mels pressure level
c. 50-60 dB b. 1 watt
a. Microphone
d. 70-80 dB c. 10 watts
b. Headphone
143. What principle is used by a carbon d. 1 milliwatt
type micro phone? c. Headset
d. Speaker View Answer:
149. An agreed set of empirical curves B. It is always transverse 153. Through which medium does sound
relating octave-band sound pressure level travel fastest?
to the center frequency of the octave
bands C. It is always longitudinal
a. Air
A. Electromagnetic wave
a. 1 kHz View Answer:
b. 300-3400 Hz B. Radio wave 154. Speed that is faster than that of
sound.
c. 100 Hz
D. Light wave
B. Supersonic
A. It may be longitudinal
156. Calculate a half wavelength sound for C. 30 Hz
sound of 16000 Hz
C. Subsonic
D. 20 Hz
A. 35 ft
D. Transonic
View Answer:
B 10 ft
View Answer: 158. Sound that vibrates at frequency too
high for the human ear to hear (over 20
155. What is the speed of sound in air at kHz)
20°C? C. 0.035 ft
A. Subsonic
A. 1087 ft/s D. 100 ft
B. Ultrasonic
B. 1100 ft/s View Answer:
A. 5 Hz D. Stereo
D. 200 ft/s
B. 20 Hz View Answer:
View Answer:
159. The frequency interval between two
sounds whose frequency ratio is 10.
D. 8
View Answer:
B. Half octave 161. Sound waves composed of but one C. Pitch and loudness
frequency is a/an
D. Residual sound
A. 2 B. Diffraction
View Answer:
C. 4 D. Refraction
A. Highness and loudness
View Answer: B. Threshold of hearing View Answer:
164. The amplitude of sound waves, the 167. What is the device used in measuring
maximum displacement of each air sound pressure levels incorporating a
C. Reference pressure = 2 x 10^-5 N/m2
particle, is the property which perceive as microphone, amplification, filtering and a
_______ of a sound display.
D. All of these
A. Pitch A. Audiometer
View Answer:
B. Intensity 166. What is a device that is used to B. OTDR
measure the hearing sensitivity of a
person?
C. Loudness C. SLM
A. Audiometer
D. Harmonics D. Spectrum analyzer
B. OTDR
View Answer: View Answer:
165. It is the weakest sound that average 168. What weighted scale in a sound level
human hearing can detect. C. SLM meter gives a reading that is most closely
to the response of the human ear?
D. Filter
View Answer:
A. Sound pressure
D. Weighted scale D View Answer:
B. Sound energy
173. Calculate the sound intensity level in 176. The sound pressure level is increased
dB of a sound whose intensity is 0.007 by _________ dB if the pressure is
W/m^2. C. 140 dB doubled.
A. 95 dB D. 14 dB A. 3
B. 91 dB View Answer: B. 4
175. What is the sound intensity for an
RMS pressure of 200 Pascal?
C. 98 dB C. 5
A. 90 W/m^2
D. 101 dB D. 6
B. 98 W/m^2
View Answer: View Answer:
174. What is the sound pressure level for a 177. The sound pressure level is increased
given sound whose RMS pressure is C. 108 W/m^2 by _________ dB if the intensity is
200/m^2? doubled.
D. 88 W/m^2
A. 200 dB A. 3
View Answer:
B. 20 dB B. 4
179. The transmission of sound from one
room to an adjacent room, via common
C. 5 walls, floors or ceilings. C. Sound shadow
178. If four identical sounds are added 181. Required time for any sound to decay
what is the increase in level in dB? to 60 dB
C. Refraction
A. 3 A. Echo time
D. Reverberation
B. 4 B. Reverberation time
View Answer:
D. 6 D. Transient time
A. Flutter echo
A. 0.3 sec
D. Free-field
D. Microphone
B. 3.5 sec
View Answer:
View Answer:
183. A room in which the walls offer
essentially 100% absorption, therefore C. 3 sec 186. _________ is a pressure type
simulating free field conditions. microphone with permanent coil as a
transducing element.
D. 0.53 sec
A. Dead room
A. Dynamic
View Answer:
B. Anechoic room
B. Condenser
188. A microphone that uses the C. Mid-range
piezoelectric effect
C. Magnetic
D. A or C
A. Dynamic
D. Carbon
View Answer:
B. Condenser
View Answer: 190. _____ is measure of how much sound
is produced from the electrical signal.
187. A microphone which has an internal
impedance of 25 kΩ is _________ type. C. Crystal
A. Sensitivity
B. Distortion
D. Magnetic A. Tweeter
View Answer:
D. 10
A. Echo
D. Frame
A. Microphone
B. Pure sound
View Answer:
B. Baffle
198. A circuit that divides the frequency
components into separate bands in order C. Reverberation
to have individual feeds to the different
C. Magnetic assemble drivers.
D. Intelligible sound
C. dBa D. Phon
A. Sone
D. 100 phons