Professional Documents
Culture Documents
In which VTP mode can a switch create VLANs, ignore VTP messages, and not pass local VLAN
• client
• server
• pruning
• transparent
• IP is used to specify all TCP/IP protocols including TCP, UDP, ICMP and routing protocols.
• Traffic can be filtered on source address only.
• Traffic can be filtered on source and destination address only.
• Traffic can be filtered on source and destination address, protocol, and specific port number.
3. Which two statements are true regarding a PPP connection between two Cisco routers?
(Choose two.)
• LCP tests the quality of the link.
• LCP manages compression on the link
4. Assuming VLSM is not being used, what impact will adding the command ip route 172.16.64.0
• All packets with a destination address between 172.16.64.1 and 172.16.80.254 will be
• All packets with a destination address between 172.16.64.1 and 172.16.255.254 will be
• All packets with a destination address between 172.16.64.1 and 172.16.79.254 will be
forwarded out serial0/0.
• All packets with a destination address between 172.16.0.1 and 172.16.64.254 will be
forwarded out serial0/0.
5.
Refer to the exhibit. The network is using OSPF as the routing protocol. A network administrator
issues the show ip ospf neighbor command to check the status of operation. Which statement is
true?
from a hotel room using the Internet. Prior to the trip, the IT staff made the necessary
provisions to allow secure Internet access. What solution was implemented for the sales
representative?
• VPN
• Frame Relay
Refer to the exhibit. A network administrator noticed that the VLAN configuration changes at
SW2 did not propagate to SW3. On the basis of the partial output of the show vtp status
command, what is the possible cause of the problem?
• VTP V2 mode is disabled.
8.
Refer to the exhibit. Because of continuing instability of one of the serial links in the OSPF
network, a network administrator configures router ASBR as shown. Which two statements will
be a result of this configuration? (Choose two.)
• Traffic intended for destinations across unstable serial links will be forwarded by ASBR even
when the links are down
• number of ports
• switch location
• switching speed
10. A company is using a Class B IP addressing scheme and expects to need as many as 150
networks. What is the correct subnet mask to use with the network configuration?
• 255.255.0.0
• 255.255.240.0
• 255.255.254.0
• 255.255.255.0
• 255.255.255.128
• 255.255.255.192
11.
What is the term for the value 2172416 that is highlighted in the output of the show ip eigrp
topology command?
Refer to the exhibit. RIPv2 is configured in the network shown. Hosts in the network have access
to all internal networks but do not have Internet access. On which router should the commands,
shown in the exhibit, be added to provide Internet access for all hosts in the network?
• R1
• R2
• R3
• ISP
13. What do companies gain from the services performed at the enterprise edge?
• faster communication with server farms
• stronger security against malicious attacks
• faster communication with Internet destinations
• enhanced performance and reliability through VLANs and redundant trunk links
14.
Refer to the exhibit. A network administrator wishes to deny Internet access to all R2 LAN hosts,
while allowing these hosts to reach all other devices on the company networks. Where the ACL
15.
Refer to the exhibit. In what sequence (from first to last) does an OSPF router check the
parameters listed when selecting the DR?
• C, B, A, D
• D, C, B, A
• A, B, C, D
• A, C, B, D
• B, C, A, D
16. What two statements are true regarding EIGRP tables? (Choose two.)
• A feasible successor route can be found in the topology table.
• A successor route can only be found in the routing table.
• The topology table shows whether a route is in the passive or active state.
• The routing table shows the amount of time elapsed since a router adjacency was formed.
• The neighbor table shows all adjacent Cisco devices.
• Administrative distance is shown as a column in the neighbor table
17.
Refer to the exhibit. Assuming that all three routers are configured with the EIGRP routing
protocol and sharing information, what information can be gathered from the show command
output?
18. Which three statements are true about RSTP? (Choose three.)
• RSTP can fall back to STP to provide support for legacy equipment.
19.
Refer to the exhibit. A network support technician has been asked to set an IP address on one of the FastEthernet interfaces on a new router. What