Professional Documents
Culture Documents
Edition 21/02/2012
Identification no:
02 05 01 06 05
Sika Boom®
Sika Boom®
Expanding Polyurethane Foam
Product
Sika Boom® is a polyurethane-based fast curing expanding foam.
Description
Construction
Uses Filling gaps and voids that occur around the home and during building
construction
Blocking out dust, noise, draft and vermin
Installation of window and doorframes
Insulation of pipes
Characteristics / HCFC Free
Advantages
Can be cut, sanded and over painted
Can be used when held upside down
Suitable for use outside
Has excellent adhesion to most substances
Quick and easy gap filler
Reaches difficult access areas that need to be filled
Product Data
Form
Storage
Storage Conditions / 9 months shelf life if stored in an unopened packaging at between +18°C and
Shelf-Life +22°C and in a dry place.
Technical Data
Chemical Base Polyurethane
Density ~ 22 kg / m³
Skinning Time About 10 minutes at 23 °C
Curing Rate 5 – 10 hours depending on atmospheric temperature and humidity.
Mechanical Properties
Mechanical Strength > 9 N/cm²
Foam yield in litres 750ml – 39 ± 3
500ml – 26 ± 3
250ml – 12 ± 2
Dimensional stability ±7%
Application Details
Substrate Quality Clean and dry, homogeneous, free from grease, dust and loose particles. Paint,
laitance and other poorly adhering particles must be removed. Standard
construction rules must be observed.
Substrate Preparation / The substrate must be free of dust, grease, oil and surface contaminants.
Priming
The surface should be pre-moistened with water before application to ensure that:
(a) The foam cures at an optimum rate
(b) Secondary foam expansion is prevented.
Application
Conditions /
Limitations
Substrate Temperature Min. 5°C max. 30°C
Ambient Temperature Min. 5°C max. 35°C
Substrate Humidity <5%
Relative Air Humidity < 80 %
Application
Instructions
Application Method / Screw the nozzle onto the can.
Tools
Shake can thoroughly (approximately 20 times) before use.
Apply foam by pointing nozzle into area to be filled and depressing. It can be
applied valve up or down.
Foam will dispense rapidly and will expand 2 to 3 times its size as it comes out of
the can.
Varying the pressure on the adaptor can regulate the quantity of foam dispensed.
Cleaning of Tools Remove fresh spots of foam immediately using acetone.
Cured foam can only be removed mechanically.
Notes on Application / All data for 23°C and 50 % r.h. and non-aged foam.
Limitations
For yield and reactivity 85 % h.r. is necessary (humidify!).
Special uses have to be tested in advance.
For aged foam no. 8 is up to 30 % lower.
Sika Boom® does not adhere to Teflon, polythene, silicone or grease.
For special uses, test Sika Boom® in advance.
Cutting time is about 25 minutes.
Aged material can yield up to 30 % less than the specified value.