Professional Documents
Culture Documents
1. System structure
icon.
3.2 Add TS
3.4 SAVE
After add all the service information for the TS. Click<Commit> to
Save.
4. Configure table generation.
Take the first TS as the main frequency, so the first frequency NIT
will contain the information of all the programs. The other tables just
need to send self table information as follows.
Next figure is example for 2nd TS.
Set the time by ‘Duration(s)’, the unit is second. Also, can set
the time by the ‘Start time’ and ‘End time’.
This page we can set the ‘Country code’ and the ’Min age
recommended’.
Extended event descriptor page
Commit to save.
6.2 Choose<Function>, <Import multiple program lists>
Note: The name of file which for import to the service should
be 100% same as the <File name> name. If not, the import
will fail.
Then on this page we can check the table PID. Here take the NIT
for example.
Usually the PID of table begin with :NIT 0x20,SDT 0X21,EIT
0X22,TDT/TOD 0X23;
The next TS will continue as: NIT 0x24, SDT 0X25, EIT 0X26, and
TDT/TOD 0X27
In this case, the EPG input by the ‘Gigabit Ethernet Card ’, port 16.
Output by the ‘8-Channel QAM Card’, port 1.for TS1.(Main Freq.)
Output used by the ‘8-Channel QAM Card’, port 2.for TS2.
EPG IP configuration as <2.1.> destination IP is 192.168.1.141—the
IP of EMR. Destination UDP is 4389.
Configure the parameter on the EMR <SNMP Para> page as follow
Choose the Gigabit Ethernet Card, port 16, and input the IP
address and UDP port. Check the Table PID input.
When the EMR got the PID input ,in the <SNMP Para>page like above
on the <port16 input System bit rate>will show the bit rate.
And also can fresh the PID input on the page of <Output Set>.(should
choose refresh all PID)
7.4 PSI interval set
In the detail page, click the output port, set the SI table interval
generate by the EMR to ‘0’. <Apply>, <OK>to save.
Here just example for 1st TS. All the other TS use to send the EPG
information need to setting the sending Interval too.
After this, should click the “set all ” for saving the changement.
‘Add’ to save.
Then add the NIT, SDT, EIT, and TOT/TIT one by one for TS1.