Roll Numbrs & Name of SG soup 8 Stuclents
td Le rmentiored om backside
UES 009 — ENGINEERING MECHANICS PROJECT
SAMPLE REPORT
GROUP NO: ABC1 SUB-GROUP NO. 1
Problem Statement: To construct a Truss bridge of span 300 mm and width 100 mm. The point
of application of load should be level with side supports.
Truss Configuration: We have chosen the truss shown in Figure 1.
‘The analysis of the truss is shown in Figure 2. The compression and tension members are
marked in the figure.
The no. of bays is
The height of the truss is
The amount of wood used = ‘x’ metres (say). The amount of wire used = ‘Y’ metre (say).
THE COST OF THE TRUSS IS = Rs (1.1 *(1200*X + 300*Y))
Result: The truss was loaded upto failure. The following results were obtained:
Load at failure:
Mode of failure: Write the identification of the joint or the member that failed.
Load - to Cost ratio is
Show
C Tafel
& im 2a
Figuee ee We Bt
oe 2 Shew the Tnteinal