Professional Documents
Culture Documents
Center
ORDER NO.
RRV4273
HTP-071
HTP-071
AUDIO/VIDEO MULTI-CHANNEL RECEIVER
VSX-321-K-P
SUBWOOFER SPEAKER SYSTEM
S-22W-P S-11-P
THIS MANUAL IS APPLICABLE TO THE FOLLOWING MODEL(S) AND TYPE(S).
Model Type Power Requirement Remarks
HTP-071 SYXE8 AC 220 V to 230 V
HTP-071 CXE AC 120 V
HTP-071 DLPWXE AC 220 V to 240 V
HTP-071 AXE5 AC 220 V
VSX-321-K-P SYXE8 AC 220 V to 230 V
VSX-321-K-P CXE AC 120 V
VSX-321-K-P DLPWXE AC 220 V to 240 V
VSX-321-K-P AXE5 AC 220 V
S-22W-P ————— —————
S-11-P ————— —————
HTP-071 is a Home Cinema Package and consists of VSX-321-K-P, S-22W-P and S-11-P.
SAFETY INFORMATION
This service manual is intended for qualified service technicians; it is not meant for the casual do-it-
yourselfer. Qualified technicians have the necessary test equipment and tools, and have been trained
to properly and safely repair complex products such as those covered by this manual.
Improperly performed repairs can adversely affect the safety and reliability of the product and may
void the warranty. If you are not qualified to perform the repair of this product properly and safely, you
should not risk trying to do so and refer the repair to a qualified service technician.
WARNING
B This product may contain a chemical known to the State of California to cause cancer, or birth defects or other reproductive
harm.
Health & Safety Code Section 25249.6 - Proposition 65
AC Leakage Test
2 HTP-071
1 2 3 4
5 6 7 8
CONTENTS
SAFETY INFORMATION.......................................................................................................................................................... 2
1. SERVICE PRECAUTIONS .................................................................................................................................................... 4
1.1 NOTES ON SOLDERING ............................................................................................................................................... 4 A
1.2 NOTES ON REPLACING PARTS ................................................................................................................................... 4
1.3 SERVICE NOTICE.......................................................................................................................................................... 4
2. SPECIFICATIONS................................................................................................................................................................. 5
3. BASIC ITEMS FOR SERVICE .............................................................................................................................................. 7
3.1 CHECK POINTS AFTER SERVICING ........................................................................................................................... 7
3.2 JIGS LIST ....................................................................................................................................................................... 7
3.3 PCB LOCATIONS ........................................................................................................................................................... 8
4. BLOCK DIAGRAM .............................................................................................................................................................. 10
4.1 OVERALL CONNECTION DIAGRAM........................................................................................................................... 10
4.2 OVERALL BLOCK DIAGRAM....................................................................................................................................... 12
4.3 D-MAIN BLOCK DIAGRAM .......................................................................................................................................... 14
5. DIAGNOSIS ........................................................................................................................................................................ 16 B
5.1 TROUBLESHOOTING.................................................................................................................................................. 16
5.2 PROTECTION CIRCUIT............................................................................................................................................... 23
5.3 IC INFORMATION ........................................................................................................................................................ 24
6. SERVICE MODE ................................................................................................................................................................. 36
6.1 SERVICE MODE .......................................................................................................................................................... 36
7. DISASSEMBLY ................................................................................................................................................................... 39
7.1 VSX-321-K-P ................................................................................................................................................................ 39
7.2 S-22W-P ....................................................................................................................................................................... 47
7.3 S-11-P........................................................................................................................................................................... 48
8. EACH SETTING AND ADJUSTMENT ................................................................................................................................ 49
8.1 UPDATING OF THE FIRMWARE ................................................................................................................................. 49
C
9. EXPLODED VIEWS AND PARTS LIST............................................................................................................................... 54
9.1 PACKING SECTION ..................................................................................................................................................... 54
9.2 VSX-321-K-P SECTION ............................................................................................................................................... 56
9.3 S-22W-P SECTION ...................................................................................................................................................... 59
9.4 S-11-P SECTION.......................................................................................................................................................... 60
10. SCHEMATIC DIAGRAM .................................................................................................................................................... 62
10.1 INPUT ASSY .............................................................................................................................................................. 62
10.2 AMP ASSY ................................................................................................................................................................. 64
10.3 MAIN ASSY (1/2)........................................................................................................................................................ 66
10.4 MAIN ASSY (2/2)........................................................................................................................................................ 68
10.5 D-MAIN ASSY (1/3) .................................................................................................................................................... 70
10.6 D-MAIN ASSY (2/3) .................................................................................................................................................... 72 D
10.7 D-MAIN ASSY (3/3) .................................................................................................................................................... 74
10.8 BR1, HP, FUNC and FRONT ASSYS ......................................................................................................................... 76
10.9 DG ASSY.................................................................................................................................................................... 78
10.10 CNT, G-T, G-L and G-H ASSYS ............................................................................................................................... 79
10.11 STBY ASSY.............................................................................................................................................................. 80
10.12 S-11-P....................................................................................................................................................................... 81
11. PCB CONNECTION DIAGRAM ........................................................................................................................................ 82
11.1 INPUT ASSY .............................................................................................................................................................. 82
11.2 AMP ASSY ................................................................................................................................................................. 84
11.3 MAIN ASSY ................................................................................................................................................................ 86
11.4 D-MAIN ASSY ............................................................................................................................................................ 90
11.5 BR1, HP, FUNC and FRONT ASSYS ......................................................................................................................... 94 E
11.6 DG ASSY.................................................................................................................................................................... 96
11.7 CNT ASSY.................................................................................................................................................................. 97
11.8 G-T, G-L and G-H ASSYS .......................................................................................................................................... 98
11.9 STBY ASSY................................................................................................................................................................ 99
12. PCB PARTS LIST ............................................................................................................................................................ 100
HTP-071 3
5 6 7 8
1 2 3 4
1. SERVICE PRECAUTIONS
1.1 NOTES ON SOLDERING
A • For environmental protection, lead-free solder is used on the printed circuit boards mounted in this unit.
Be sure to use lead-free solder and a soldering iron that can meet specifications for use with lead-free solders for repairs
accompanied by reworking of soldering.
• Compared with conventional eutectic solders, lead-free solders have higher melting points, by approximately 40 ºC.
Therefore, for lead-free soldering, the tip temperature of a soldering iron must be set to around 373 ºC in general, although
the temperature depends on the heat capacity of the PC board on which reworking is required and the weight of the tip of
the soldering iron.
Compared with eutectic solders, lead-free solders have higher bond strengths but slower wetting times and higher melting
B
temperatures (hard to melt/easy to harden).
4 HTP-071
1 2 3 4
5 6 7 8
2. SPECIFICATIONS
[VSX-321-K-P] Miscellaneous A
Audio section Power Requirements .......AC 220 V to 230 V, 50 Hz/60 Hz (SYXE8)
(SYXE8) AC 120 V, 60 Hz (CXE)
Rated power output AC 220 V to 240 V, 50 Hz/60 Hz (DLPWXE)
Front, Center, Surround..100 W per channel (1 kHz, 6 Ω, 0.7 %) AC 220V, 50 Hz/60 Hz (AXE5)
Total Harmonic Distortion Power Consumption ........................... 165 W (SYXE8, CXE, AXE5)
.......................................... 0.06 % (20 Hz to 20 kHz, 8 Ω, 50 W/ch) 170 W (DLPWXE)
Frequency response (LINE Pure Direct mode) In standby......................................................................... 0.45 W
.......................................................................... 10 Hz to 70 kHz dB (ARC function: OFF) (SYXE8, DLPWXE)
Guaranteed speaker impedance ....................................6 Ω to 16 Ω Dimensions................... 435 mm (W) x 168 mm (H) x 362.5 mm (D)
Input (Sensitivity/Impedance) Weight (without package) ........................................................7.6 kg
LINE...................................................................... 200 mV/47 kΩ
Output (Level/Impedance)
REC..................................................................... 200 mV/2.2 kΩ [S-22W-P] B
Signal-to-Noise Ratio (IHF, short circuited, A network) Cabinet ...........................................................Bass-reflex, floor type
LINE.................................................................................... 98 dB Speaker .................................................................. 16 cm cone type
• The specifications are applicable when the power supply is 230 V. Nominal impedance.....................................................................6 Ω
(CXE) Outline Dimension ........... 230 mm (W) x 418 mm (H) x 358 mm (D)
Front (stereo) ..........................................................60 W + 60 W Weight (without package) ........................................................5.3 kg
Rated power output
Front, Center, Surround..100 W per channel (1 kHz, 6 Ω, 0.7 %)
Total Harmonic Distortion [S-11-P]
.......................................... 0.06 % (20 Hz to 20 kHz, 8 Ω, 50 W/ch) Front speakers / Surround speakers
Guaranteed speaker impedance ....................................6 Ω to 16 Ω Enclosure
Input (Sensitivity/Impedance) Front speakers
LINE...................................................................... 200 mV/47 kΩ .................... Closed-box bookshelf type (magnetically shielded)
Output (Level/Impedance) Surround speakers ...............................losed-box bookshelf type
REC..................................................................... 200 mV/2.2 kΩ C
System.............................................................7.7 cm 1-way system
Signal-to-Noise Ratio (IHF, short circuited, A network) Speaker ................................................................. 7.7 cm cone type
LINE.................................................................................... 98 dB Nominal impedance.....................................................................6 Ω
(DLPWXE) Dimensions...................... 106 mm (W) x 116 mm (H) x 106 mm (D)
Rated power output Weight
Front, Center, Surround..100 W per channel (1 kHz, 6 Ω, 0.7 %) Front speakers....................................................................0.8 kg
Maximum power output (Front, Center, Surround) Surround speakers .............................................................0.6 kg
.............................................120 W per channel (1 kHz, 6 Ω, 10 %)
Total Harmonic Distortion Center speaker
.......................................... 0.06 % (20 Hz to 20 kHz, 8 Ω, 50 W/ch) Enclosure.......... Closed-box bookshelf type (magnetically shielded)
Guaranteed speaker impedance ....................................6 Ω to 16 Ω System.............................................................7.7 cm 1-way system
Input (Sensitivity/Impedance) Speaker ................................................................. 7.7 cm cone type
LINE...................................................................... 200 mV/47 kΩ Nominal impedance.....................................................................6 Ω
Output (Level/Impedance) Dimensions...................... 270 mm (W) x 100 mm (H) x 106 mm (D) D
REC..................................................................... 200 mV/2.2 kΩ Weight .....................................................................................1.0 kg
Signal-to-Noise Ratio (IHF, short circuited, A network)
LINE.................................................................................... 98 dB Note
• The specifications are applicable when the power supply is 230 V. • Specifications and the design are subject to possible
(AXE5) modifications without notice, due to improvements.
Rated power output
Front, Center, Surround....90 W per channel (1 kHz, 6 Ω, 0.7 %)
Maximum power output (Front, Center, Surround)
.............................................120 W per channel (1 kHz, 6 Ω, 10 %)
Guaranteed speaker impedance ....................................6 Ω to 16 Ω
Tuner section
Frequency Range (FM) .................................87.5 MHz to 108 MHz
Antenna Input (FM)............................................... 75 Ω unbalanced
Frequency Range (AM) ................... 531 kHz to 1602 kHz (SYXE8)
530 kHz to 1700 kHz (CXE)
9 kHz step ........................531 kHz to 1602 kHz (LPWXE, AXE5)
10 kHz step.......................530 kHz to 1700 kHz (LPWXE, AXE5)
Antenna (AM) ............................................................ Loop antenna
HTP-071 5
5 6 7 8
1 2 3 4
A
Accessories
Speaker cord (4 m) x 4
(8952S11005480-IL)
Non-skid pads x 20
(8952S11005510-IL)
Operating instructions
(CXE: 5707000006100-IL, 5707000006210-IL)
FM wire antenna (DLPWXE: 5707000006090-IL, 5707000006220-IL)
(E605010140010-IL) (AXE5: 5707000006080-IL, 5707000006230-IL)
6 HTP-071
1 2 3 4
5 6 7 8
To keep the product quality after servicing, confirm recommended check points shown below.
No. Procedures Check points
1 Confirm whether the customer complain has been solved. The customer complain must not be reappeared.
If the customer complain occurs with the particular source, such Video, Audio and operations must be normal.
as Dolby Digital, DTS, AAC, DVD-A and HDMI, input it for the
operation check.
2 Check the analog audio playback. Each channel audio and operations must be normal.
(Make the analog connections with a DVD player.)
3 Check the digital audio playback. Each channel audio and operations must be normal.
(Make the digital connections with a DVD player.)
B
4 Check surround playback. Each channel audio and operations must be normal.
(Select Surround mode and check the multichannel operations
via the DSP circuit.)
C
See the table below for the items to be checked regarding video and audio.
Item to be checked regarding video Item to be checked regarding audio
Block noise Distortion
Horizontal noise Noise
Flicker Volume too low
Disturbed image (video jumpiness) Volume too high
Too dark Volume fluctuating
Too bright Sound interrupted
Mottled color
D
HTP-071 7
5 6 7 8
1 2 3 4
A VSX-321-K-P
STBY ASSY N
B
MAIN ASSY C
G-T ASSY K
INPUT ASSY A E BR1 ASSY
AMP ASSY B
G-L ASSY L
M G-H ASSY
C
HP ASSY F
FUNC ASSY G
H FRONT ASSY
NOTES: - Parts marked by “NSP” are generally unavailable because they are not in our Master Spare Parts List.
- The > mark found on some component parts indicates the importance of the safety factor of the part.
Therefore, when replacing, be sure to use parts of identical designation.
Mark No. Description Part No. Mark No. Description Part No.
LIST OF ASSEMBLIES
NSP 1..PCB TTL ASSY FRONT 7025HK1103011-IL NSP 1..PCB TTL ASSY MAIN 7025HK1103040-IL
2..FRONT ASSY 7028071131010-IL 2..MAIN ASSY (SYXE8) 7028071121040-IL
2..FUNCT ASSY 7028071132010-IL 2..MAIN ASSY (CXE) 7028071121030-IL
2..BR1 ASSY 7028071133010-IL 2..MAIN ASSY (DLPWXE) 7028071121020-IL
E 2..HP ASSY 7028071134010-IL 2..MAIN ASSY (AXE5) 7028071121010-IL
NSP 1..PCB TTL ASSY D-MAIN 7025HK1103012-IL 2..STBY ASSY (SYXE8) 7028071122040-IL
2..D-MAIN ASSY 7028071161010-IL 2..STBY ASSY (CXE) 7028071122030-IL
2..STBY ASSY (DLPWXE) 7028071122020-IL
NSP 1..PCB TTL ASSY INPUT 7025HK1103013-IL 2..STBY ASSY (AXE5) 7028071122010-IL
2..DG ASSY 7028071111010-IL
2..INPUT ASSY 7028071112010-IL
2..G-T ASSY 7028071123010-IL
NSP 1..PCB TTL ASSY AMP 7025HK1103014-IL 2..G-H ASSY 7028071124010-IL
2..AMP ASSY 7028071141010-IL
2..G-L ASSY 7028071125010-IL
NSP 1..PCB TTL ASSY CNT 7025HK1103015-IL
F 2..CNT ASSY 7028071151010-IL
8 HTP-071
1 2 3 4
5 6 7 8
HTP-071 9
5 6 7 8
1 2 3 4
4. BLOCK DIAGRAM
4.1 OVERALL CONNECTION DIAGRAM
A
I DG ASSY
(7028071112010-IL) AI
N STBY ASSY
(SYXE8: 7028071122040-IL)
(CXE: 7028071122030-IL)
(DLPWXE: 7028071122020-IL)
CP603
(AXE5: 7028071122010-IL)
13P WAFER
CP301
13P WIRE
CP701 C C 1/2- C 2/2
CN603
9P WAFER CP302
CP304
MAIN ASSY
(SYXE8: 7028071121040-IL)
(CXE: 7028071121030-IL)
(DLPWXE: 7028071121020-IL)
(AXE5: 7028071121010-IL)
C
CN3 CN1
8P WIRE 6P WIRE
BD-TO
CP5
4P WIRE
MAIN TRANS E
CP1
CP702
4P WIRE
CN701
9P WIRE
CN702
4P WIRE
F
10 HTP-071
1 2 3 4
5 6 7 8
- When ordering service parts, be sure to refer to "EXPLODED VIEWS and PARTS LIST" or "PCB PARTS LIST". A
- The > mark found on some component parts indicates the importance of the safety factor of the part.
Therefore, when replacing, be sure to use parts of identical designation.
- : The power supply is shown with the marked box.
J
CNT ASSY B
(7028071151010-IL)
13P WIRE
CN601
CN603
BD-TO-BD 29P
BD-TO-BD 27P
CN1000
CP401
D D 1/3- D 3/3
CP17
BD-TO-BD 29P
D-MAIN ASSY
CP1000
(7028071161010-IL)
12P WIRE
CN400 CP201
C
CP400
BD-TO-BD 23P CN201
CN600
CP104
4P WAFER
BD-TO-BD 21P
CN209
E BR1 ASSY
(7028071133010-IL) CN5
4P WIRE
CP3
CN704B
27P FFC WAFER K G-T ASSY
(7028071123010-IL) D
3P WAFER
CP404
CP2
G-L ASSY
L (7028071125010-IL)
E
CN203
12P WAFER
B AMP ASSY
3P WIRE
CP201
(7028071141010-IL)
M G-H ASSY
(7028071124010-IL)
CN704
27P FFC WAFER
H FRONT ASSY F
(7028071131010-IL)
HTP-071 11
5 6 7 8
1 2 3 4
A
H FRONT ASSY
A INPUT ASSY
12 HTP-071
1 2 3 4
5 6 7 8
A
ONT ASSY
C MAIN ASSY
PUT ASSY
C MAIN ASSY
HTP-071 13
5 6 7 8
1 2 3 4
A D D-MAIN ASSY
B
I2C DATA
SUB MICO
EPF021A
4-IN 2-OUT Switch
74VHCU04
D
74LCX257MTCK
A_R IN
E A_L IN
TO INPUT PART
I2C CONTROL BLOCK
DIR
PCM9211
F
14 HTP-071
1 2 3 4
5 6 7 8
SN74LVC2GU04DCKR
UB MICOM CEC-U
PF021A EPF011C MAIN MICOM
CONTROL LINE
I2C DATA
FR OUT
TMS320DA788
FL OUT
TO INPUT PART
D
DA_CONVERTER
257MTCK SR OUT
DSP
PCM1681
SL OUT
C OUT
SW OUT
SBR OUT
E
SBL OUT
HTP-071 15
5 6 7 8
1 2 3 4
5. DIAGNOSIS
5.1 TROUBLESHOOTING
A
[1] DSP TROUBLESHOOTING
Yes
Step 2: Regulator IC To Step 5
D IC608 (pin 2)
(to chassis)
Yes
IC100 (pin 2)
(to chassis)
Yes
To Step 3
16 HTP-071
1 2 3 4
5 6 7 8
Step 5: DIR A
Check that the S/PDIF signal is output.
Check that changes by pulling out and inserting the digital input lines.
3: OPTICAL
IC600 (pins 3,11)
11: COXIAL
B
Can observe the No Check the path to pins 4, 8
digital signal? of IC600 or replace IC600.
(0 V ↔ 3.3 V)
Yes
IC602 (pin 20)
DIR_SCKO (master clock)
Yes
IC602 (pin 18)
DIR_LRCK (LR CLOCK)
C
Is there a LR clock No
Replace IC602.
output?
(0 V ↔ 3.3 V)
Yes
IC602 (pin 17)
DIR_SDTO (DATA)
Is there a DATA No
Replace IC602.
output?
(0 V ↔ 3.3 V)
Yes
IC602 (pin 19) D
DIR_BCK (bit clock)
No
Is there a master clock
output?
(0 V ↔ 2.5 V) E
Yes
IC101 (pin 7)
DAI_LRCK (LR CLOCK)
No
Is there a LR clock
output?
(0 V ↔ 2.5 V)
Yes Is the voltage of No Check the path between
IC101 pin 1 0V? IC101 pin 1 and MAIN Assy.
IC101 (pin 9) DAI_bck (bit CLOCK)
Yes
*IC101 pin 1
No Replace IC101. 0 V: DIR
Is there a bit clock
output? 3.3 V: HDMI F
(0 V ↔ 2.5 V)
Yes
To Step 6
HTP-071 17
5 6 7 8
1 2 3 4
A Step 6: DSP output (digital) to CODEC input Step 7: CODEC output (ANALOG)
Digital output of each CH when inputting the digital signal with audio. Analog output of each CH when inputting the digital signal with audio.
B
No Is there a audio signal No
Is there a LR clock
output? output?
(0 V ↔ 3.3 V)
Yes Yes
IC601 (pin 6) IC604 (pin 1)
front L/R data surround R out
To Step 7 End
E
18 HTP-071
1 2 3 4
5 6 7 8
A
[2] HDMI TROUBLESHOOTING
HDMI Troubleshooting
Cause for noncomplection of HDMI authentication between the source equipment and this unit.
(the HDMI indicator is unlit or flasher)
OK
Replace the HDMI cable. Replace the HDMI cable.
B
NG
OK
Connect the source equipment Repare the Receiver.
(player) to the Sink equipment
(monitor) directly.
NG
OK
Replace the Player. Repare the Player.
C
NG
OK
Replace the Monitor. Repare the Monitor.
D
Do screws of COAX jack No
Tighten screws securely. Sink equipment:
securely tighten? Connect a TV to HDMI OUT
Yes
To Step 1 POWER ON
To Step 2
HTP-071 19
5 6 7 8
1 2 3 4
No
Is the voltage 0 to 3.3 V? Diagonose the MAIN Assy.
Yes
IC207 (pin 4)
sub MICOM 3.3V
B
No
Is the voltage 3.3 V? Check the pin 5 of IC207.
Yes
CP104 (pins 1, 2)
HDMI_10V
No
Is the voltage 10 V? Diagonose the MAIN Assy.
Yes
IC609 (pin 3)
HDMI +5V
C
Yes
HDMI 3.3V
IC205 (pin 2) GND is equal of chassis
No No
Is the voltage 3.3 V? Is IC205 abnormally hot? Replace IC205.
Yes Yes
D
The output and GND may be short-circuited.
Check the path between them.
HDMI 2.0V
IC206 (pin 2)
No No
Is the voltage 2 V? Is IC206 abnormally hot? Replace IC206.
Yes Yes
IC200
No
Is IC200 abnormally hot? Replace IC200.
Yes
To Step 3
20 HTP-071
1 2 3 4
5 6 7 8
Yes Yes
* when connected the equipment to
CN601 (pin 7) JACK202 (pin 18) IN2 (BD): +5V_R315 (Not Insert)
CSCK_MAIN
B
Is there a data input? No No Check the JACK202. If JACK202
Diagonose the MAIN Assy. Is the voltage 5 V? is failure, replace JACK202.
(0 to 3.3 V)
Yes Yes
* when connected the equipment to
CN601 (pin 8) JACK203 (pin 18) IN3 (DVD): +5V_R316 (Not Insert)
SCDO_MAIN
Yes Yes
* when connected the equipment to IN4
To Step 4 JACK205 (pin 18) (DVR/BDR): +5V_R318 (Not Insert)
C
No
Is there a 24 MHz output? Replace IC201 or XTAL200.
Yes
IC200 (pin 97)
D
Yes
To Step 5
HTP-071 21
5 6 7 8
1 2 3 4
B
Does a signal output No Check the JACK204 and IC201.
in constant period If JACK204 or IC201 is failure,
(0 to 5 V)? replace JACK204 or IC201.
Yes
* when connected the equipment to
IC200 (pin 85) SDA IN1 (CD/SAT):
IC200 (pin 86) SCL
Yes
C * when connected the equipment to
IC200 (pin 83) SDA IN2 (BD):
IC200 (pin 84) SCL
Yes
* when connected the equipment to
IC200 (pin 81) SDA IN3 (DVD):
IC200 (pin 82) SCL
Yes
* when connected the equipment to
IC200 (pin 114) SDA IN4 (DVR/BDR):
IC200 (pin 115) SCL
Yes
To Step 7
22 HTP-071
1 2 3 4
B AMP ASSY C MAIN ASSY
R233
OVERLOAD DECTION CIRCUIT C219
D203
Q205
R227
5
5
Q209
R224 Q207
R263
R232
IC203
C211
R226
R220
R221
R255
(MAIN CPU)
R270
R223
R239
R222
R276
R234
R235
R236
R237
R238
85 PROTECTION1
D201 R225
Q206
R271
C235
R291
Q215
5.2 PROTECTION CIRCUIT
6
6
SPK.DC R240
PROTECTION R241
NORMAL:3.3V
R252
R242
ASO PROTECTION:0.83V
CIRCUIT
R273
C224
DC PROTECTION:1.45V
C220
Q210
Q217
R287
Q212
HTP-071
C232
R243
R244 R253
R245
R274
C225
7
7
C221
Q214
Q218
R288
Q213
C233
R54
C100
R57
Q16
R58 R60
8
8
Q15
R59
C98
R53
C99
23
F
E
B
A
D
C
1 2 3 4
5.3 IC INFORMATION
A
J046941000010-IL (EP94A1K)(D-MAIN ASSY: IC200)
HDMI 1.3 4-In 1-Out Repeater with Audio Output
DDC3_SDA
DDC1_SDA
DDC2_SDA
DDC1_SCL
DDC2_SCL
DDC3_SCL
EXT_RSTb
A_MUTE
PVDD18
AVDD33
AVDD18
AVDD18
IIS_SD1
IIS_SD3
IIS_SD2
DSD3R
DSD3L
VSSE
AVSS
AVSS
TXC+
TX2+
TX1+
TX0+
TXC-
TX1-
TX0-
TX2-
INTb
VDD
VSS
NC
68
67
66
65
95
93
91
89
87
85
83
81
79
77
75
73
71
69
96
94
92
90
88
86
84
82
80
78
76
74
72
70
X_IN 97 64 EXT_SWING
X_OUT 98
63 AVSS
VDDE 99
62 RX23+
VDD_PLL 100
61 RX23-
B PLL_XFC_A 101
60 AVDD
VSS_PLL 102
59 RX13+
VSS 103
58 RX13-
VDD 104
57 AVSS
VDD 105
56 AVDD33
SPDIF 106
55 RX03+
VSSE 107
54 RX03-
VSS 108
53 AVSS
MCLK 109
52 RXC3+
IIS_SCK 110
51 RXC3-
IIS_WS 111
50 PVDD/AVDD
IIS_SD0 112
49 AVSS/PVSS
VSS 113
48 RX22+
DDC0_SDA 114
47 RX22-
DDC0_SCL 115
46 AVDD
PH1 116
45 RX12+
PH2 117
44 RX12-
VSS 118
43 AVSS
VDD 119
42 AVDD33
VDD 120
41 RX02+
MCU_SDA 121
40 RX02-
C MCU_SCL 122
39 AVSS
VSS 123
38 RXC2+
VDDE 124
37 RXC2-
reserved 125
36 AVDD
NC 126
35 PVDD
NC 127
34 AVSS
NC 128
33 EXT_RES
11
13
15
17
19
21
23
25
27
29
31
10
12
14
16
18
20
22
24
26
28
30
32
1
2
3
9
4
8
RXC0+
AVSS
RX10+
AVDD
RX20+
AVSS
PVDD
AVDD
RX11+
RXC1-
RXC1+
AVSS
RX01-
RX01+
AVDD33
RX11-
AVDD
RX21-
RX21+
AVSS
RX00-
RX10-
RX00+
AVDD33
AVSS
AVSS
VDDE
PVSS
PVDD
AVDD
RXC0-
RX20-
• Block Diagram
D
MCU_SCL
INTb MCU_SDA
Registers
RX00+/- and
RX10+/- HDMI Control Logic
RX20+/- RX
RXC0+/- Input
DDC0_SDA Port 0 Secondary RX
DDC0_SCL
EDID 0
HDCP RX
HDMI RX
RX01+/-
RX11+/- HDMI
RX21+/- RX
E RXC1+/- Input
4-In 2-Out Switch
DDC1_SDA Port 1
DDC1_SCL
EDID 1
RX02+/-
2-In 1-Out Switch
RX22+/-
HDMI TX
Port A TX0+/-
RXC2+/- Input
HDCP RX
TX1+/-
HDMI RX
RX23+/-
OUT Processor
RXC3+/- Input
MCLK
Processor
DDC3_SDA Port 2
DDC3_SCL IIS_SCK
Audio
EDID 3 IIS_WS
F IIS_SD*/DSD*
SPDIF
HDCP Keys
24 HTP-071
1 2 3 4
5 6 7 8
A
• Pin Function
HDMI Input Ports
Name In/Out Description
RXC0- IN Differential Clock Input Pair for HDMI Input Port 0
RXC0+ IN Differential Clock Input Pair for HDMI Input Port 0
RX00- IN Differential Data Input Pair0 for HDMI Input Port 0
RX00+ IN Differential Data Input Pair0 for HDMI Input Port 0
RX10- IN Differential Data Input Pair1 for HDMI Input Port 0
RX10+ IN Differential Data Input Pair1 for HDMI Input Port 0
RX20- IN Differential Data Input Pair2 for HDMI Input Port 0
RX20+ IN Differential Data Input Pair2 for HDMI Input Port 0
B
RXC1- IN Differential Clock Input Pair for HDMI Input Port 1
RXC1+ IN Differential Clock Input Pair for HDMI Input Port 1
RX01- IN Differential Data Input Pair0 for HDMI Input Port 1
RX01+ IN Differential Data Input Pair0 for HDMI Input Port 1
RX11- IN Differential Data Input Pair1 for HDMI Input Port 1
RX11+ IN Differential Data Input Pair1 for HDMI Input Port 1
RX21- IN Differential Data Input Pair2 for HDMI Input Port 1
RX21+ IN Differential Data Input Pair2 for HDMI Input Port 1
RXC2- IN Differential Clock Input Pair for HDMI Input Port 2
RXC2+ IN Differential Clock Input Pair for HDMI Input Port 2
RX02- IN Differential Data Input Pair0 for HDMI Input Port 2
RX02+ IN Differential Data Input Pair0 for HDMI Input Port 2 C
RX12- IN Differential Data Input Pair1 for HDMI Input Port 2
RX12+ IN Differential Data Input Pair1 for HDMI Input Port 2
RX22- IN Differential Data Input Pair2 for HDMI Input Port 2
RX22+ IN Differential Data Input Pair2 for HDMI Input Port 2
RXC3- IN Differential Clock Input Pair for HDMI Input Port 3
RXC3+ IN Differential Clock Input Pair for HDMI Input Port 3
RX03- IN Differential Data Input Pair0 for HDMI Input Port 3
RX03+ IN Differential Data Input Pair0 for HDMI Input Port 3
RX13- IN Differential Data Input Pair1 for HDMI Input Port 3
RX13+ IN Differential Data Input Pair1 for HDMI Input Port 3
RX23- IN Differential Data Input Pair2 for HDMI Input Port 3 D
RX23+ IN Differential Data Input Pair2 for HDMI Input Port 3
EXT_RES IN External Termination Resistor for all HDMI Input Ports.
A resistor should tie this pin to AVDD33. 470 Ω is recommended.
HTP-071 25
5 6 7 8
1 2 3 4
A
• Pin Function
Audio Outputs
Name In/Out Description
MCLK OUT System Clock output for audio DAC (128/256/384/512 * FSampling_Clock. Connecting a pull-up
(logic 1) or pull-down (logic 0) resistor at this pin defines bit 4 of the slave IIC Address
IIS_SCK OUT IIS SCK output for IIS audio port. Sampling clock output for DSD.
IIS_WS OUT IIS WS output for all IIS audio ports. DSD audio output port 0 (Right Channel).
IIS_SD0 OUT IIS SD output for audio port 0 or HBR audio output. DSD audio output port 0 (Left Channel).
IIS_SD1 OUT IIS SD output for audio port 1 or HBR audio output. DSD audio output port 1 (Right Channel).
IIS_SD2 OUT IIS SD output for audio port 2 or HBR audio output. DSD audio output port 1 (Left Channel).
IIS_SD3 OUT IIS SD output for audio port 3 or HBR audio output. DSD audio output port 2 (Right Channel).
B
SPDIF OUT SPDIF output. DSD audio output port 2 (Left Channel).
DSD3R OUT DSD audio output port 3 (Right Channel).
DSD3L OUT DSD audio output port 3 (Left Channel).
A_MUTE OUT Audio Mute Output
DDC/IIC/MCU/EEPROM
Name In/Out Description
INTb OUT Interrupt signal. Asserted when interrupt requests occur. This pin is open drain output when
programmed as active low and external pull-up resistor is needed. This pin is push-pull when
programmed as active high.
MCU_SCL IN SCL signal for slave IIC port
C
MCU_SDA IO SDA signal for slave IIC port
DDC0_SCL IN IIC SCL signal for HDMI Receiver DDC Port 0
DDC0_SDA IO IIC SDA signal for HDMI Receiver DDC Port 0
DDC1_SCL IN IIC SCL signal for HDMI Receiver DDC Port 1
DDC1_SDA IO IIC SDA signal for HDMI Receiver DDC Port 1
DDC2_SCL IN IIC SCL signal for HDMI Receiver DDC Port 2
DDC2_SDA IO IIC SDA signal for HDMI Receiver DDC Port 2
DDC3_SCL IN IIC SCL signal for HDMI Receiver DDC Port 3
DDC3_SDA IO IIC SDA signal for HDMI Receiver DDC Port 3
Misc. Pins
D
Name In/Out Description
X_IN Analog External Crystal Input, 18.432 MHz
X_OUT Analog External Crystal Output, 18.432 MHz
PLL_XFC_A Analog For connecting a capacitor to ground for on-chip PLL
EXT_RSTb IN External Reset input (Active Low) with internal weak pull-up.
PH1 Analog Connect with 2 kΩ pull-up resistor to 3V3.
PH2 Analog Connect with 2 kΩ pull-up resistor to 3V3.
reserved IN Must be tied LOW for normal operation.
Power Pins
Name In/Out Description
E
AVDD PWR HDMI Receiver Analog Power (1.8 V)
PVDD PWR HDMI Receiver PLL Analog Power (1.8 V)
AVDD33 PWR HDMI Termination Power (3.3 V)
AVDD18 PWR HDMI Transmitter Analog Power (1.8 V)
PVDD18 PWR HDMI Transmitter PLL Analog Power (1.8 V)
AVSS, PVSS GND Analog Ground
VDDE PWR I/O Power (3.3 V)
VSSE GND I/O Ground
VDD PWR Internal Logic Power (1.8 V)
VSS GND Logic Ground
VDD_PLL GND Audio PLL Power (3.3 V)
F VSS_PLL GND Audio PLL Ground
26 HTP-071
1 2 3 4
5 6 7 8
A
8952VS3210020-IL (EPF021A) (D-MAIN ASSY: IC201)
Generic Microcontroller Unit
SPI_CLK
SPI_DO
X_OUT
P8[0]
P6[3]
P6[0]
P8[1]
P0[6]
P6[2]
P6[1]
P0[7]
X_IN
VDD
VDD
VSS
VSS
48
47
46
45
44
43
42
41
40
39
38
37
36
35
34
33
P2[1] 49 32 P0[5]
P2[2] 50 31 P0[4]
30
B
P2[3] 51 P0[3]
P2[4] 52 29 P0[2]
P2[5] 53 28 P0[1]
P2[6] 54 27 P0[0]
P2[7] 55 26 P5[7]
TIM[0] 56 25 P5[6]
TIM[1] 57 24 P5[5]
P1[0] 58 23 P5[4]
P1[1] 59 22 P5[3]
P1[2] 60 21 P5[2]
P1[3] 61 20 P5[1]
P7[0] 62 19 P5[0]
P7[1] 63 18 P7[4](CIR) C
P4[0] 64 10 17 VSS
11
12
13
14
15
16
1
2
3
4
5
6
7
8
9
RSTb
OP_MODE
DM
P4[1]
P3[0]
P3[1]
P3[2]
P3[3]
P3[4]
P3[5]
VDD
VSSA
ADC[1]
ADC[0]
VDDA
DP
• Block Diagram
D
Port 0
Port 1 256B Direct
KBI Data RAM
8051 Core 3KB Aux.
Port 2 Timer x 4
Data RAM
Port 3 LVI SPI
IIC
PMU 64KB Flash
Port 4 10-bit ADC x 2
Ex. Int. ICP E
Port 5
Hi Current
Port 6
Hi Current WDT
Port 7 USB 1.1
UART/CIR UART
Port 8
PWM IIC x 2
8-bit PWM x 2
F
CIR
HTP-071 27
5 6 7 8
1 2 3 4
A
• Pin Function
Name In/Out Buffer Type Description
OP_MODE IN IXDXXP Chip operation mode.
0: Normal mode
1: ICP (In Circuit Flash Programming) mode
RSTb IN BDUX8P External Reset (active low) with on-chip pull-up.
When this pin is asserted low, the chip is totally reset.
X_IN IN XTL24P 24 MHz crystal input
X_OUT OUT XTL24P 24 MHz crystal output
P0[7:0] IN/OUT BRXX12P GPIO port 0 with programmable Open Drain capability.
P1[3:0] IN/OUT BRUX8P GPIO port 1 or Keyboard Interrupt inputs with internal 20 kΩ pull-up to VDD
B
P2[7:1] IN/OUT BRXX8P GPIO port 2 with programmable Open Drain capability.
P3[5:0] OD IN/OUT BRXX8P Open Drain I/O port 3. P3[5:0] shared with IIC.
P4[1:0] IN/OUT BRXX8P GPIO port 4 or External Interrupt inputs
P5[7:0] IN/OUT BRXX24P GPIO port 5 with programmable Open Drain capability; 20 mA drive
P6[3:0] IN/OUT BRXX24P GPIO port 6 with 20 mA drive
P7[4,1:0] IN/OUT BRXX8P Open Drain I/O port 7. P7[1:0] shared with Serial Port. P7[4] share with CIR.
P8[1:0] IN/OUT BRXX8P GPIO port 8 with programmable Open Drain capability.
P8[7] and P8[3:0] share with PWM
TIM[1:0] IN/OUT BRXX8P Timer In/Out or GPIO
SPI_CLK IN/OUT BRXX8P SPI Clock Out or General Purpose Output
SPI_DO IN/OUT BRXX8P SPI Data In/Out or General Purpose Output
C DP IN/OUT USB USB D+ In/Out or GPO
DM IN/OUT USB USB D- In/Out or GPO
ADC[1:0] IN/OUT ADC ADC Inputs or GPIO
VDDA PWR — Analogue VDD (3.3 V)
VSSA PWR — Analogue Ground
VDD PWR — Digital VDD (3.3 V)
VSS PWR — Digital Ground
28 HTP-071
1 2 3 4
5 6 7 8
A
8952VS3210030-IL (EPF011C) (D-MAIN ASSY: IC203)
Generic MCU with 64K Embedded Flash
P7[0](RXD) 1 24 P1[1]
P7[1](TXD) 2 23 P8[7](PWM)
P4[1] 3 22 P2[1]
B
P3[0] 4 VSS
21
P3[1] 5 VDD
20
P3[4] 6 19 X_OUT
P3[5] 7
18 X_IN
RSTb 8
17 VSS
OP_MODE 9
16 VDD
C
P9[0] 10 15 P0[2]
P7[4](CIR) 11 14 P0[1]
P5[0] 12 13 P0[0]
• Block Diagram
D
Port 0
Port 1 256B Direct
KBI Data RAM
8051 Core 2KB Aux.
Port 2 Data RAM
Port 3 LVI
IIC
PMU 64KB Flash
Port 4
Ex. Int. ICP
Port 5
Hi Current WDT
Port 7
UART/CIR UART
Port 8
PWM IIC x 2
Port 9
GPIO 8-bit PWM x 1
CIR
F
Timer x 4
HTP-071 29
5 6 7 8
1 2 3 4
A
• Pin Function
Name In/Out Buffer Type Description
OP_MODE IN IXDXXP Chip operation mode.
0: Normal mode
1: ICP (In Circuit Flash Programming) mode
NOTE: The input crystal rate will be 24 MHz if this ICP mode is used.
30 HTP-071
1 2 3 4
5 6 7 8
A
PCM1681 (D-MAIN ASSY: IC601)
24-Bit, 192-kHz Sampling, Enhanced Multilevel Delta-Sigma, Eight-Channel Audio Digital-to-Analog Converter
ZR1/ZR1/FMT0 1 28 ZR2
MS/ADR/FMT1 2 27 VOUT1
MC/SCL/DEMP 3 26 VOUT2
MD/SDA/MUTE 4 25 VCOM
SCK 5 24 AGND2
DATA1 6 23 VCC2 B
BCK 7 22 VOUT3
LRCK 8 21 VOUT4
VDD 9 20 VOUT5
DGND 10 19 VOUT6
DATA2 11 18 AGND1
DATA3 12 17 VCC1
DATA4 13 16 VOUT7
MSEL 14 15 VOUT8
• Block Diagram
LRCK
Output Amp and VOUT2
DAC
Serial Low-Pass Filter
DATA1 (1, 2) Input
I/F Output Amp and VOUT3
DATA2 (3, 4) DAC
Low-Pass Filter
DATA3 (5, 6) D
DATA4 (7, 8) 8 VCOM
Output Amp and
Oversampling Enhanced DAC
Low-Pass Filter VOUT4
Digital Filter Multilevel
With Delta-Sigma
Function Modulator Output Amp and
DAC
Controller Low-Pass Filter VOUT5
MS/ADR/FMT1
Output Amp and
MC/SCL/DEMP DAC
Low-Pass Filter VOUT6
MD/SDA/MUTE Function
Control Output Amp and
I/F DAC
Low-Pass Filter VOUT7
E
MSEL Output Amp and
DAC
Low-Pass Filter VOUT8
System Clock
System Clock
SCK Zero Detect Power Supply
Manager
ZR2
AGND1
AGND2
VDD
VCC1
VCC2
DGND
ZR1/ZR1/FMT0
HTP-071 31
5 6 7 8
1 2 3 4
A
• Pin Function
32 HTP-071
1 2 3 4
5 6 7 8
A
J046921100710-IL (PCM9211) (D-MAIN ASSY: IC602)
216-kHz Digital Audio Interface Transceiver (DIX) with Stereo ADC and Routing
AGNDAD
GNDRX
VCCAD
VCOM
RXIN0
AGND
VINR
VINL
VC C
XTO
FILT
XTI
48 47 46 45 44 43 42 41 40 39 38 37
B
ERROR/INT0 1 36 VDDRX
NPCM/INT1 2 35 RXIN1
MPIO_A0 3 34 RST
MPIO_A1 4 33 RXIN2
MPIO_A2 5 32 RXIN3
MPIO_A3 6 31 RXIN4/ASCKIO
PCM9211
MPIO_C0 7 30 RXIN5/ABCKIO
MPIO_C1 8 29 RXIN6/ALRCKIO
C
MPIO_C2 9 28 RXIN7/ADIN0
MPIO_C3 10 27 MODE
MPIO_B0 11 26 MS/ADR1
MPIO_B1 12 25 MC/SCL
13 14 15 16 17 18 19 20 21 22 23 24
DVDD
DOUT
DGND
MPO0
MPO1
SCKO
MPIO_B2
BCK
MDI/SDA
LRCK
MPIO_B3
MDO/ADR0
HTP-071 33
5 6 7 8
1 2 3 4
A
• Block Diagram
FILT
AUXIN 0
AUTO
RXIN7
RXIN 0 RXIN0 DIR DIR SCKO
DOUT
RXIN 1 RXIN1 ADC MAIN BCK
PLL
AUXIN0 OUTPUT LRCK
RXIN 2 RXIN2
SCKO/ BCK/LRCK
PORT
B RXIN 3 RXIN3 AUXIN1 DOUT
DIR
DITOUT RECOUT 1
C RECOUT0
MPO 0
RECOUT1 MPO0/1
SELECTOR MPO 1
ADC DITOUT
VINL
ADC Mode
VINR ADC Control
VCOM
Com. Supply
AUTO
ADC Clock
(SCK /BCK/LRCK)
XTI Divider
XTO OSC
34 HTP-071
1 2 3 4
5 6 7 8
A
• Pin Function
No. Name In/Out Description
1 ERROR/INT0 O DIR Error detection output / Interrupt0 output
2 NPCM/INT1 O DIR Non-PCM detection output / Interrupt1 output
3 MPIO_A0 I/O Multipurpose I/O, Group A(1)
4 MPIO_A1 I/O Multipurpose I/O, Group A(1)
5 MPIO_A2 I/O Multipurpose I/O, Group A(1)
6 MPIO_A3 I/O Multipurpose I/O, Group A(1)
7 MPIO_C0 I/O Multipurpose I/O, Group C(1)
8 MPIO_C1 I/O Multipurpose I/O, Group C(1)
9 MPIO_C2 I/O Multipurpose I/O, Group C(1)
B
10 MPIO_C3 I/O Multipurpose I/O, Group C(1)
11 MPIO_B0 I/O Multipurpose I/O, Group B(1)
12 MPIO_B1 I/O Multipurpose I/O, Group B(1)
13 MPIO_B2 I/O Multipurpose I/O, Group B(1)
14 MPIO_B3 I/O Multipurpose I/O, Group B(1)
15 MPO0 O Multipurpose output 0
16 MPO1 O Multipurpose output 1
17 DOUT O Main output port, serial digital audio data output
18 LRCK O Main output port, LR clock output
19 BCK O Main output port, Bit clock output
20 SCKO O Main output port, System clock output
21 DGND — Ground, for digital C
22 DVDD — Power supply, 3.3 V (typ.), for digital
23 MDO/ADR0 I/O Software control I/F, SPI data output / I2C slave address setting0(2)
24 MDI/SDA I/O Software control I/F, SPI data input / I2C data input/output(2) (3)
25 MC/SCL I Software control I/F, SPI clock input / I2C clock input(2)
26 MS/ADR1 I Software control I/F, SPI chip select / I2C slave address setting1(2)
27 MODE I Control mode setting, (see the Serial Control Mode section, Control Mode Pin Setting)
28 RXIN7/ADIN0 I Biphase signal, input 7 / AUXIN0, serial audio data input(2)
29 RXIN6/ALRCKI0 I Biphase signal, input 6 / AUXIN0, LR clock input(2)
30 RXIN5/ABCKI0 I Biphase signal, input 5 / AUXIN0, bit clock input(2)
31 RXIN4/ASCKI0 I Biphase signal, input 4 / AUXIN0, system clock input(2)
32 RXIN3 I Biphase signal, input 3(2) D
33 RXIN2 I Biphase signal, input 2(2)
34 RST I Reset Input, active low(2) (4)
35 RXIN1 I Biphase signal, input 1, built-in coaxial amplifier
36 VDDRX — Power supply, 3.3 V (typ.), for RXIN0 and RXIN1.
37 RXIN0 I Biphase signal, input 0, built-in coaxial amplifier
38 GNDRX — Ground, for RXIN
39 XTI I Oscillation circuit input for crystal resonator or external XTI clock source input(5)
40 XTO O Oscillation circuit output for crystal resonator
41 AGND — Ground, for PLL analog
42 VCC — Power supply, 3.3 V (typ.), for PLL analog
43 FILT O External PLL loop filter connection terminal; must connect recommended filter
E
44 VCOM O ADC common voltage output; must connect external decoupling capacitor
45 AGNDAD — Ground, for ADC analog
46 VCCAD — Power supply, 5.0 V (typ.), for ADC analog
47 VINL I ADC analog voltage input, left channel
48 VINR I ADC analog voltage input, right channel
(1) Schmitt trigger input
(2) Schmitt trigger input
(3) Open-drain configuration in I2C mode
(4) Onboard pull-down resistor (50 kΩ, typical)
(5) CMOS Schmitt trigger input
HTP-071 35
5 6 7 8
1 2 3 4
6. SERVICE MODE
6.1 SERVICE MODE
A
[1] Display mode for numbers of protection detections
[Purpose]
The numbers of detections for various protection processes are displayed.
[How to enter/exit]
During Standby mode, simultaneously press and hold the [PRESET –] and [STANDBY/ON] keys for 2 seconds to enter
this mode.
The display will return to the normal indication when no key operation is performed for 5 seconds.
B [Basic operations]
(STANDBY state)
[PRESET –] +
[STANDBY/ON] keys
(Initial display)(press DC : 005 5 (-> normal) *1 Number of DC error detections
the keys for 2 seconds.) Counter
C
D
[ENTER] key OVER : 0 0 3 5 (-> normal) *1 Number of OVERLOAD error detections
Counter
(Initial display)
*1 "5 (-> normal)" denotes that the display will return to the normal indication when no key operation is performed
for 5 seconds.
*2 Variable range: 0 to 255
36 HTP-071
1 2 3 4
5 6 7 8
A
[2] Reset mode for numbers of protection detections
[Purpose]
For clearing all the counts of protection detections.
(This mode resets the counts of protection detections.)
[How to enter/exit]
During Standby mode, simultaneously press and hold the [ALC/STANDARD SURR] and [STANDBY/ON] keys
for 10 seconds to enter this mode.
The display will return to the normal indication when no key operation is performed for 5 seconds.
B
[Basic operations]
(STANDBY state)
[ALC/STANDARD SURR]
+ [STANDBY/ON] keys
(press and hold the keys
for 10 seconds.) CL EAR? 5 (-> normal) *1
C
[ENTER] key
*1 "5 (-> normal)" denotes that the display will return to the normal indication when no key operation is performed
for 5 seconds. D
*2 Indication when the BD function is selected
[Detailed explanations]
1. When the procedures for Reset mode for numbers of protection detections are completed, all the counters will be
reset to "000."
2. Prohibitions:
The protection detection counts cannot be cleared (reset to 000) with the MEMORY CLEAR process.
They can only be cleared when the procedures of Reset mode are completed.
HTP-071 37
5 6 7 8
1 2 3 4
B
Normal Operations
*1
Is THER_DET No
detected?
Yes
Prohibit detection of
THER_DET for 2 min.
38 HTP-071
1 2 3 4
5 6 7 8
7. DISASSEMBLY
7.1 VSX-321-K-P
Note: A
(1) Even if the unit shown in the photos and illustrations in this manual may differ from your product, the
procedures described here are common.
(2) For performing the diagnosis shown below, the following jigs for service is required:
• Board to board extension jig cable (GGD1736)
• Board to board extension jig cable (GGD1772)
• 3P extension jig cable (GGD1773)
1. Discharging B
[1] MAIN Assy Capacitor (C55, C58)
[Procedures]
(1) Unplug the power cord.
(2) Connect J35 (B+) and J57 (B–), using resistor leads with 47 - 100 ohms (2 W or higher), for discharging.
∗ Discharging time: 30 - 60 seconds, depending on the level of resistance.
(3) Check that the voltage between the B+ and B– terminals is less than 1 V, using a tester.
∗ Be sure to connect the GND terminal of the tester to the chassis.
∗ If the voltage is still 1 V or higher, repeat Step (2).
MAIN Assy
J35 (B+) 47 - 100 ohms
J57 (B−) (2 W or higher)
C58 C55
CN704
27 1 FRONT Assy
47 - 100 ohms
(2 W or higher)
HTP-071 39
5 6 7 8
1 2 3 4
A
2. Notes on Disassembly and Reassembly
Confirmation of Connection
After completion of reassembly, before plugging the power cord into an outlet, make sure that the 4P wires from CN5 of
the MAIN Assy are connected to CP104 of the D-MAIN Assy.
If the unit is turned ON without these wires connected, the CODEC IC (IC602) on the D-MAIN Assy
may be damaged.
B D-MAIN Assy
CP104
GND wire
(Be sure to disconnect the GND wire
before reassembly.)
40 HTP-071
1 2 3 4
5 6 7 8
A
3. Disassembly
B
1 1 1 1 1
• Bottom view
3 3
4 E
HTP-071 41
5 6 7 8
1 2 3 4
A
[2] Heatsink Section
Caution: Heatsink section in work becomes hot,
and be careful with it.
Remove the cabinet by removing the 10 screws.
• Bottom view
C
(2) Remove the seven screws.
(BBZ30P080FTC) G-L Assy
2 2
2 2 2 2
3 3
42 HTP-071
1 2 3 4
5 6 7 8
CP404
AMP Assy
D
Heatsink
• Rear view F
HTP-071 43
5 6 7 8
1 2 3 4
A
(3) Cut the binder. BR1 Assy
(4) Disconnect the two B to B connectors.
(CN600, CN601) 5 4
(5) Remove the D-MAIN and DG Assemblies. CN209
CN600
3
CNT Assy
D-MAIN Assy
5 DG Assy
B 4
CN1000 CN601
CP201
9
Insulation sheet
44 HTP-071
1 2 3 4
5 6 7 8
A
[4] MAIN Assy
Remove the cabinet by removing the 10 screws.
3 1
1 1 B
1
1 1
1 1 1
MAIN Assy F
HTP-071 45
5 6 7 8
1 2 3 4
B 1
2 2 2 2
3 3 3 3
Note:
While securing the regulator ICs and rectifier diode to the holes for
temporary joining, tighten the screws while holding the regulator ICs
E and rectifier diode with your fingers so that the jumper wires will not
become distorted.
46 HTP-071
1 2 3 4
5 6 7 8
[4-4] Diagnosis A
(1) Remove the one screw and remove the earth
lead jumper. (BBZ30P080FTC)
(2) Reassemble the earth lead jumper. Earth lead jumper Earth lead jumper
2
1
B
G-H Assy G-H Assy
7.2 S-22W-P
Orientation of the Speaker during Attachment
Rear
E
Attach the speaker so that the terminals
are placed nearer the rear.
• Bottom view
HTP-071 47
5 6 7 8
1 2 3 4
7.3 S-11-P
Fig.1
Fig.2
D
Fig.3
48 HTP-071
1 2 3 4
5 6 7 8
Refer to this section when updating the firmware of each microcomputer is required by the service information, etc.
10P
PC
RS-232C
Straight cable
10P to 10P FFC
To confirm if .NET Framework 3.0 Service Pack 1 has been installed on your PC or not, select Settings > Control Panel >
Add or Remove Programs. This confirmation method may be different, depending on the PC. Refer to the operation
manual of the PC you use on how to execute Add or Remove Programs.
HTP-071 49
5 6 7 8
1 2 3 4
A
Connect as shown in the figure below.
Insert the FFC with its contact surface facing the " mark.
PC 10P
USB cable
(HDMI/CEC microcomputer)
10P
USB cable
A type <-> B type
Microcomputers update
[Procedures]
for MAIN microcomputer
1. Unplug the AC cord. [ if the following messages are displayed ]
C
Connect the FFC cable. ( MAIN microcomputer )
Start up application FlashSta on the PC.
2 Enter ID.
Enter "ff" in all field.
2 Enter ID.
50 HTP-071
1 2 3 4
5 6 7 8
A
5. Set speed update and update the MCU.
1 Set speed of update.
If the following messages are displayed, shut the update Connect the PC and the Upgrade Jig. E
program down, and start the update again from step 1. Connect the FFC cable. (HDMI microcomputer )
Plug the AC cord. (STANDBY mode)
Push the JIG’s RESET button during
1 sec.
Press the OK button. 10. While holding down the tact switch of the Upgrade Jig,
press STANDBY/ON button.
After 2 or 3seconds, release the tact switch button.
Select the 9600 of the Board rate then
press the OK button
HTP-071 51
5 6 7 8
1 2 3 4
A
11. Select the update file. Press the "OpenFile" button. End the application EPFlash.
B
If the following messages are displayed, shut the update
program down, and start the update again from step 8.
14. Turn the unit off (STANDBY mode) and unplug the
AC cord.
Disconnect the FFC cable.
F
Connect the PC and the Upgrade Jig.
Connect the FFC cable. (CEC microcomputer )
Plug the AC cord. (STANDBY mode)
52 HTP-071
1 2 3 4
5 6 7 8
A
17. Select the update file. Press the "FILE" button. 19. Press the button.
When the update file is selecting, the check box is Rate of the progression is appeared.
C
automatically on.
21. Update Finished CEC microcomputer.
18. While holding down the tact switch of the Upgrade Jig,
If the following messages are displayed, shut the update D
press STANDBY/ON button.
After 2 or 3seconds, release the tact switch button. program down, and start the update again from step 19.
E
22. Turn the unit off (STANDBY mode) and unplug the
AC cord. Disconnect the FFC cable.
Check to the software virsion of MAIN, HDMI (SUB) and CEC microcomputers
23. Make sure that the main unit is in STANDBY mode.
Press and hold the " ENTER " and " STANDBY/ON " keys, then press the " ENTER "key to display each UCOM version.
Each time the " ENTER "key is pressed, then indications on the FL display change as follows:
F
"ENTER"
HTP-071 53
5 6 7 8
1 2 3 4
- For the applying amount of lubricants or glue, follow the instructions in this manual.
Tape (Clear)
B
Power cord
SYXE8, AXE5
only
×4
SYXE8
×20 only
or or
C
SYXE8,
DLPWXE
only
S-22W-P
F Top
SET
(Side)
54 HTP-071
1 2 3 4
5 6 7 8
6 S-11-P Total Assy See Contrast table (2) 21 Poly-Bag (Set) 8952S21W05180-IL
7 Speaker Cord (4 m) 8952S11005480-IL 22 Cushion, Snow 6230212914000-IL
8 Speaker Cord (10 m) 8952S11005490-IL 23 PE, Sheet 6327040059000-IL
9 Brackets for Wall Mounting 8952S11005500-IL 24 Band Packing 8952SHM700046-IL
10 Non-Skid Pads 8952S11005510-IL 25 Box, Gift See Contrast table (2)
B
11 Screw (M5) 8952S11005520-IL 26 Packing Top S-11-P 8952S11005541-IL
12 Operating Instructions (CD-ROM) See Contrast table (2) 27 Packing Top S-11-P 8952S11005542-IL
13 Operating Instructions See Contrast table (2) 28 Packing S-22W-P 8952S22W05191-IL
14 Operating Instructions See Contrast table (2)
15 Operating Instructions See Contrast table (2)
14 Operating Instructions (En/Fr) Not used 5707000006100-IL Not used Not used
15 Operating Instructions (En/Zhtw) Not used Not used 5707000006090-IL Not used
16 Operating Instructions (Zhcn) Not used Not used Not used 5707000006080-IL D
17 Operating Instructions (En/Fr) Not used 5707000006210-IL Not used Not used
18 Operating Instructions (En/Zhtw) Not used Not used 5707000006220-IL Not used
19 Operating Instructions (Zhcn) Not used Not used Not used 5707000006230-IL
NSP 20 Warranty Card EU ARY7127 Not used Not used ARY7137
25 Box, Gift 6007211970030-IL 6007211970020-IL 6007211970010-IL 6007211970000-IL
HTP-071 55
5 6 7 8
1 2 3 4
A
DLPWXE
only
N
B
C
L
Cushion EVA
H
E
F
Nut
F Nut
56 HTP-071
1 2 3 4
5 6 7 8
×23
I
C
K
E A D
Silicon adhesive
(GYA1011)
C
E
M
Heatsink
Silicon grease
(GEM1057)
HTP-071 57
5 6 7 8
1 2 3 4
6 DG Assy 7028071111010-IL 36 • • • • •
7 INPUT Assy 7028071112010-IL 37 • • • • •
8 AMP Assy 7028071141010-IL 38 Support 4070001601010-IL
9 CNT Assy 7028071151010-IL 39 Clamp MTG 4330000310000-IL
10 MAIN Assy See Contrast table (2) 40 Window Display 421U 5077213113000-IL
> 16 Power Trans. See Contrast table (2) 46 Cover See Contrast table (2)
17 Posistor F320301022240-IL 47 Cover See Contrast table (2)
> 18 Transistor J5011560P0000-IL 48 • • • • •
> 19 Transistor J5032390P0000-IL 49 • • • • •
> 20 Transistor J5032390Y0000-IL 50 Screw BBT30P100FTB
C
61 Screw 1500001456010-IL
58 HTP-071
1 2 3 4
5 6 7 8
E
S-22W-P SECTION PARTS LIST
Mark No. Description Part No.
1 Unit Assy 8952S22W00009-IL
2 Network Assy 8952S22W00011-IL
3 Speaker Terminal 8952S22W00004-IL
4 Foot Mold 8952S22W00007-IL
5 Foot Cushoin 8952S22W00200-IL
6 Cashmere 8952S22W00210-IL
7 Screw (Bind Head) 8952SHM700039-IL F
8 Screw (Bind Head) 8952S21W05381-IL
HTP-071 59
5 6 7 8
1 2 3 4
A
Front L, R, Surround L, R speaker
Center speaker
60 HTP-071
1 2 3 4
5 6 7 8
6 Felt 8952S11005411-IL
7 Cassimere 8952S11005430-IL
8 Screw 8952SB3001110-IL
9 Screw (Bind Head) 8952S11005150-IL
Center speaker
1 Unit Speaker (Front) 8952S11005090-IL
2 Speaker Wire 8952S11005140-IL
3 Speaker Terminal 8952S11005100-IL
4 Frame Net Assy 8952S11005030-IL
5 Case Rear Assy 8952S11005060-IL
C
6 Felt 8952S11005411-IL
7 Cassimere 8952S11005130-IL
8 Screw 8952SB3001110-IL
9 Screw (Bind Head) 8952S11005150-IL
HTP-071 61
5 6 7 8
1 2 3 4
R509 R516
0 0
C443 (SBL)
R438 R439 10/50
(SBL)
R437
(C)
(SW)
(FL)
(SL)
100 0 2K
C445 -
R445 R446
R440
R441
100P-J
C444
47K
Q409
- 10K
-
Q408 - INC2001AC1
C424
47N-K
47N-K
47N-K
47N-K
47N-K
47N-K
47N(EB)-100V
C412
C413
C414
C415
C416
C417
C411
47N-K
Q412
Q411 - INC2001AC1
100P-J
R422
4K7
47N-K
C450
C451 -
R453
47K
R450
C418
R451 R452
- 10K C453 -
R454 R455 R456
C423
100 0 2K 10/50 22N(EB)-100V
LUG500
150N(R)-63V
1P200mm
100/16
100/16
100/16
C427
100/16
100/16
C433
10/50
10/50
10/50
C434
C425
C429
C430
C431
C428
C432
B
C457 C441
R462 R463 10/50 10N-K
R461 0 30 29 28 27 26 25 24 23 22 21 20 19 18 17 16 15 14 13 12 11 10 9 8 7 6 5 4 3 2 1
100 2K
-
R467 R468
100P-J
R447
C459
R465
R466
31
47K
Q415
- 10K 32
-
INC2001AC1
100P-J
C465
10/16-Z8154
-
C455 37
R475 R476
R485
47K
R473
- 10K 38
(SW)
-
39
R487 R488 R489 C467 C458 10/16-Z8154 (SL) 40 IC400
100 0 2K 10/50 C461 10/16-Z8154 R2A15218FP
41
R472 100 C462 10/50 (FL) 42
C464 10/50
43
470K
470K
470K
470K
470K
470K
470K
R469 44
100
45
46
R479
R477
R478
R480
R482
R483
R486
R491
0 47
48
49
C 50
JACK400
(CD) 51 52 53 54 55 56 57 58 59 60 61 62 63 64 65 66 67 68 69 70 71 72 73 74 75 76 77 78 79 80
C473
R423 10N-K
330 C410 C477
R424
C437 C422
220P-J 220P-J
100P-J 470K
0
C436
100P-J
R504 R505
R430
R511 470
R512 470
100P-J
C480
R431 - 10K
-
470K
470K
C440
470K
470K
470K
470K
470K
470K
470K
470K
470K
470K
R434 10/50 470K R503
330
C487 10/50
R604
470K
R542
R558
R555
R586
R481
R547
R578
R596
R587
R580
(TU)
R591
R594
C490 10/50
470K
R519
R490 C468 R518
330 470K
R493
220P-J220P-J
C472 C470
10/50 R492
C469 470K
-
100P-J
C471
R496
-
100P-J R495
R498 C476
10/50 470K
330
D C508
10N-K
R521
220P-J
330 C492
R522
JACK401 C509
C494
10/50 R523
G607-902AA-560YS C493 470K 10/50 C503
-
100P-J
IC401(1/2)
AZ4580
220P-J
C497
C496
R527
-
100P-J R528
C498 R544 R539 R540
R530 470K 4 3
330 10/50 1K
680P-J
4K7 4K7
1
C507 2
10/50
C512 R549 C513
C511
R548
3N3-K 5K6 10/16-Z8154
R551
100K
100K
R554
R532 C514 1K5
220P-J
R559
C505
C504 IC403(2/2)
R537
8 6
-
10/16-Z8154
C527
2SK117Y
C529 C528
10N-K 10N-K
(SW)
(TU)
10N-K
C534
C546 C547
10N-K
C533
A C 1/2 CP17
62 HTP-071
1 2 3 4
5 6 7 8
10K
(SL)
R410
D404 Q402 47K
KDS4148U INC2001AC1
R414 (SL) CN400
D403 C406 R415 470 C407
- 2.0MM-12P
1K KDS4148U 10/50 R420
47N-K
47N-K
47N-K
C416
C417
R421
10K 47K C409
Q405
D406 INC2001AC1 -
47N-K
C418
KDS4148U C419
R426 (C) -
C420 R427 470
1K 10/50 C426
R428 -
B CP201
R429
D405
47K
10K
KDS4148U C435
D408 -
KDS4148U Q406
100/16
C433
10/50
10/50
C434
INC2001AC1
C432
1N-K
93 6 8
R464
KDS4148U R502 10K
47K
92 R507 - C438
R513 1K5 Q413 100P-J
91 47K INC2001AC1
C481
90 C484
89 R515 47P-J
88 3K9 C485
87 10N-K
R406 470K C486
86 10/50
R411 470K
85
84
(CD)
83 (SW)
82
81 C
9 70 71 72 73 74 75 76 77 78 79 80 (FL)
R499
0
: Audio Signal Route (Front L ch)
R501 470K
(SL)
: Audio Signal Route (Surround L ch)
C478 220N-K (C)
R508
: Audio Signal Route (Center ch)
470K
470K
470K
470K
470
(SW)
Q419
RT1P141C : Audio Signal Route (SubWoofer ch)
R514
(SBL)
R481
R596
R591
R594
10K
: Audio Signal Route (Surround Back L ch)
(TU)
R526 0
23
22
21
(SBL)
R563 1K 20
19
2N2-K
18
C518 R567 1K
17
2N2-K
(SW)
16
C521 R570 1K
15
2N2-K
14
2N2-K
(SL)
E CN210
12
C524 R579 1K
11
2N2-K
10
C525 R581 1K
9
2N2-K
(FL)
8
C530 R584 1K
7
2N2-K
6
C531 R585 1K
5
2N2-K
E
4
C532
3
2
1
LUG007
-
F
- When ordering service parts, be sure to refer to "EXPLODED VIEWS and PARTS LIST" or "PCB PARTS LIST".
- The > mark found on some component parts indicates the importance of the safety factor of the part.
Therefore, when replacing, be sure to use parts of identical designation.
- : The power supply is shown with the marked box.
A
HTP-071 63
5 6 7 8
1 2 3 4
A
B AMP ASSY (7028071141010-IL)
R203SR
100P-500V
7K5
R217SR
C209SR
5K6(1)
R227SR
2SD2390Y
2K2
Q205SR
R205SR C207SR R218SR
R216SR
5K6(1)
KTC3200BL
C211SR
R220SR
R223SR R221SR
27K
0R47(2)
0R47(2) 0R47(2)
22N
220P-500V 33P-500V
R214SR
C201SR R201SR Q202SR R206SR
R212SR R213SR
KSA992F
3K
R222SR
Q201SR
0R47(2)
R207SRC205SR
33K
100/10
10/50 220 Q204SR
C208SR
75
KSA992F
10/50
R204SR 2SC3964
R225SR
C202SR
330K
33K
680P
820
1K5
R208SR R219SR C
1SS133T
D201SR
R210SR C206SR
100P-500V
C210SR
1N
R211SR
R209SR
47(1/4)
1K2
470
(FL)
C CP201
R203SL
100P-500V
R217SL
C209SL
(FL)
5K6(1)
7K5
R227SL
12 11 10 9 8 7 6 5 4 3 2 1
2SD2390Y
2K2
CN400
Q205SL
(SL) R2056SL C207SL R218SL
5K6(1)
KTC3200BL
C211SL
R220SL
R221SL
0R47(2)
0R47(2)
27K
10/50
22N
220P-500V 33P-500V
R214SL
C201SL R201SL Q202SL R206SL (SL)
A
KSA992F
R212SL R213SL
3K
Q201SL
R207SL C205SL
R223SL
33K
R222SL
0R47(2)
0R47(2)
100/10
220
75
10/50
C208SL
KSA992F
10/50
Q204SL
(SW) R204SL 2SC3964
R225SL
C202SL
330K
33K
680P
820
1K5
R208SL R219SL
47K 47(1/4)
Q203SL Q206SL
KTC3200BL 2SB1560Y
1SS133T
D201SL
R210SLC206SL
100P-500V
C210SL
1N
R211SL
R209SL
47(1/4)
1K2
470
(C)
R203SW
7K5
C201C R
100P-500V
R217SW
C209SW
5K6(1)
R227SW
2SD2390Y 10/50
2K2
Q205SW
R205SW C207SW R218SW
E 470K 47/50(6.3*11) 47(1/4) R226SW
R224SW Q207SW
75K
R216SW
C203SW C204SW
5K6(1)
KTC3200BL
C211SW
R220SW
R223SW R221SW
0R47(2)
0R47(2) 0R47(2)
27K
22N
220P-500V 33P-500V
R214SW
C201SW R201SW Q202SW R206SW (SW)
R212SW R213SW
KSA992F
3K
R222SW
Q201SW
C205SW
0R47(2)
33K
100/10
10/50 220
75
C208SW
KSA992F Q204SW
10/50
R204SW
R225SW
2SC3964
C202SW
R207SW
330K
33K
680P
820
1K5
R208SW R219SW
47K 47(1/4)
1SS133T
Q206SW
D201SW
Q203SW
KTC3200BL 2SB1560Y
R210SWC206SW
100P-500V
C210SW
1N
R211SW
R209SW
47(1/4)
1K2
470
B
64 HTP-071
1 2 3 4
5 6 7 8
100P-500V
R217FR
C209FR
5K6(1)
R203FR
R227FR
2SD2390Y
7K5
2K2
Q205FR
R205FR C207FR R218FR
R216FR
5K6(1)
KTC3200BL
C211FR
R220FR
R221FR
27K
0R47(2)
0R47(2)
22N
220P-500V 33P-500V
R214FR
C201FR R201FR Q202FR R206FR
KSA992F
R212FR R213FR
3K
R222FR
R223FR
Q201FR
R207FRC205FR
0R47(2)
33K
0R47(2)
100/10
75
10/50 220
B
C208FR
KSA992F Q204FR
10/50
R204FR
R225FR
2SC3964
C202FR
330K
33K
680P
820
1K5
R208FR R219FR
100P-500V
2SB1560Y
C210FR
KTC3200BL
R210FR C206FR
1SS133T
D201FR
1N
R211FR
R209FR
47(1/4)
1K2
470
CP202
C217
100P-500V
R217FL
C209FL
10/100(6.3*11)
5K6(1)
R203FL
C212
R227FL
2SD2390Y
7K5
10/100(6.3*11) C218
2K2
R205FL C207FL R218FL
Q205FL
R228 10/100(6.3*11) C
470K 47/50(6.3*11) 47(1/4) R226FL 10(1)
R224FL Q207FL
C203FL C204FL 75K
R216FL
5K6(1)
KTC3200BL
C211FL
R220FL
R221FL
27K
0R47(2)
0R47(2)
22N
Q201FL
R207FL C205FL
R222FL
R223FL
33K
0R47(2)
0R47(2)
100/10
KSA992F (SL)
75
Q204FL
10/50
R204FL
2SC3964
C215 (C)
R225FL
C202FL
330K
33K
680P
D202
820
4.7/50
1K5
22K
22K
22K
22K
22K
KTA1268BL
22K
R219FL 1SS133T
R208FL
Q208
R230SW
47K 47(1/4)
R230SR
Q206FL
R230SL
R230FR
R230FL
Q203FL
R230C
R230
15K
KTC3200BL 2SB1560Y
1SS133T
R210FL C206FL
D201FL
CN203
100P-500V
1N
C210FL
R211FL
R209FL
47(1/4)
1K2
470
(SW)
330/6.3(6.3*11)
330/6.3(6.3*11)
D
R231
15K
C213
C216
(SL)
100P-500V
5K6(1)
R217C
C209C
R203C
R227C
7K5
2K2
2SD2390Y
R205C C207C R218C Q205C
KTC3200BL
R216C
27K
0R47(2)
C211C
0R47(2)
R221C
R220C
22N
220P-500V 33P-500V
R214C
C201C R201C Q202C R206C
KSA992F
R213C
3K
Q201C
75
0R47(2)
C205C
33K
0R47(2)
R222C
100/10
R223C
10/50 220
C208C
KSA992F
10/50
Q204C
R204C 2SC3964
R225C
330K
C202C
R212C
R207C
33K
E
680P
820
1K5
R208C R219C
47K 47(1/4)
Q203C Q206C
KTC3200BL
1SS133T
D201C
2SB1560Y
R210C C206C
100P-500V
1N
C210C
47(1/4)
R211C
R209C
1K2
470
(FL)
: Audio Signal Route (Front L ch)
(SL)
(SW) : Audio Signal Route (Surround L ch)
(C)
: Audio Signal Route (Center ch)
(SW) F
: Audio Signal Route (SubWoofer ch)
B
HTP-071 65
5 6 7 8
F
E
B
A
D
C
66
FROM MAIN TRANS
GND2
C 1/2
GND
35328-0360
1 2 3 3 2 1 5 4 3 2 1
CP3
CP1
CP2
1
1
5267-03A
35313-0360
R27 C64
0R22(1) 100N(EB)-100V
R25
R42
R41
10(1)
0R22(1)
0R22(1)
C61
R39 150(1)
C81
RLY1
R31
47N(EB)-100V
F1 100N(R)-250V
R38
100N(EB)-100V
OPEN C65 330(2)
C83
330(2)
C82
(HP) R37
R40 150(1)
C66
C70 C69 R26
100N(R)-250V
-
47N(EB)-100V
47N(EB)-100V
- - JACK1
0R22(1)
D7
C5 C6
2N2-K 47N(EB)-100V
R79 L1FR
GBJ1006
-
SP-2507
C68
C4 C2 C3
C67
C71 - 2N2-K
100N(R)-250V
47N(EB)-100V
10.3 MAIN ASSY (1/2)
R7 47N(EB)-100V RLY2
C72 100N-K 47K(1/4) 47K(1/4) 10(1) R8 HL3-2A-12S (FL)
100N(R)-250V
TO CHASSIS
R36 R35 10(2)
(HP)
6800/63(30*40) 6800/63(30*40) L1FL
D10
C55
D13
D12
D11
C58 SP-2507 (FL) (FL)
1N4007
1N4007
1N4007
1N4007
(HP)
C9
R9 47N(EB)-100V
2
2
D9
10(1)
R10
L1SR 10(2)
KBPC604-6A
SP-2507
(C)
C13 JACK2
C73 C14
6800/16(16*31.5) C12 2N2-K 47N(EB)-100V
B
R13 47N(EB)-100V
2
10(1) R12
3
C10 C11
10(2)
C84
C85
C74 L1SL 2N2-K 47N(EB)-100V
4
10N-K SP-2507 (SL)
1000/25(10*20)
RLY4
4700/25(16*31.5)
(SL)
C17
6
HL3-2A-12S C18 C19
R11 47N(EB)-100V 2N2-K 47N(EB)-100V
10(1)
CP203
CN1 R14
10(2) (C)
L1C C15 C16
SP-2507 2N2-K 47N(EB)-100V (SL)
C22 (C)
HTP-071
SPEAKER TERMINAL
47N(EB)-100V
R84
C87 C86 R15
10N-K 10(1) RLY5
D15
R47
10N-K
D14
R16 (SW)
C106
HL3-2A-12S
C26
C27
C29
C30
C31
C32
10(2)
IC2
R80
R81
L1SW
0R1(5)
0R1(5)
R83
SP-2507
KIA7912PI
CN3
-
JUMPER JUMPER
C107
TO CHASSIS
TO CHASSIS
-
IC3
-
C25
-
-
KIA7805API
D28
1N-K
1N-K
1N-K
1N-K
1N-K
1N-K
(SW) (SW)
D27 R17 47N(EB)-100V
R82
750
RB551V-30 10(1)
B
Q19
IC1
RB551V-30 R18
KTA1268BL 10(2)
C94 10N-K C93 10N-K
3
3
KIA7812API
D16
-
C88
TO CHASSIS
R86
C89
100/16(6.3*11)
D26
100/16(6.3*11)
R75 R71 RB551V-30
- -
22K
CP202
C108 10N-K
Q18
C95 10N-K
C90
KTA1268BL
100/6.3(6.3*5)
R72
R85
560K
-
F
4
3
(HP)
2
1
CN721
CP5
20010WS-04
33K
R91
4
4
Q21
R30
KTA1268BL
R90
4K7
C116
R29
2K2(1) 2K2(1)
100N-K
D5
10
R23
KDS4148U
CP17
R73
MTZ3.3B
C125Z1-27
R28
ZD10
2K2(1)
R89
3K6
Q20
-
C115
1
Q12
Q5
1SS133T
RT1P237C
2
RT1N237C
C57
4
C62
10/50
R44
3
10N-K
2.2/50
4
C112
-
10N-K
C114
KTC3198Y
2
10
5
C59 D4
R22
10N-K
1
KDS4148U
6
R92
2K2
560K
D8
CN5
7
R87 5267-04A
1SS133T
8
RT1P
D
C60
Q1
Q
R43
RT1N
CP
5 6 7 8
R632 -
R625 JACK4
(SW) (SW) R626 R629 C627 - -
- -
-
R631
-
C626
R627 R630
R628
R44 - -
R43 - C612 Q602 -
C62 - C60 - -
C628
Q603
R633
- -
-
-
(TU)
JACK3
C37 100N-K
IC4
BH76330FVM
8
C36
R3 0 R5 75
220P-J
B
220P-J
R34 C42 470/6.3(6.3*11)
75
75
3
6
75 100N-K R6 - D18
0
R4
4
5
C34
R24
22K
D19
C39
47/16
R32
R33
C40
C35 0
R1 - 47N-Z
C41
C33 - 0
/RST
1
/SEN
2
3
SCLK
SDIO
4
10N-K
5
C607 VCC_5V
-
R635
C636
C635
BEAD601
R636
GND
6
-
-
BD3580
C611L
4N7-K
R608R 1K
7
TUNER_R
C609L
8
10/50 R608L TUNER_L
(TU) (TU) 1K
9
GPIO2/INT
10N-K
4N7-K
C611R
R637
R638
C609
47K
47K
PACK601 C
C609R
10/50
R48
-
100/25(6.3*11)
KDS4148U
KDS4148U
D4
D2
D1
C53
C 2/2
C103
1/50
ZD10
10N-K
C59
MTZ16B
ZD24
C101
C102
MTZ16B
1/50
D17
ZD25
1SS133T
Q14
D 2/3
10N-K
C100
R51
100K
KTC3198Y
R54
R49 51K
51K R52
R59
10K
MTZ3.3B
Q16
R58 27K
CN5
ZD26
100/10
2N2-K
33K
KTC3198Y
R73 -
Q15
C112
10N-K
C98
R53
C99
KDS4148U
D3
E
R89
3
5267-03A
R93
2.2/50
3K6
2
C114
CP4
22K
560K
R87
R45
Q20 KTC3198Y -
C115 10N-K
R46
D29 R88 220 R92 0
1SS133T 2K2
(FL)
: Audio Signal Route (Front L ch)
(SL)
: Audio Signal Route (Surround L ch)
(C)
: Audio Signal Route (Center ch)
(SW)
: Audio Signal Route (SubWoofer ch)
(TU)
: Audio Signal Route (Tuner L ch) F
(HP)
: Audio Signal Route (Headphone L ch)
C 1/2
HTP-071 67
5 6 7 8
1 2 3 4
R268
10K
J CP1000 CP201
C125Z1-29
R269
29 27 25 23 21 19 17 15 13 11 9 7 5 3 1 -
28 26 24 22 20 18 16 14 12 10 8 6 4 2
C208
100N-K
C209
330P-J
22
47K
R311
47K R308
22
47K
R227
10K
10K
10K
47K
22
22
22
C242
22
R329
R213
R328
R214
R216
R217
R218
47
10N-K
R309
R305
R310
R303
-
C214
51 52 53 54 55 56 57 58 59 60 61 62 63 64 65 66 67 68 69 70 71 72 73 74
R312 22
50
R317 22
49
48
47
46
45
C R300 22
44
43 IC203
R299 22 M3030RFGPFP
42
41
R298 22
40
39
38
37
C 1/2 R275
36
35
34
22
33
R223 22 32
R225 22 31
47K
30 29 28 27 26 25 24 23 22 21 20 19 18 17 16 15 14 13 12 11 10 9 8 7
R301
18P-J
C244
C245
22
16M9344(16P)
R322
22P-J
RES201
R233 10K
22
-
-
R321
22
10K
10K
R231
R232
D Q201
R234
R235
R320
-
ISA1530AC1 C216
C243
R215
R236
10K
10K
D201 100N-K
KDS4148U
10/50
1N-K
C217
100/10
R337
1K
R341
C218
C241
1K
C221
-
R243
3K3
C220
10N-K
KDS4148UKDS4148U
D206
Q202
RT1N237C
R245
10K
D207
E
R248
1K
R249 1K
2SC3052
Q203
R250
R251
100
1K
R256 4K7
100K
R258
R257 4K7
R260
100
100K
R259
R261
KDS4148U
1K
100N-K
R272
100K
C223
R262
D202
220K
100
R265
R266
10K
ZD201
8 7 6 5
10N-K
47/16
C227 Q206
0
R281 2SC3052
2.2/50
C228
10N-K
4K7 IC204
CW24C16DR
10N-K
C225
C226
FT24C16A
4K7
10N-K
KDS4148U
C230
10N-K
R285
47K
D203
1 2 3 4
KTA1504S
F
2SC3052
C229
R282
R286
470K
2SC3052
Q211
Q216
Q209
C231
C 2/2
68 HTP-071
1 2 3 4
10K R233 10K
Q216 D207 C244 R227
D206 47K
IC203
KTA1504S
C216
22P-J
C220
KDS4148UKDS4148U
10N-K
-
R272
100K
M3030RFGPFP
C245 R328
C243
C241
C217
Q211
100/10
47K R308 22
-
18P-J
100N-K
2SC3052
RES201
R286 C223 R251
470K 100N-K 100 16M9344(16P) R329 47K
7 16 15 14 13 12 11 10
R214
10K
R269
R268
9
C231 10N-K
47
8
Q209 R322 22 R213
7
2SC3052
47K
6
R330
47K
5
Q217
KTA1504S R273
10K
R331
4
R209
100K
47K
3
Q212
10K
R207
2SC3052 R601 22
2
R247 100
5
5
10
1
10K
100N-K 100
4 65 66 67 68 69 70 71 72 73 74 75 76 77 78 79 80
R246
R208
470K 100
9
R212
R201 100
8
C232 10N-K 47
99
98
97
96
95
94
93
92
91
90
89
88
87
86
85
84
83
82
81
R202 100
7
R203 100
6
Q210
2SC3052
5
C215
3
10N-K
R324
R323
R313
R316
R315
2
R222
R221
C249 R206 100
1
22
22
22
22
22
R340 100
R339 100
R338 100
10P-D
-
-
FPC201
C248
C247
C246
R224
R226
R342
R230
R229
R228
R267
1.0-11S-10PW
10K
10K
10K
10K
10K
10
1N-K
1N-K
1N-K
47K R279
R292 -
GND
Q218
2SC3052
-
C235 R255 -
6
6
10N-K 100
J251
47K R276 0
R291 120K J250
Q215
0
R325
2SC3052
0 D204
D311
M150(1) 1SS133T
R302 0 D205
47K 10N-K
C 2/2
R327
47K
100N-K 100N-K
R271 R270
470 330
HTP-071
R263 10N-K
1K
C222
10N-K 100N-K 100P-J
R264 100N-K
10K 10N-K
7
7
3 2 1 C 1/2 26 24 22 20 18 16 14 12 10 8 6 4 2
CP404
27 25 23 21 19 17 15 13 11 9 7 5 3 1
1.25-2-27P
20010WS-03
B
MAIN ASSY (CPU BLOCK)
CN203
CN704
8
(SYXE8: 7028071121040-IL) (CXE: 7028071121030-IL)
(DLPWXE: 7028071121020-IL) (AXE5: 7028071121010-IL)
69
C 2/2
F
E
B
A
D
C
F
E
B
A
D
C
70
D 1/3
1
1
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19
D203 CDS2C05HDMI1 R203 D202 CDS2C05HDMI1 R202 D201 CDS2C05HDMI1 R201 D268 CDS2C05HDMI1 R204
0 0 0 0
D207 CDS2C05HDMI1 Q203 R207 D206 CDS2C05HDMI1 Q202 R206 D205 CDS2C05HDMI1 Q201 R205 D269 CDS2C05HDMI1 Q204 R208
1K 1K KRC102S 1K KRC102S 1K
D211 CDS2C05HDMI1 KRC102S D210 CDS2C05HDMI1 KRC102S D209 CDS2C05HDMI1 D267 CDS2C05HDMI1
KRC104S R211 KRC104S R210 KRC104S R209 KRC104S R293
D215 CDS2C05HDMI1 10K D214 CDS2C05HDMI1 10K D213 CDS2C05HDMI1 10K D272 CDS2C05HDMI1 10K
Q206
Q207
Q205
Q208
-
-
-
R213
R289
R214
-
-
10K
10K
R222
R288
10K
10K
R243
R290
R234
R223
R286
R287
D227 CDS2C05HDMI1 D226 CDS2C05HDMI1 D225 CDS2C05HDMI1 D276 CDS2C05HDMI1
-
R215
D231 CDS2C05HDMI1 D230 CDS2C05HDMI1 D229 CDS2C05HDMI1 D275 CDS2C05HDMI1
-
10.5 D-MAIN ASSY (1/3)
-
R318
R317
D235 CDS2C05HDMI1 D234 CDS2C05HDMI1 D233 CDS2C05HDMI1 D273 CDS2C05HDMI1
-
R315
2
2
-
R316
D243 CDS2C05HDMI1 D242 CDS2C05HDMI1 D241 CDS2C05HDMI1 D244 CDS2C05HDMI1
R218 R217 R216 R291
47K 47K 47K 47K
HTP-071
3
3
R212
1K
D248
UDZ5.1B
C206
C205
C204
C203
C207
100N-K
C270
C208
C202
C201
C209
D249
UDZ5.1B C210 47/16-Z8156
C211 100N-K
D250
100N-K
100N-K
100N-K
100N-K
100N-K
100N-K
100N-K
100N-K
100N-K
C212
UDZ5.1B
2K 47/16-Z8156
-
R224
R225
R227
32 31 30 29 28 27 26 25 24 23 22 21 20 19 18 17 16 15 14 13 12 11 10 9 8 7 6 5 4 3 2 1
470
2K
R228
J200 0
33
J201 0
CB201
C213
34
100N-K
J202 0
R229
R233
0
0
35
R226
R232
R231
36
47K
R230
R235
-
37
1K
R236
49
50
51
52
53
54
55
56
57
58
59
60
61
62
63
64
R237 38
0
R238
1
4
4
39
R323 100
2 40
CB202
R332 2K R324 100
3
24MHZ
R266 41
100 2K C214
XTAL200
C216
4
0 42
10K 2K
C215
100N-K
5
43
100N-K
10P-D R239
R333
6
44
10M
100 10K R240
R241
7
CB221 10P-D 45
100N-K 2K
8
46
C217
IC201
0
100N-K
C218
EPF021A
47
C219
48
IC200
49
EP94A1K
R328 100
C220
C221
50
100N-K
52
R325 100
53
D 2/3
R269
100N-K
CB211
48 47 46 45 44 43 42 41 40 39 38 37 36 35 34 33
9 10 11 12 13 14 15 16
54
10K
R242 55
32
31
30
29
28
27
26
25
24
23
22
21
20
19
18
17
10K
56
2.2/50
100
C22
10K R240
41
7
CB221 10P-D 45
100N-K 2K
8
46
C217
IC201
0
100N-K
C218
EPF021A
47
C219
48
IC200
49
EP94A1K
R328 100
C220
C221
50
100N-K
100N-K R327 100
51
0 R326 100
C222
52
R325 100
53
D 2/3
R269
100N-K
CB211
42 41 40 39 38 37 36 35 34 33
9 10 11 12 13 14 15 16
54
10K
R242 55
32
31
30
29
28
27
26
25
24
23
22
21
20
19
18
17
10K
56
C224
57 C223
2A
1A
100N-K
10
R245 100N-K
R244
1K
GND
2.2/50-Z8154
58
C225
CB203
CB222
59
C226
1N-K
C228 0
2K2
60
47K
C227
R247
R246
100N-K
100N-K
D265
61
2Y
VCC
1Y
0
UDZ5.1B
5
5
62 99
C229 100N-K
63 98
R334
64 97 C231
R248
0
10P-D
XTAL201
65 66 67 68 69 70 71 72 73 74 75 76 77 78 79 80 81 82 83 84 85 86 87 88 89 90 91 92 93 94 95 96
18M432MHZ
10P-D
C230
10M
100N-K
330
C232
R249
47/16-Z8156
R330
R331
R329
C233
C237 CB204
100
100
100
0
C240
100N-K
C239
1/50-Z8155
C238
C242
C243
0
100N-K
100N-K C241
10/16-Z8154
100N-K
100N-K
CB220
1/50-Z8155
C245
D 2/3
100N-K
1
C246
C244
2
10/16-Z8154
CB210
CB212
CB208
CB207
3
CB209
10
10
4
R250
5
10
6
C247 C248
27K
1000N-K
R251
7
100N-K
IC203
EPF011C
R252
8
10N-K 10/16-Z8154
C252 10 C253 C249
9
C251
100N-K
100/6.3-Z8156 100N-K
C256
C254 C255
10/16-Z8154 47/16-Z8156
3
4
24 23 22 21 20 19 18 17 16 15 14 13
10 11 12
2
6
6
10K
10K
10K
IC207
R255
R254
R253
CB214
CB213
CB215
D251
0
47K
1
5
NJM2831F33
KDS4148U
R268
C235
1/50-Z8155
C236
-
47/16-Z8156
D 3/3
C261 C260
47/16-Z8156
D278
10N-K 10N-K C262
HTP-071
R283
R284
R285
R278
R279
R280
R281
R282
IC205
C264
IL1117-3.3
100N-K C263
0
0
0
0
0
0
0
0
IC206
-
IL1117-1.8
10N-K
-
R264
D277
R265 330
C265
47/16-Z8156 22
C266
R256 100N-K
51 R263 0
7
7
R260 R257
C267
R259
R258
4R7 51
100N-K
0
0
D252 CDS2C05HDMI1
D253 CDS2C05HDMI1 R261
1K8
D254 CDS2C05HDMI1
-
D255 CDS2C05HDMI1
R262
C250
D259 CDS2C05HDMI1
D260 CDS2C05HDMI1
CB217
CB218
D261 CDS2C05HDMI1
D262 CDS2C05HDMI1
D263 CDS2C05HDMI1
R267
-
D264 CDS2C05HDMI1
C269 CB219
-
(7028071161010-IL)
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19
JACK204
8
8
D 1/3 D-MAIN ASSY (HDMI BLOCK)
71
D 1/3
F
E
B
A
D
C
1 2 3 4
A
CP603
I
D 1/3
CN603
R602FR
470P-J
8K2
C604FR
FR R600FR 2
1 560 5K1 10/16-Z8154
47 3
AZ4580M C601FR
4N7-K
IC603
R602FL
470P-J
8K2
C C608
C604FL
FL
1N-K R603FL C602FL (FL)
R600FL 8 6
FL R601FL
7 5K1 10/16-Z8154
560
(FL) 47 4 5
C601FL
4N7-K
C607
1N-K
470P-J
R602SR
C604SR
8K2
SR IC601
10K
R610
R601SR R603SR C602SR
R627
PCM1681
R600SR 2
1
SR
560 5K1 10/16-Z8154
15 16 17 18 19 20 21 22 23 24 25 26 27 28
1
1
2
C624
47 3 10/16-Z8154
2
3
3
4
4N7-K 1N-K
IC604
4
5
C627
10/16-Z8154
R602SL
5
6
8K2
470P-J C623
C604SL
6
7
1N-K
C606
SL
7
R603SL C602SL
(SL)
8
1N-K
CN209
8 6
8
R600SL
9
SL
R601SL 5K1 10/16-Z8154
7
9
10
560
47
14 13 12 11 10
4 5
11
(SL) C601SL
12
4N7-K C618
D
13
1N-K
14
C605
E
15
1N-K
470P-J D162 -
16
R602C
C604C
8K2
C626
17
10/16-Z8154
R601C R603C C602C C
(C)
18
10N-K
C R600C 2
19
1/50-Z8155
1
(C)
20
10N-K
47
C613
3
21
AZ4580M C601C
4N7-K
22
C614
C612
C611
IC605
23
R602SW
8K2
470P-J
C604SW
C125Z2-23
C604
SW
CN600
R603SW C602SW
8 6
1N-K (SW)
SW R600SW
R601SW 5K1 10/16-Z8154
7 560
(SW) 47 4 5
C601SW
4N7-K
C603
1N-K
R602SBR
X5R106-K/25V(TDK)
X5R106-K/25V(TDK)
470P-J
8K2
AZ4580M C601SBR
4N7-K
IC606
C674
C675
C673
R602SBL
220/6.3-Z8157
10/25-Z8155
8K2
470P-J
C604SBL
10N-K
C697
10N-K
C602
C695
R600SBL
C696
SBL
R601SBL 5K1 10/16-Z8154
7 560
(SBL) 47 4 5
820K
CP104 1 2 3 4
5268-04A
C 1/2 CN5
D 2/3
72 HTP-071
1 2 3 4
5 6 7 8
R653 R656
2K2 300K
0
L148
C659
47P-J
IC600
R655 74VHCU04
100K
C653
C654
10N-K
9 10 11 12 13 14
1
-
C661
2
47P-J R657
3 100
R651
4
33 R612
5
33
6
C651
10/16-Z8154
7
- C650
100N-K
C652
L141
100N-K
C631
LBC2012T-4.7UH
1N-K
C630
L147
0
C641
C639 C640 68N-K
10/16-Z8154
10/16-Z8154 10/16-Z8154
C660
680 R638
C645 C646
1A 1Y
100N-K
4N7-K
C635
100N-K
C609FL
10/16-Z8154 GND VCC
R270
100N-K
330
C644
R271 330
2A 2Y
100N-K
10/16-Z8154
R635
C609FR
C610
10/16-Z8154
48
47
46
45
44
43
42
41
40
39
38
37
C643
R314
R272 0 0
R647
R648
25 26 27 28 29 30 31 32 33 34 35 36
100K
10K
1
C634 C636
R273 0 R313 0 R646
10N-K -
2
R274 0 R304 0
3
R275 0 R305 0
4
R644
R276 0 1M
R629
5
R277 0 680
IC602
6
R645
R294 PCM9211 R306 XTAL600
0
0 0
24M576(10P)
D 1/3
7
R295 0 R307 0
8
R296 0 R308 0
12 11 10 9
R297 0
R298 0 R311 0
R299 0
C632
5P-C
C633
5P-C
C
430
13
14
15
16
17
18
19
20
21
22
23
24
R312 0 R605
100
100
100
100
0
0
0
0
100N-K
R604
R320
R319
R321
R322
R300
R301
R309
R310
430
C642
R302 4K7
IC601 R303
10K
R610
10K
4K7
R627
R633
R634
PCM1681
15 16 17 18 19 20 21 22 23 24 25 26 27 28
4K7
4K7
2
R631 430
3
R632 430
4
R624 100
5
R625 100
D 3/3
6
R626 100
7
R622 100
8
10/16-Z8154
L149
C619
9
1N-K 0
C628
14 13 12 11 10
R618 100
C618 R617 100
R616 100
D
1N-K
R609 0
10K
10K
10K
10K
C626
Z8154
R606
R607
R608
R611
29
28
27
26
25
24
23
22
21
20
CN1000
D 3/3 19
18
17
R674 C694
16
- -
15
X5R106-K/25V(TDK)
X5R106-K/25V(TDK)
L160
14
15UH
1
13
E
C684
47K-F
91K-F
2
12
J
-
C681
11
-
R673
D 1/3
4
10
-
22000N-M-3225
R671
R672
22000N-M-3225
R670
IC608 300
8
C674
C675
C673
AOZ1073AI
R665
7
R666
2K2
10K-F
6
C682
C683
C669
5
6N8-K
4
3
R658
2
47K
1
R661
C125Z2-29
R659 (FL)
: Audio Signal Route (Front L ch)
CN601
10
(SL)
: Audio Signal Route (Surround L ch)
(C)
: Audio Signal Route (Center ch)
(SW)
: Audio Signal Route (SubWoofer ch)
(SBL) F
: Audio Signal Route (Surround Back L ch)
D 2/3
HTP-071 73
5 6 7 8
F
E
B
A
D
C
74
D 2/3
D 2/3
D 3/3
1
1
R703
R702
R706
R701
R714
R705
10.7 D-MAIN ASSY (3/3)
R704
33
33
33
47
100
47K
8 7 6 5 4 3 2 1
2
2
C460 10N-K
IC101
74LCX257MTCX
C461
9 10 11 12 13 14 15 16 220/6.3-Z8157
33
R709
C463
R708 0
R707 0
C462
10N-K
220N-K
C464
-
D160
10N-K
C465
C466
0
220/6.3-Z8157
100/6.3-Z8156
L151
L150
R710 C467
0 L153 100/6.3-Z8156
LBC2012T-4.7UH
0
HTP-071
C468 -
- C469 220/6.3-Z8157
C470
C471 -
C472 10N-K
C473 100N-K
C474 10N-K
R711
C475 1N-K
C476 100P-J 100N-K
C477
-
C478 100P-J
C479 1N-K
C480 330P-J
C481 10N-K
C482 100N-K
C483 CH1N-J
3
3
C484 -
C485 33P-J
C486 100N-K
C487 330P-J 100N-K
C488
C489 10N-K
C490 330P-J
C491 10N-K
C492 100N-K
C493 100P-J
C495 10N-K C494 100N-K
C502 -
C503 -
C504 10N-K
R717 R715 1K C505 -
C506 -
R716 1K C507 -
1K
C508 -
R718 1K C509 -
C510 10N-K
R719 1K R720
C511 -
R722
R726
R725
R724
R723
4K7
C512 -
R721
R727
R733
R732
R731
R730
R729
C513 330P-J
33
33
33
33
68
33
0
0
0
0
33
4
4
C514
R736
R735
100P-J
C515
100P-J
33
33
4K7
R738
R742
R741
R740 0
R744 C516 R743 33
1
1K
1K
R746 47 100P-J R745 33
R747
2
0
R748
3
0
R750 R749 33
4
0
R752 0 R751 33
5
D 2/3
6
R753 - R754 33
7
R755
8
0 R756 33
R757 -
C517 R761 33
5 6 7 8
L156
0
L157
0
C530
470/6.3-Z8158 C532
33
33
33
33
33
33
33
33
33
33
33
33
33
33
C526 -
28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54
220N-K
1
2
R745
C527
R765
R767
R769
R770
R773
R774
R776
R778
R780
R782
R783
R785
B
3
-
33
33
33
33
33
33
33
33
4
5
C533
100P-J
6
R749
R751
R754
R756
R758
R760
R761
R763
1N-K
7
8
C528
9
33P-J
27 26 25 24 23 22 21 20 19 18 17 16 15 14 13 12 11 10
C534
99 98 97 96 95 94 93 92 91 90 89 88 87 86 85 84 83 82 81 80 79 78 77 76 75 74 73
220N-K
72
C529
71 100N-K
R787 33
70
R788 33
69
C524 10P-D
68
67
R789 33
66
R790 33
65
64
R791 33
63
R792 33
62
61
R793 33
60
59
R794 33 C
58
IC102 R795 33 C531
57 220N-K
IC103
56
R796 33 IS42S16400F-6TL
55
R797 33
54 R818 L158
53 0 0
52
33
10N-K
R798
100/6.3-Z8156
51
R799 33
50
49
R800 33
C537
C535
48
R801 33
47
IC104
46
R802 33
MX29LV160DTTI
45
R803 33
44
43
R804 33
25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48
1
42
2
41
R805 33
3
40
R808 33
4
39
R809 33
5
38
R810 33 6
37
R811 33
D
7
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36
8
24 23 22 21 20 19 18 17 16 15 14 13 12 11 10 9
C518
47K
R812
330P-J
R757 -
R813
100N-K
R814
33
33
33
33
33
33
0
R759
C517
47
R775
10K 0
330P-J
R815
C522
-
0
33
C525
R766
C519
33
R777
R779
R781
R784
R786
R746
33
100N-K
100N-K
R768
R771
R762
C520
10K
1K
-
1K
R772
C521
10/16-Z8154
0
L154
R806
E
L155 10K
0 R807
10K
-
10
R764 2K7
9
R753
8
7
6
0
0
0
0
0
5
R755
C523
4
10N-K
0
3
R750
R752
2
R744
R747
R748
CN101
1.0-15S-10PWB
D 2/3 F
D 3/3
HTP-071 75
5 6 7 8
1 2 3 4
A
E BR1 ASSY (7028071133010-IL)
CN209
C125Z1-23
D 2/3 CN600
1 3 5 7 9 11 13 15 17 19 21 23
2 4 6 8 10 12 14 16 18 20 22
23
22
C125Z1-23
CN210
21
20
(SBL)
19
C250SBL
18
10P-D
C250SW
C250SR
C250FR
C250SL
17
C250FL
C250C
10P-D
10P-D
10P-D
10P-D
10P-D
10P-D
C250SBR
B
16
10P-D (SW)
15
14
(C)
A CP400
13
(SL) 12
11
10
(FL)
9
(FL)
7
(SL)
: Audio Signal Route (Surround L ch)
6
(C)
5
(SW)
3
(SBL)
1
C
CN701
270MM/9P
FL1
FLCT
FL2
GNDU
N CP701
CPU+3.3V
CPU_ST_VCC
PDN
STBY_RLY
HDMI+12V
D
F HP ASSY (7028071134010-IL)
C738
VOL_UP
GNDU
VOL_DN
820P-K
C742
KDS4148U
KDS4148U
D707
C751
10N-K
D709
(HP)
E : Audio Signal Route (Headphone L ch)
STBY_KEY STBY_KEY
INPUT_UP INPUT_UP
GNDU GNDU
820P-K
10N-K
INPUT_DN INPUT_DN
C758
C757
ST_H+5V ST_H+5V
POWER_LED POWER_LED
820P-K
C759
C744 10N-K
C726
KDS4148U
C745 -
KDS4148U
D711
C761
10N-K
D712
C765
HDMI+12V
-
-30V
E F G H
76 HTP-071
1 2 3 4
02
GNDU
ST_H+5V
STBY_KEY
INPUT_UP
INPUT_DN
POWER_LED
CP701
C744
C745
CN701
270MM/9P
-
PDN
FL2
FL1
10N-K
-30V
GNDU
FLCT
CPU+3.3V
HDMI+12V
STBY_RLY
HDMI+12V
CPU_ST_VCC
C737
CPU_ST_VCC
-
-
R788 R787
1N-K
-
C740
C763
C752
C753
C760
-
- -
GNDU
5
5
C741
-
100P-J
-
C764
1N-K
C739
CPU_+3.3V
ST_H+5V
-
15K
10/50
R737
C728
C762
R779
R780
2R2(1/4)
POWERDOWN
2R2(1/4)
RMC
STBY_RLY 10UH(02)
OSD/FLT_DATA
-
OSD/FLT_CLK
FLT_CE
MTZ7.5B
C746
INPUT_UP
KEY2 L701
100UH(02)
C 2/2 CN704B
KEY3
KEY1 (STBY_KEY) C719
47N(EB)-100V
INPUT_DN
-
R741 470 R707
C733 100P-J R708 56K
10N-K
6
C756
C767
6
-
C734 100P-J 11 10 9 8 7 6 5 4 3 2 1 R709 56K
C766
56K
C735 100P-J R710
1/50
12 44
C727
10N-K
C730
R711 56K
13 43
56K
14 42 R712
56K
15 41 R713
56K
R714
16 40
R715 56K
17 39
56K
R716
IC701
18 38
SC16315
R717 56K
10K
19 37
R778
R777 56K
R718
20 36
3K3 56K
R719
21 35
Q703
R720 56K
22 34
Q702
C705 56K
HTP-071
RT1N144C
2SA933S
23 24 25 26 27 28 29 30 31 32 33 C706 -
C707 -
C708 -
C709 -
C710 -
R721 -
56K
R722
56K
R723
7
7
R724 56K
R725 56K
56K
R726
R727 56K
R728 56K
R729 56K
R730 56K
56K
R731
R732 56K
56K
C718 47N(EB)-100V
C724
-
C717 1/50
C711 -
C712 -
C713
C714 -
C729 C715 -
-
C716 -
-
8
8
C725
10N-K
H FRONT ASSY (7028071131010-IL)
H
77
F
E
B
A
D
C
1 2 3 4
10.9 DG ASSY
I
MT602 DG ASSY (7028071112010-IL)
R615 0
B R616 0
JACK601
R610
4K7
C602
C603
47/16
L601
LBC2012T-4.7UH
-
C601
C604
22P-J
10N-K
D 2/3
CN603
10
9
8
R612
7
10K
6
5
CP603
4
3
2
D
1
1.0-11S-10PW
FPC202
MT601
R613 0
R614 0
I
78 HTP-071
1 2 3 4
5 6 7 8
BD1001 BD121T
C 2/2 CP201
D 2/3 CN601 BD1002 BD121T
BD1003 BD121T
BD1004 BD121T
BD1005 BD121T B
BD1006 BD121T
BD1007 BD121T
BD1008 BD121T
BD1009 BD121T
K G-T ASSY
(7028071123010-IL) C
L G-L ASSY
(7028071125010-IL) D
M G-H ASSY
(7028071124010-IL)
CLAMP904 CLAMP903
CLAMP_WIRE CLAMP_WIRE
CLAMP906 CLAMP907
CLAMP_WIRE CLAMP_WIRE
F
J K L M
HTP-071 79
5 6 7 8
1 2 3 4
N STBY ASSY
(SYXE8: 7028071122040-IL)
(CXE: 7028071122030-IL)
(DLPWXE: 7028071122020-IL)
(AXE5: 7028071122010-IL)
• NOTE FOR FUSE REPLACEMENT
CAUTION - FOR CONTINUED PROTECTION AGAINST RISK OF FIRE,
REPLACE WITH SAME TYPE AND RATINGS OF FUSE.
ZD303
B
MTZJ7.5B
1
R336
10K
2
D301 R326
C304
4N7
R318
2SC3052
47K
Q302
R334
2SC3052
20K
RT1N144C
CXE
ONLY
9
MTZ15B
CN700
ZD302
8
7
C307
6
ZD301 -
5
MTZ5.1B
4
D303 KDS4148U
H
3
IC301
2
D304 KDS4148U
PT301 IL1117-3.3
1
1
C F301
100/16
D305 1N4007 CP701
2
100N-K
C302
2200/16(12*16)
1/50
1N4007 20010WR-09
100N-K
D306
C305
CP301 J301
JE202B1T2 D307 1N4007
C306
C301
C303
J302
D308 1N4007
CP303
-
KDS4148U
KDS4148U
D309
D310
C315
1/50
1
2
3
3
2
1
230V(SYXE8) CP304
5267-03A
120V(CXE) 220V(AXE5)
220-240V(DLPWXE) GND301 GND302 GND303
E
1
2
N
80 HTP-071
1 2 3 4
5 6 7 8
10.12 S-11-P
Red
Poly S/W-110
INPUT Speaker
White
P.SW:
P.SW has extreme positive resistance-temperature characteristics.
If an abnormal current flows to P.SW due to an excessive input or
unusual signal, P.SW heats up and the resistance rapidly increases.
With this function, the speakers are protected from excessive input
or unusual signal. The resistance value increases even when using
a soldering iron for repairing, so allow it to cool before using. C
HTP-071 81
5 6 7 8
1 2 3 4
A INPUT ASSY
Q411 Q416
Q408 Q414
Q412 Q417
Q409 Q415
CP17
CP401
C
IC400
Q402
Q405
Q413
Q407 Q406
Q410 IC403
CP201
CN400
IC402
B
E
Q427
Q426
Q421
Q420
Q419
CP400
F
E CN210
A
82 HTP-071
1 2 3 4
5 6 7 8
A
NOTE FOR PCB DIAGRAMS : 2. View point of PCB diagrams. SIDE B
1. The parts mounted on this PCB include all Connector Capacitor
necessary parts for several destinations.
For further information for respective desti- SIDE A
nations, be sure to check with the sche-
matic diagram.
SIDE B
P.C.Board Chip Part
A INPUT ASSY
C
CP17
CP401
C
CN400
CP400
A
HTP-071 83
5 6 7 8
1 2 3 4
B
CP404
CN203
C
C CP203
C CN
SIDE B
D
F CP202 CP201
B
84 HTP-071
1 2 3 4
5 6 7 8
A CN400 SIDE A
A
CP201
CP203 C
C CN1
SIDE B
D
CP203
2 CP201 F
B
HTP-071 85
5 6 7 8
1 2 3 4
C MAIN ASSY
CP203
C
CN1
B
CP202
CN3
B
CN721
D
CP5
F
CP1 CP3
Q18
F Q19
C
86 HTP-071
1 2 3 4
5 6 7 8
SIDE A
A
A CP401
CP17
CP1000
CP201
J
C
CN704
CN704B
D
H
CN203
CP404
B
CP104
CN5
CP3 CP2
C
HTP-071 87
5 6 7 8
1 2 3 4
SIDE B
A
B
CP201
C
CN704B
D
CP404
CN5
CP2 CP3
C
88 HTP-071
1 2 3 4
5 6 7 8
SIDE B
A
C
CN1
CN3
CP5
CP3 CP1
C
HTP-071 89
5 6 7 8
1 2 3 4
CN600
B
E
E
CN5
CP104
C
D
90 HTP-071
1 2 3 4
5 6 7 8
SIDE A
CN603 I CP603
A
IC600
IC609
IC205
IC101
IC602 IC206
IC601
IC200
IC102
D
IC100
IC608
IC203
IC201
IC202 E
IC207
IC103
IC607
Q208 Q204
CN601 J CN1000
D
HTP-071 91
5 6 7 8
1 2 3 4
SIDE B
A D D-MAIN ASSY CN603
IC606
IC605
IC604
IC603
E
IC104
CN601
D
92 HTP-071
1 2 3 4
5 6 7 8
SIDE B
A
CN600
B
E
CP104
D
HTP-071 93
5 6 7 8
1 2 3 4
E BR1 ASSY
CP5
CN721
CN600
CN209
C
D
Q702
B
CN210 A CP400
CP701
CN701
G FUNC ASSY
N
C
CN702
CP702
SIDE B
CP702
D CN702
Q705
G FUNC ASSY
CN701
E
CN210
Q707 Q703
Q701
CN209
CN721
F E BR1 ASSY
E F G H F HP ASSY
94 HTP-071
1 2 3 4
5 6 7 8
SIDE A
A
H FRONT ASSY
C CN704B
RMC701
CN704
B
SIDE B
CN704
IC701 Q706 Q708 Q704 Q709
H FRONT ASSY
H
HTP-071 95
5 6 7 8
1 2 3 4
11.6 DG ASSY
SIDE A SIDE A
A
I DG ASSY
CP603
C
D CN603
SIDE B SIDE B
I DG ASSY CP603
I
96 HTP-071
1 2 3 4
5 6 7 8
J CNT ASSY
C
CP1000 CN1000
C CP201 D CN601
SIDE B SIDE B
D
CP1000 CN1000
J CNT ASSY F
J
HTP-071 97
5 6 7 8
1 2 3 4
M G-H ASSY
SIDE B SIDE B
M G-H ASSY
E
K L M
98 HTP-071
1 2 3 4
5 6 7 8
CP304
AC IN
CP301
B
CN700
CP701
TRANS.
MAIN
CP302
H
SIDE B SIDE B
N STBY ASSY D
CP302
CP701
E
CP301
CP304
F
Q303 Q302 IC301 Q301
N
HTP-071 99
5 6 7 8
1 2 3 4
Ex.1 When there are 2 effective digits (any digit apart from 0), such as 560 ohm and 47 k ohm (tolerance is shown by J = 5%,
and K = 10%).
560 Ω → 56 × 101 → 561 ................................................................... RD1/4PU 5 6 1 J
47 kΩ → 47 × 103 → 473 ................................................................... RD1/4PU 4 7 3 J
0.5 Ω → R50 ................................................................................................. RN2H R 5 0 K
1Ω → 1R0 ................................................................................................. RS1P 1 R 0 K
Ex.2 When there are 3 effective digits (such as in high precision metal film resistors).
5.62 kΩ → 562 × 101 → 5621 ................................................................. RN1/4PC 5 6 2 1 F
- Meaning of the figures and others in the parentheses in the parts list.
B
Example) IC 301 is on the point (face A, 91 of x-axis, and 111 of y-axis) of the corresponding PC board.
IC 301 (A, 91, 111) IC NJM2068V
Mark No. Description Part No. Mark No. Description Part No.
NSP 1..PCB TTL ASSY MAIN 7025HK1103040-IL
LIST OF ASSEMBLIES 2..MAIN ASSY (SYXE8) 7028071121040-IL
NSP 1..PCB TTL ASSY FRONT 7025HK1103011-IL 2..MAIN ASSY (CXE) 7028071121030-IL
2..FRONT ASSY 7028071131010-IL
2..MAIN ASSY (DLPWXE) 7028071121020-IL
2..FUNCT ASSY 7028071132010-IL
2..MAIN ASSY (AXE5) 7028071121010-IL
2..BR1 ASSY 7028071133010-IL
2..HP ASSY 7028071134010-IL
2..STBY ASSY (SYXE8) 7028071122040-IL
2..STBY ASSY (CXE) 7028071122030-IL
NSP 1..PCB TTL ASSY D-MAIN 7025HK1103012-IL 2..STBY ASSY (DLPWXE) 7028071122020-IL
D 2..D-MAIN ASSY 7028071161010-IL
2..STBY ASSY (AXE5) 7028071122010-IL
C MAIN ASSY
7028071121040-IL, 7028071121030-IL, 7028071121020-IL and 7028071121010-IL are constructed the same
except for the following:
Mark Symbol and Description 7028071121040-IL 7028071121030-IL 7028071121020-IL 7028071121010-IL
L1 COIL, FILTER-INDUCTOR Not used D330900001330-IL D330900001330-IL D330900001330-IL
601 TUNER, FM/AM E903104100780-IL E903004100780-IL E903004100780-IL E903004100780-IL
F
100 HTP-071
1 2 3 4
5 6 7 8
N STBY ASSY
7028071122040-IL, 7028071122030-IL, 7028071122020-IL and 7028071122010-IL are constructed the same
except for the following:
A
Mark Symbol and Description 7028071122040-IL 7028071122030-IL 7028071122020-IL 7028071122010-IL
Q302 Not used J522101441210-IL Not used Not used
D9302 Not used MTZJ15(B) Not used Not used
> T301 POWER TRANS 8200280150680-IL 8200280150620-IL 8200280150680-IL 8200280150680-IL
> FU301 FUSE GLASS TUBE 20 mm N751503151160-IL N751506301160-IL N751503151160-IL N751503151160-IL
> CN9302 CN, WAFER 7.92 mm L108353280290-IL L108011430210-IL L108011430210-IL L108011430210-IL
A INPUT ASSY
C 204 D00033006D051-IL
C 209,210 D00410107D051-IL
SEMICONDUCTORS
IC 400 J084152180010-IL
IC
Q
Q
401-403
402,405-407,409
410,412,413,415
J121458000020-IL
J522020011210-IL
J522020011210-IL
C MAIN ASSY
SEMICONDUCTORS
Q 417 J522020011210-IL > IC 1 J126781200040-IL
> IC 2 J126791200060-IL
Q 419-421,426 J520101411210-IL > IC 3 J126780500110-IL
Q 425,428 J544117Y01150-IL IC 4 J127763300010-IL
C
Q 427 J522104411210-IL IC 203 8952VS3210010-IL
D 401-412,414,415 K005041480030-IL
D 9400,9401 MTZJ6R8(B) IC 204 J000241600170-IL
Q 1,2,4,5 J520102371210-IL
MISCELLANEOUS Q 8,9,11,12 J522102371210-IL
J 400 CN,WIRE 2MM L002201122620-IL Q 14,15,20 J5023198Y0000-IL
JA 400 TER,RCA 6PIN G603603A0920Y-IL Q 16 J5000992F0050-IL
JA 401 TER,RCA 6PIN G603603A0930Y-IL
CN 400 CN,WIRE 2MM L002201122620-IL Q 17 J5000916Y0050-IL
CN 9400 CN,WAFER L109012522310-IL Q 18,19,21 J5001268B0050-IL
Q 201 J520015301210-IL
CN 9401 CN,WAFER L109012522710-IL Q 202 J522102371210-IL
500 RING,TER WIRE 8410201010070-IL Q 203,206,209-212 J522305200050-IL
D
B AMP ASSY
D 8,17,29,311 K000013300520-IL
> D 9 K047604000020-IL
SEMICONDUCTORS
> D 10-13 K000400700010-IL
Q 201,202 J5000992F0050-IL
D 23 K000400700010-IL
Q 203,207 J5023200B0050-IL
D 26-28 K125551300010-IL
Q 208 J5001268B0050-IL
D 206,207 K005041480030-IL
D 201,202 K000013300520-IL
D 208 J5001268B0050-IL E
D 9010,9026 MTZJ3R3(B)
D 9024,9025 K06016R044520-IL
MISCELLANEOUS
CN 203 CN,WIRE L002800030110-IL
MISCELLANEOUS
CN 9201 CN.WAFER 2.0MM L101200101210-IL
JA 1 TER,BOARD PUSH 4P G594408SA030Y-IL
CN 9202 CN.WAFER 2.0MM L101200100810-IL
JA 2 TER,BOARD PUSH 8P G598801SA050Y-IL
CN 9203 CONNECTOR(6P) L102526700600-IL
JA 3 TER,RCA 3PIN G6060319D1B5Y-IL
RY 1 RELAY G680240202030-IL
RESISTORS RY 2,4,5 RELAY G680120503020-IL
R 211,218,219 C060047063050-IL
R 216,217 C060056265050-IL CN 1 CN,WIRE L000161062250-IL
> R 220-223 C060R47066050-IL
CN 3 CN,WIRE L002161082620-IL
R 228 C060010065050-IL
CN 5 CN,WIRE L000151042250-IL F
CN 704 CN.FPC 1.25MM L131125022710-IL
CAPACITORS CN 8201 CN.FPC 1.0MM L130100111050-IL
C 203 D009092212500-IL
HTP-071 101
5 6 7 8
1 2 3 4
Mark No. Description Part No. Mark No. Description Part No.
CN 9001 CONNECTOR L108353280360-IL
CN 9002 CN.WAFER 3.96MM L104353130360-IL D 251 K005041480030-IL
CN 9003,9004 CONNECTOR(3P) L102526700300-IL D 266-276 K067020500010-IL
A CN 9005 CN.WAFER 2.0MM L101200100410-IL
CN 9017 CN.WAFER L109012512710-IL MISCELLANEOUS
L 141,153 COIL,INDUCTOR D3104R7010200-IL
CN 9201 CN,WAFER L109012512910-IL L 160 COIL,CHIP D311126000030-IL
CN 9404 CN.WAFER 2.0MM L101200100310-IL JA 201-204 CN.WAFER L109100190160-IL
601 TUNER,FM/AM E903104100780-IL X 200 CRYSTAL CHIP (24 MHz) E80524R000040-IL
X 201 CRYSTAL CHIP (18.432 MHz) E80518R432010-IL
RESISTORS
R 7,9,11,13 C060010065050-IL X 600 CRYSTAL CHIP (24.576 MHz) E80524R576050-IL
R 8,10,12,14 C060010066050-IL CN 101 CN.FPC 1.0MM L130100151040-IL
R 15,17,25 C060010065050-IL CN 600 CN,WAFER L109012522310-IL
R 16,18 C060010066050-IL CN 601 CN.WAFER L109012522910-IL
> R 27,31,41,42 C060R22065050-IL CN 603 CN,WIRE 2MM L002800132620-IL
B
R 66
R 80,81
R 325
C0604R7065050-IL
C141R10069010-IL
C060015165520-IL
E BR1 ASSY
MISCELLANEOUS
CN 209,210 CN,WAFER L109012512310-IL
CAPACITORS
C C 55,58 D040682088010-IL
C
C
C
61,64
65-68
73
D02010406C060-IL
D02010407H070-IL
D040682083000-IL
F HP ASSY
SEMICONDUCTORS
C 84 D040472084020-IL D 705,706 K005041480030-IL
C 85 D040102084060-IL MISCELLANEOUS
C 101 D040331088230-IL JA 701 JACK,D6.5 G402PJ612AG1Y-IL
CN 721 CN,WIRE 2MM L002411042420-IL
702 RING,TER WIRE 8410131010060-IL
D D-MAIN ASSY
G FUNC ASSY
SEMICONDUCTORS
D > IC 100 J126111712070-IL
IC 101 J040742570040-IL SEMICONDUCTORS
IC 103 J001421640060-IL D 711,712 K005041480030-IL
IC 104 8952521000020-IL
IC 200 J046941000010-IL MISCELLANEOUS
S 715 SWITCH G180501000010-IL
IC 201 8952VS3210020-IL
S 9702 SW,ENCODER G121123050021-IL
IC 202,610 J040740400310-IL
CN 9702 CN.WAFER 2.0MM L101200100420-IL
IC 203 8952VS3210030-IL
> IC 205 J126111700041-IL
H FRONT ASSY
> IC 206 J126111710011-IL
Mark No. Description Part No. Mark No. Description Part No.
I DG ASSY
SEMICONDUCTORS
D 416 K005041480030-IL
MISCELLANEOUS
JA 601 OPTICAL RECEIVER E100116500040-IL
JA 602 TER,RCA 1PIN G600107A0000Y-IL
CN 202 CN.FPC 1.0MM L130100111050-IL B
CN 9603 CN.WAFER 2.0MM L101200101310-IL
601,602 BRACKET 4010210196100-IL
J CNT ASSY
MISCELLANEOUS
L 1001-1009 CHIP BEAD D340160811210-IL
CN 1000 CN,WAFER L109012512910-IL
CN 9000 CN.WAFER L109012522910-IL
1000 BRACKET 4010210196100-IL
K G-T ASSY
MISCELLANEOUS
910,911 BRACKET 4010210196000-IL
L G-L ASSY
There is no service parts.
M G-H ASSY
MISCELLANEOUS
D
N STBY ASSY
SEMICONDUCTORS
> IC 301 J126111700041-IL
Q 301,303 J522305200050-IL
D 301,302,309,310 K005041480030-IL
> D 303,304 K005041480030-IL
> D 305-308 K000400700010-IL
E
D 9301 UDZS5R1(B)
D 9303 UDZS7R5(B)
MISCELLANEOUS
H 301,9301 HOLDER,FUSE CLIP G645000050010-IL
> RY 301 RELAY G680060102020-IL
> T 301 POWER TRANS 8200280150680-IL
> CN 9301 CONNECTOR L108202000220-IL
> CN 9302 CN.WAFER 7.92MM L108353280290-IL
HTP-071 103
5 6 7 8