Professional Documents
Culture Documents
PRESSURE HOLD/
RELEASE VALVE ADJUSTABLE
(OPTIONAL RELIEF VALVE
BLANKING PLUG) (OPTIONAL
BLANKING PLUG)
OUTLET PORT,
ADAPTORS,
OPERATING
3 & 4 WAY
HANDLE
VALVES
DETACHABLE
AVAILABLE
LOW EFFORT
FILLER/ BREATHER G ½
FEATURES
Ultra low space envelope Output 0.6 cc/stroke up to 400 bar
Rugged construction Single acting, pumping on down stroke only
Carbon Steel or Stainless options Optional adjustable relief valve
Bronze piston rod bearing for low wear Built in 20cc reservoir as standard
For use on mineral oil Optional direct mounting 175cc reservoir
Hard chromed piston rod for long life Filler cap incorporates breather element
Integrated inlet and outlet check valves Nitrile seals, optional Viton® fluorocarbon
Optional pressure hold/ release valve Optional 3 and 4 way valves
Low handle load- 100N (22lbf) at 400 bar Quality British manufacture
APPLICATION CONNECTIONS
The unit is suitable for any application requiring manual Make connection to the outlet port with 1/8 NPT adaptor
generation of hydraulic power e.g. control system pilots, or fitting. Where a pressure gauge is required, this can be
small actuators or calibration. The small displacement mounted into the outlet line using a tee. 3 or 4 way valves
from this compact unit will limit application in larger can also be fitted. Contact the factory.
systems.
COMMISSIONING
The unit is suitable for use with mineral oil and other Fill reservoir. Operate hand pump and prime system.
similar viscosity fluids. Standard seals are nitrile rubber Follow instructions of hydraulic cylinder manufacturer
- check compatibility for medium. If in doubt, consult as applicable to bleed air from system. Pressurise to
factory. For low viscosity liquids, we recommend use of maximum pressure. Check for leaks in the system. Set
our MW series hand pumps with a poppet instead of ball relief valve (if fitted).
check valves, rather than the MC series.
MAINTENANCE
The body is tapped M8 in two places for mounting. The inlet strainer is easily accessible for cleaning. The
These holes must not be drilled out or otherwise inlet and outlet check valves are also easily serviced.
modified. Where it is not possible to utilise these holes Seals are easily replaced using standard tools. Service
for mounting, an optional mounting bracket is available. kits are available.
Mounting orientation must be as shown below because
of the necessity to keep the pump inlet flooded. SAFETY
This pump is a component forming part of a hydraulic
MATERIALS pressure system. The system should be designed ,
We offer two versions: The MC-O series compact pump is operated and maintained in accordance with statutory
manufactured in carbon steel, bronze and stainless steel. requirements and other relevant instructions.
The MC-3 series compact pump includes a 316 stainless
body and small amounts of 302/303/304/420/431
stainless and CW307 bronze.
DIMENSIONS
ALL DIMENSIONS in mm