Professional Documents
Culture Documents
Wcdma Cell Selection and Reselection PDF
Wcdma Cell Selection and Reselection PDF
PARAMETERS
MTN Ghana
INTRODUCTION
2
MTN Ghana
Cell selection
• When a UE is switched on
• When a UE in Idle mode has had a number of failed RRC connection
requests
• When a UE returns to Idle mode from the Connected mode on common
channels (CELL_FACH state) after a number of failed cell update attempts
• When a UE moves from dedicated mode to Idle mode
• When a UE returns to Idle mode after an emergency call on any PLMN
• When a UE moves from dedicated mode to state CELL_FACH or
URA_PCH.
3
MTN Ghana
CELL RESELECTION
4
MTN Ghana
CELL SELECTION/RESELECTION criteria
S - Criteria
• Measurements for GSM selection/reselection starts if
Squal < sRatSearch and/or Srxlev < sHcsRat where
R- Criteria
R(s)=Q meas (s) + qHyst (s) + Q offmbms
R(n)= Qmeas(n) – qOffset (s,n) + Qoffmbms – TO (n)
5
MTN Ghana
definition
• qQualMin is a cell parameter that indicates the minimum required quality
value in the cell for idle mode camping and is sent in SIB3 for the serving
cell and SIB11 for adjacent cells.
• qRxLevMin is a cell parameter that indicates the minimum required signal
strength in the cell for idle mode camping and is sent in SIB3 for the
serving cell and SIB11 for adjacent cells.
• Qqualmeas is the quality value measured by the UE expressed as CPICH
Ec/No
• Qrxlevmeas is the received signal strenght measured by the UE and expressed
as CPICH RSCP.
• Pcompensation is introduced for UEs that cannot trasmit at maximum power
on the RACH in the cell.
• maxTxPowerUl is a cell parameter that indicates the maximun allowed
transmitted power when the UE accesses the system on RACH and is
broadcasted on SIB3
6
MTN Ghana
definition
7
MTN Ghana
definition
8
MTN Ghana
PARAMETERS
9
MTN Ghana
PARAMETERS
11
MTN Ghana
PARAMETERS
• The UE reselects the cell if it is best ranked than the serving cell during a time
interval treSelection.
12
MTN Ghana
EXAMPLE
13
MTN Ghana
Cell reselection in DCH mODE-
mODE- IFHO
14
MTN Ghana
LAYER MANAGEMENT for multi-
multi- CARRIER
•This is a layer management for 2nd and 3rd carrier. HO ttype here is set to IFHO, IRAT
NONE.. Depending on coverage, traffic and position of the cell, whether border site or not.
15
MTN Ghana
• Questions
16