Professional Documents
Culture Documents
Cross Slats
Hanging Rod
Side Sections
Side Sections
Cross Slats
Screw Plug
Bottom Section
64
19
13 mm
305 mm
629 mm
610 mm
19 mm 19 mm
64
13
64
13
63
127 mm 343 mm 89
Side Front Side
19 19
140 mm
127 mm
89 mm
Bottom
Top
Scale (at P4) Drawn By: Project: Description:
1:7.5 RB Bathroom Stand Elevations
©2020 Makers Mob Agency Inc.
Chamfer base edges slightly when
assembled to avoid breakout
12
12
12
108
12
10
Add wood glue or construction adhesive for the added strength to all joints. Clean up residue to avoid unwanted
3
stains.
4 Plug screw and pin holes with wooden plugs or filler to hide screws if desired.
5 Pre-drill through top for 40mm-50mm wood screws or using angle brackets from underside to fasten top to base.
6 Plug screws with wooden plugs to hide screws if screwed through top.
7 Sand and finish/paint. Make sure to remove all glue residue before finishing.
Double check clearance for toilet paper rolls being used to clear bottom of the top back support. Lower holes for
Note.
rod if necessary.
Materials
Qty Profile X Profile Y Length
Cross Slats 7 19 mm 64 mm 343 mm
Bottom Section 1 19 mm 89 mm 305 mm
Sides 2 19 mm 89 mm 610 mm
Top Section 1 19 mm 133 mm 368 mm
The dimensions listed here are finished dimensions. Extra length and thickness should be added when calculating
Note.
the material needed.
Every effort was made to provide accurate dimensions. I am not responsible for any errors or omissions.
**Verify all dimensions before cutting.**