Professional Documents
Culture Documents
x
Getting Started
This document describes the how to get started with your pre-installed AEM3 Management
Software
AEM 3.X
GETTING STARTED
Contact Information
Headquarters Axell Wireless trading as Cobham Wireless
Aerial House, Asheridge Road
Chesham, Buckinghamshire
HP5 2QD, United Kingdom
Tel: +44 1494 777000
Fax: +44 1494 777002
Commercial inquiries cw.coverage@cobham.com
Website www.cobham.com/wireless
Support issues cw.support@cobham.com
Technical Support Line, English speaking +44 1494 777 747
Notice
Confidential - Authorized Customer Use
This document may be used in its complete form only and is solely for the use of Cobham Wireless employees and
authorized Cobham Wireless channels or customers. The material herein is proprietary to Cobham Wireless. Any
unauthorized reproduction, use or disclosure of any part thereof is strictly prohibited.
All trademarks and registered trademarks are the property of their respective owners.
Disclaimer of Liability
Contents herein are current as of the date of publication. Cobham Wireless reserves the right to change the contents
without prior notice. The information furnished by Cobham Wireless in this document is believed to be accurate and
reliable. However, Cobham Wireless assumes no responsibility for its use. In no event shall Cobham Wireless be liable
for any damage resulting from loss of data, loss of use, or loss of profits and Cobham Wireless further disclaims any and
all liability for indirect, incidental, special, consequential or other similes damages. This disclaimer of liability applies to all
products, publications and services during and after the warranty period.
Table of Contents
1 Introduction ................................................................................................................................................. 1
1 INTRODUCTION
For your convenience, the Alarm Element Management 3 (AEM 3.x) software has been pre-installed and
configured on your new server.
A default IP Address 192.168.1.100 is set on the first Ethernet network port. It is likely that you will need
to change the default set IP address to a one suitable for your local network (consult your local IT staff if
necessary to get a static IP address allocated).
Using the default access values given is section 2, follow the procedures on the following pages to change
the AEM server IP address in all the required places.
3. Select the Internet Protocol Version 4 (TCP/IPv4) row and click the Properties button.
Select Internet
Protocol Version 4
(TCP/IPv4)
Click Properties
4. In the Properties dialog, modify the values of the following parameters according to your network
requirements: IP Address, Subnet Mask, Default Gateway and DNS Server IP addresses.
Database tab
New IP Address
3. Select the Communication tab and update the IP address to the new setting:
AEM Configuration
Communication
tab
New IP Address
4. Click Apply to save the new settings and use the top-right corner X to close the tool.
5. In the Start Menu, select All Programs, Cobham Wireless, AEM 3, Communication Transceivers
and SNMP Transceiver Configuration Tool.
6. On the Server Connectivity tab, update the IP address to the new setting.
SNMP Transceiver
Configuration
Server
Connectivity tab
New IP Address
7. Click Apply to save the new settings and then use the X to close the tool.
8. In the Start Menu, select All Programs, Cobham Wireless, AEM 3, GUI Server, GUI Server
Configuration.
9. On the Server Connectivity tab, update the IP address to the new setting.
GUI Server
Configuration
Server
Connectivity tab
New IP Address
10. Click Apply to save the new settings and then use the X to close the tool.
11. RESTART the Server to synchronise all the changes.