Installation
Proline Promag H 300 HART
Orientation
‘The direction of the arrow on the sensor nameplate helps you to inst
according to the flow direction (direction of medium flow through the pi
rs a
B | onzonval onentaton rename a oO = wi
: dp
c wsmitter at TP
J
7 amare] ASI =
ns with low process temperatures may decease the ambient temper
this erent
2} Applications with high process temperatures may increase the ambient temperature. To manta 1
smanitnum ambien transmitter, this orientation i recommended
3} To prevent the electrons module ‘tom overheating inthe case of @ sharp nie Is temperature (eg. CIP or
SIP processes, instal the iter component pointing downwards
‘With the empty pipe detection function switched on: empty pipe detecion only works if the transmitter
housing is ponting upwards.
natn the
Horizontal
«Ideally, the measuring electrode plane should be horizontal. This prevents brief
insulation of the two measuring electrades by entrained air bubbles.
‘* Empty pipe detection only works if the transmitter housing is pointing upwards as
otherwise there is no guarantee that the empty pipe detection function will actually
respond to a partially filled or empty measuring tube.
—
GR 2
Sobel
1 EpD electrode forempty pipe detection (avaiable from,
2 Measuring electrodes for signal detection
IN> 15 mm 5)
EB Measuring devices with a nominal diameter < DN 15 mm (% in) do not have an EPD
electrode. In this ease, empty pipe detection is performed via the measuring,
electrodes.
Inlet and outlet runs
If possible, install the sensor upstream from
itt
ngs such as valves, T-pieces or elbows.
Observe the following inlet and outlet runs to comply with accuracy specifications: