Professional Documents
Culture Documents
Snug Nose-Bridge Fitted DIY Mask: Made by
Snug Nose-Bridge Fitted DIY Mask: Made by
Top
Place on Fold
Optional Pleat
STEP 1
• Cut outside and inside layers (option to
have more than on inside layer depening
on desired density)
• Place right sides together and sew top
seam across. Trim to small (3/16”) seam
allowance
STEP 2
• Open layers to wrong side of fabric and
place prepared nose strip in centre against
seam
Carefully fold down top and press with iron
to fuse into place. It will attach to outside
and inside fabric. If desired you may also
top stitch next to strip but that will add
extra holes into fabrics.
STEP 3
• With right sides together match lower
front seams on both lining and outer fabric
and sew curved seams ending in the fold
(secure with backstitch)
made by .com
Snug Nose-Bridge DIY Fitted Mask
STEP 4
• With rights sides together match
bottom edges aligning centre
seams and stitch across (ends
will be open)
STEP 5
• Turn right side out and top stitch
along bottom close to edge as
possible. Iron if desired (be
aware that some NWPP Non-wo-
ven Polypropylene has a low melt
temperature)
STEP 6
• Ends can be finished as desired
STEP 7
• sew elastic or cord
across end with zigzag
stitch
• Trim close to edge
made by .com