Professional Documents
Culture Documents
CAD Model #001 CAD Model #002 CAD Model #003 CAD Model #004
Manifold Tree Circular Plate Linkage Z-Bracket
CAD Model #005 CAD Model #006 CAD Model #007 CAD Model #008
U-Bracket Mounting Plate Pipe Strap Hex Fitting
CAD Model #009 CAD Model #010 CAD Model #011 CAD Model #012
Caster Bracket Stop Collar Tri-Linkage Wiring Box
CAD Model #017 CAD Model #018 CAD Model #019 CAD Model #020
Spindle Molded Boot Spring Lever Dual Port Shroud
CAD Model #021 CAD Model #022 CAD Model #023 CAD Model #024
Angle Tie Plate Flask Elbow +Ears Coupling
CAD Model #029 CAD Model #030 CAD Model #031 CAD Model #032
Fixture Block Regulator Body Spring Clip Wing Nut
CAD Model #033 CAD Model #034 CAD Model #035 CAD Model #036
Universal Joint Junction Box Washer Clip Circular Grill
CAD Model #041 CAD Model #042 CAD Model #043 CAD Model #044
Wheel Sheet Metal Box Hopper Pulley
CAD Model #045 CAD Model #046 CAD Model #047 CAD Model #048
Quick Connect Connector Core Connector Shell Spray Head
Copyright © 2008 Conceptual Product Development, Inc. 3 Robertson Rd., West Orange, NJ. 07052 World Rights Reserved: This may be copied for educational purposes only as a handout in a classroom.
This project may not be copied or incorporated into any product for resale such as a book or training manual without the express permission of the author.
Each plate has an accompanying page at the back of the manual that has a rendered
image of the part, a brief description, and a brief plan of attack for modeling the part.
Pulley
Description:
This part would be diecast from a metal
alloy. It requires several steps to develop
all of the features.
Basic Steps:
Start by creating a circular profile on the front vertical system plane and extruding it
backward to form the mass of the pulley.
Next, create a smaller circular profile on the same plane and extrude it forward to create
the hub.
Create a rectangular profile on the front surface of the hub. Use the cut function to punch
the keyway slot through the bore hole.
Use the hole function to create the tapped hole in the hub.
Create a circular profile on the horizontal system plane at the perimeter of the pulley and
use a revolved cut function to carve the groove around the circumference of the part.