Professional Documents
Culture Documents
Translation
Available
Copyright 2018 by Haas Automation, Inc. No unauthorized reproduction | Last Published On September 06, 2018 1/2
The G70 Finishing Cycle can be used to finish cut paths that are rough cut with stock removal cycles such as G71,
G72 and G73.
G71 P10 Q50 F.012 (rough out N10 to N50 the path) ;
N10 ;
F0.014 ;
... ;
N50 ;
... ;
The G70 cycle is similar to a local subprogram call. However, the G70 requires that a beginning block number (P code)
and an ending block number (Q code) be specified.
The G70 cycle is usually used after a G71, G72 or G73 has been performed using the blocks specified by P and Q.
Any F, S, or T codes with the PQ block are effective. After execution of the Q block, a rapid ( G00) is executed
returning the machine to the start position that was saved before the starting of the G70. The program then returns to
the block following the G70 call. A subprogram in the PQ sequence is acceptable providing that the subprogram does
not contain a block with an N code matching the Q specified by the G70 call. This feature is not compatible with
FANUC or YASNAC controls.
Copyright 2018 by Haas Automation, Inc. No unauthorized reproduction | Last Published On September 06, 2018 2/2