Professional Documents
Culture Documents
00) - Lathe
Translation
Available
*indicates optional
G74 End Face Grooving Cycle Peck Drilling: [1] Rapid, [2] Feed, [3] Programmed Path, [S] Start position, [P]
Peck retraction (Setting 22).
The G74 canned cycle is used for grooving on the face of a part, peck drilling, or turning.
A minimum of two pecking cycles occur, if an X, or U, code is added to a G74 block and X is not the current position.
One at the current location and then at the X location. The I code is the incremental distance between X-Axis pecking
cycles. Adding an I performs multiple pecking cycles between the starting position S and X. If the distance between S
and X is not evenly divisible by I then the last interval is less than I.
When K is added to a G74 block, pecking is performed at each interval specified by K, the peck is a rapid move
opposite the direction of feed with a distance defined by Setting 22. The D code can be used for grooving and turning
to provide material clearance when returning to starting plane S.
G74 End Face Grooving Cycle: [1] Rapid, [2] Feed, [3] Groove.
Copyright 2018 by Haas Automation, Inc. No unauthorized reproduction | Last Published On September 06, 2018 1/3
%
G74 End Face Grooving Cycle (Multiple Pass): [1] Rapid, [2] Feed, [3] Programmed path, [4] Groove.
Copyright 2018 by Haas Automation, Inc. No unauthorized reproduction | Last Published On September 06, 2018 2/3
%
Copyright 2018 by Haas Automation, Inc. No unauthorized reproduction | Last Published On September 06, 2018 3/3