Professional Documents
Culture Documents
Top view :- It is the top view of any design can be seen from top.
Side view:- It is side view of any design can be seen be seen from side.
Front View:- It is the front view of any design can be seen from its front.
As shown in figure.
Commands Used:-
Line:- Draws lines at any length. You can enter x, y, z coordinates of the point to specify start
and end point of 2D or 3D entities.
When using LINE command, system will always prompt to enter point, before pressing ENTER
to finish the command, users can specify series of points, but each line is an independent
object.
Circle:- Draws a circle of any size. Predicted method of drawing circle is through center point
and radius, but there are many other ways to draw.
Selects objects that define the cutting edges at which you want to trim an object, or press
ENTER to select all objects as potential cutting edges.
Offset:- Creates a new entity at the specified distance from an existing entity or through a
specified point.
Properties:- Displays the Properties dialog box, in which you can changes the relevant
properties of existing entity.
Procedure:-