Professional Documents
Culture Documents
3G Call Flow Analysis With TEMS
3G Call Flow Analysis With TEMS
Mobility
Used by the UTRAN to update the AS of
Active set Update / the UE. The Node Bs to which the UE is
AS Update complete simultaneously connected is called the
UE's AS
Used by the UE to update the UTRAN of
the current cell that the UE is camping on
Cell Update / Cell
after cell re-selection,or,as a supervision
Update Confirm
mechanism by means of periodic Cell
Updates
Used by the to retrieve a new URA Identity
after cell re-selection, when the new
URA Update/ URA selected cell does not belong to the URA
update confirm where the UE was initially residing, or, as a
supervision mechanism by means of
periodic URA Updates
Used by UTRAN to send new mobility
UTRAN Mobility
information to the UE. The information
Information/ UTRAN
consists of any one or a combination of a
Mobility Information
new C-RNTI, U-RNTI or any other mobility
Confirm
information
Used to transfer a connection between the
Cell Update/ Cell
UE and UTRAN to another radio access
Update Confirm
technology (i.e. GSM)
Handover to UTRAN
Used to transfer a connection between the
Command/ Handover
UE and another radio access technology
to UTRAN Command
(eg GSM to UTRAN)
Complete
The Mobile user decides to initiate a voice call. The first message
the UE will send on CCCH is RRC Connection Request. This will
contain among other things, Initial UE Identity and
Establishment Cause
The SRNC sends this message to Node B. It will pass the Cell Id,
TFS, TFCS, frequency, UL Scrambling code, etc to Node B.
The UE takes the new TMSI and responds with the Complete
message
The Node B and SRNC establish synchronism for the Iub Data
Transport Bearer by means of exchange of the appropriate DCH
frame protocol frames. SRNC sends the DL Synchronisation
frames.
Finally the SRNC instructs the Node B of the CFN at which the
new configuration will come into effect.
SRNC sends the RB Setup message to add the new DCH's. The
message will be received using the old configuration.
The ACM message is sent to indicate that the remote end of the
trunk circuit has been reserved.
The MSC/VLR sends the Connect message to the SRNC via Direct
Transfer message. The Connect message indictaes that the End
User has answered the call.
Measurement Control
Used by the UTRAN to inform the UE about the
measurements that it wishes the UE to perform
Measurement Report
Used by the UE to report the measurements collected by it
to the UTRAN