Professional Documents
Culture Documents
ZenFone Selfie ZD551KL PDF
ZenFone Selfie ZD551KL PDF
Introduction &Training
2015/06/17
ZD551KL Outline
• System Block Diagram
• Component and PCB Board Introduction
• Power On Sequence
• Trouble Shooting Guide
ZD551KL
Cam_I2C
28x16
Hall Sensor
Sub-board
Sub-board
ZD551KL Outline
SOC
8939 External-buck
I/O Con.
Charger IC
Backlight driver IC
BATT CON. Rear CAMERA 13M Conn. PMIC
PCB Board Introduction (BOTTOM)
E-compass Power key Con. Front CAMERA 13M Conn.
TP CON.
SIM 2
LCD CON.
2. Use USB and Adaptor to charge, but no system displays "charging symbol"
=> check Battery conn. CON9601 pin3—BAT_ID , Pin2: BAT_THERM if connector
solder skip or tin crack or Pin skew cause PMIC PU8401 can not detect and can not be
charged.
3. USB charging test items, insert the USB cable have shown AC charging
=> check USB connector USB_HS_D_M & USB_HS_D_P is short or not, if short, please
check sub board of the L0301 is damaged or Pin has Pin2 / Pin1, PIn3 / pin4 has Short, if
there is, please replace it.
When the USB can not connection , it can also check L0301, Pin2 / Pin3 whether there
turned on, PIN1 / pin4 whether there turned on, if " no“, L0301 is damaged, replace
Trouble Shooting Guide
SD card error
1. Confirm that SD Connector CON2301 solder skips
2. When you insert SD card, SD_DET # have no pull low ;
3. Confirm the SD_EXT_LDO voltage of PU9901 is 3V or not, if there is no voltage,
check if PU9901 has solder skips, It can be reheated or replaced
4. If 3V output, check the DATA 0 ~ 3 / CMD / CLK has a signal, if there are not
any set of signal, please check the following chart strings (R2314 ~ R2318,
R0802) is normal ;
Trouble Shooting Guide
SIM card error
1. Confirm SIM1 CON 2301, SIM2 CON 2302 has solder skips or not ;
2.Make adb command => adb shell getprop gsm.sim.state can be judged
SIM card status => ready representation SIM detected OK,
absent indicates no detected
3. For SIM1: check VREG_L14_UIM1 Voltage ;
For SIM2: When inserting a SIM2 card, UIM2 PRESENT is pulled low or not ;
check VREG_L15_UIM2 Voltage; UIM2_RESET is pulled high or not.
Trouble Shooting Guide
Laser Issue
• Laser Soft board FPC is located inside the box (red mark)
Please note that the soft board of When the lens before the test and
laser can not be bent (red mark) after the test, please stick with
tape protection
Laser Issue
• Check bezel in the carton box is working , and also check the
distance of bezel in near the both of 10cm Laser Lens and
40cm Laser Lens.
• Check Laser Lens are taping or blocked.
• Check Laser Lens is serious scratches or damage
• Use of alcohol cotton wipe Laser Focus Lens
• If not, you can try re-assembled middle bezel
• Finally, the soft board of laser in the can be replaced