Professional Documents
Culture Documents
JOB SETUP
Note: The following assumes that you will be setting up over a known UTM
NAD83 Geodetic Control Pt / or entering an “autonomous” UTM NAD83
position from your handheld GPS or Base Receiver as a “known” base
position to be adjusted later.
3. JOB / EDIT POINTS - Enter the coordinates of the Base Sta (if not
entered in step 1) and any other “Known” points to be used . (for
localization or checks etc)
Close
1
SET UP BASE STATION (as shown below)
-Turn on Base Reciever and allow it to initialize for at least 5 min before
turning the Base Radio on. Check for blinking TX light on radio.
2
SETUP ROVER (as shown below)
3
TO LOG DATA AT BASE DURING AN RTK SURVEY
MAIN MENU
IMP! When performing any RTK Survey check into a known point
after the base station and rover are running to verify setup is okay!!