4 AUTOMATIC TRANSFER SWITCH, OTM_C_21D
Product overview
Product overview
‘The OTM_C_2ID automatic transfer switch can be
used as a source transfer switch in athreephase or
single-phase networks. Monitored conditions are,
no-voltage, phase-loss, overvoltage and under:
voltage detection, transfer delays, generator start
and stop, and remote test function
iL
Source transfer can be performed using a manu
ally operated handle, locally using push buttons or
fully automatically. The automatic mode includes
several operating methods: Line I priority, no line
priority and manual back switching mode
Figure 1 OTM_C_21D automatic transfer switch.
Handle for manual operation
Place for auxihary contact blocks
Push button
Mimic panel
Voltage sensing connections
Locking clip for padlock
The standard package includes:
Locking latch for releasing the handle and
locking electrical control
Locking clip for locking manual operation
Dip switches
Rotary switches
Connecting terminal
Hees
1 automatic transfer switch, 2. handle, 3. handle storage clip and 4. terminal plugAUTOMATIC TRANSFER SWITCH, OTM_C_21D 5
OTM_C_24D switching sequence
Line 1 Priority (default mode)
‘The switching sequence of OTM_
summarizedin following steps
21D can be
+ An anomaly occurs on the Line 1 (LN)
+ Switching delay Ts, in case of phase loss, over
voltage and undervoltage conditions
+ Generator start, immediate start generator
in case of black-out, in case of phase-loss,
overvoltage or undervoltage after switching
delay Ts. (if Generator modeis selected)
+ Change-over switch (Switch |) to the position 0
+ Change-over switch (Switch Il) to the position I
Figure 2. Automatic Switching Sequences in OTM
‘The back switching sequence can be summarized
inthe following steps:
+ The Line 1will start the normal functioning
+ Back switching delay Tbs
+ Change-over switch (Switch Il) to the position 0
+ Change-over switch (Switch |) to the position |
+ Generator stop delay Gs
+ Generator stop
__21D, Line Lpriority