Professional Documents
Culture Documents
CPC Fluids - Andy
CPC Fluids - Andy
2. The normal stress is the same in all directions at a point in a fluid only when
3. If a cylindrical wooden pole (gravity 0.6), 0cm in diameter and 1m in height is placed in a
pool of water in a vertical position. Then it will be
2. The normal stress is the same in all directions at a point in a fluid only when
3. If a cylindrical wooden pole (gravity 0.6), 0cm in diameter and 1m in height is placed in a
pool of water in a vertical position. Then it will be
a. Parallel
b. Cut at any angle
c. Are orthogonal everywhere in the flow field
d. Cut orthogonally except at the stagnation points
a. Energy
b. Mass
c. Momentum
d. Pressure
8. The locus of elevation that water will rise in a series of pitot tubes is called
9. Air enters a rectangular duct measuring 30x40 cm 2 with a velocity of 8.5 m/s and a
temperature of 40oC. Kinematic viscosity of the air is 16.95x10 -6 m2/s. What will be the
Reynolds number?
a. 1.72x105
b. 2.58x105
c. 0.86x105
d. 0.72x105
u/u ∞ = (y/δ)1/9
the ratio of displacement thickness to nominal layer thickness will be
a. Froude number
b. Webber number
c. Mach number
d. Euler number
12. The discharge over a right angled notch is (where H = Height of liquid above the apex of notch)
a. Cd 2g x H
b. Cd 2g x H3/2
c. Cd 2g x H2
d. Cd 2g x H5/2
13. In an inclined manometer, 30o to horizontal measures the pressure difference between two
locations of a pipe carrying water. The manometric liquid is mercury (specific gravity = 13.6).
The manometer showed a level difference of 20 cm. The pressure head difference of water
between the two tapping will be
a. Horizontal line
b. Inclined line with flow upwards
c. Inclined line with flow downwards
d. Any direction and in any location
15. Oil flows through a 200 mm diameter horizontal cast iron pipe (friction factor 4f= 0.0225) of
length 500m. The volumetric flow rate is 0.2m 3/s. The head loss ( in m) due to friction is