Professional Documents
Culture Documents
Introduction
Long wire runs to a float switch in a tank or Caution: A suitable crimping plier must be used to con-
long horizontal wiring runs to a well probe nect the cables with the splice kit:
can pick up damaging surges from nearby The correct polarity is important when con-
lightning. necting the Surge Protector to the controller.
Wrong polarity will cause false sensor signals.
To best protect the controller then shield-
ed, twisted-pair cable should be used.
Where this is not possible then the NO/NC COM
LORENTZ Surge Protector Unit can be con-
nected to the controller to reduce problems Figure 3: sensor cable spliced to Surge Protec-
caused by induced voltages. tor
Installation
BERNT LORENTZ GmbH & Co. KG Siebenstuecken 24, 24558 Henstedt-Ulzburg, Germany, Tel. +49 (0) 4193 8806 - 700, Fax - 708, www.lorentz.de
All specifications and information are given with good intent, errors are possible and products may be subject to change without notice. Pictures may Sun. Water. Life.
180710
differ from actual products depending on local market requirements and regulations.