Professional Documents
Culture Documents
4. Various items of information for systems like engines, fuel, navigation and which do not agree with a
warning,
a- are directly sent to the DUs.
b- are directly sent to the ATSU.
c- are directly sent to the DMCs.
5. The information regarding engine parameters and flap slat position is displayed
a- On upper portion of ECAM
b- On SD page
c- On flight control page through ECP key selection.
8. The advisory ADV symbol flashes on upper EWD, it means ECAM is.
a- Active
b- Connected to CFDIU
c- In mono mode
11. In case an aircraft system failure occur, the EWD page will show ECAM actions to be performed along
a- with fault lights on annunciater and relevant SD page displayed.
b- with fault lights on annunciater
c- relevant SD page displayed.
13. The fault title disappears from EWD and memo message appears when you press.
a- STS
b- ADV
c- CLR
17. Three dashes in blue after gross weight indicate that there
a- Is no data in computer.
b- Data is incorrect.
c- Gross weight is fluctuating.
18. During flight ECAM electrical page appears with IDG temperature flashing,
a- This mode is caution mode.
b- This mode is menu mode.
c- This mode is advisory mode.
19. A flight is divided into 10 phases corresponding to an
a- Aircraft configuration change.
b- Aircraft indicated speed.
c- Aircraft altitude and speed.
20. The APU or engine pages are displayed in priority if the APU or the engines are started,
a- In any flight phase.
b- Before take off
c- In advisory mode
21. The APU page disappears when APU master switch is switched OFF or the APU RPM is
a- Above 90% for 10 seconds.
b- Above 95% for 5 seconds.
c- Above 95% for 10 seconds.
22. What is displayed on the right memo area of the EWD to indicate warning is inhibited.
a- TO INHIBIT
b- INHIBIT
c- No warning is displayed
23. What page appears as soon as the slats are retracted and the engines are not at take off power?
a- Engine page
b- Cruise page
c- Status page
24. The CRUISE page disappears when the landing gear is selected down and ALT
a- below 16000 feet
b- above 16000 m
c- 1600 feet
25. How long after the last engine shutdown the FWC starts a new flight leg at phase 1?
a- four minutes
b- three minutes
c- five minutes
26. What page would appear on SD page after applying takeoff power till 1500 feet?
a- Wheel
b- Cruise
c- Engine
27. When the ALL key is pressed and held, all the system pages are displayed successively in
a- One second intervals.
b- Every time key is pressed
c- Two seconds.
30. A flight warning computer fails; another FWC takes its control.
a- This type of failure is primary.
b- This type of failure is reported via ATSU
c- This type of failure is independent.
31. Hydraulic pump failure appears with a box around its title.
a- This means it’s a primary failure.
b- This means it’s a secondary failure.
c- This means it’s an advisory message.
32. The titles of the system pages corresponding to the secondary failures are indicated on the lower
right part of the Engine/Warning Display (EWD) by
a- A line
b- An asterisk.
c- Pulsing line
33. The ELEC page will be displayed if the IDG temperature increases above its normal value, but is still
below the threshold of the warning.
a- This is because of advisory mode of DMC
b- This is because of alert mode of ECAM
c- This is because of advisory mode of ECAM
34. FWC sends _______signals to Master and Caution lights while ______ signal to loud speaker.
a- Analogue and discreet
b- Discreet and analogue
c- Digital and analogue
37. What generates alphanumeric codes corresponding to all texts and messages to be displayed on the
ECAM DUs?
a- Only FMC1
b- Each FWC
c- Each SDAC
38. Flight phase computation is carried out by
a- FWC
b- DMC
c- SDAC
39. Each FWC sends a copy of its own acquisition through an ARINC 429 bus to the
a- SDAC
b- Opposite FWC.
c- MDDU