Professional Documents
Culture Documents
a. The ATT HDG switch must be used on the switching panel in order to
recover PFD information
b. The image automatically transfers to the UPPER ECAM
c. It has to be manually activated
d. The image automatically transfers to the display formerly occupied by
the ND
Once the crewmember has completed viewing a specific system, what is the
correct procedure for clearing the display and turning it to a normal
presentation ?
If the UPPER ECAM DU fails, what will be displayed on the lower unit ?
a. Status page
b. Engines and Warning page (E/WD)
c. System display page
a. 4
b. 3
c. 2
a. White
b. Amber
c. Red
d. Yellow
After a single DMC failure, how could a crew member recover the display
units?
In case of a double FWC failure master caution light, master warning light
aural warnings and ECAM cautions and warning are lost
a. True
b. False
a. By rotating the ECAM/ND XFR switch on the switching panel, the lower
ECAM page will be transferred the CAPTAIN or FOs ND
b. By pressing and holding the related systems page pushbutton on the
ECAM control panel the page displayed on the UPPER ECAM
c. Both are correct
a. No power
b. DMC failure
c. Both are correct
Where is information displayed by DMC #1 and DMC #2 ?
On a bottom of the STATUS page, what does the green arrow mean ?
What is the meaning of 9000 in blue at the top of the altitude scale?
The upper ECAM DU has failed. You want to see the DOOR/OXY page. How
can you see it ?
a. You have to press and hold the DOOR key on the ECP
b. You have to switch the EIS DMC to CAPT 3
c. You have to press and hold the RCL key on the ECP
How did the PFN cancel the caution for the NAV ILS 1 FAULT before calling
the STATUS page on the ECAM
a. On the FOs PFD when his ILS pushbutton is selected on and on the
captain ND when the captains ND is selected to ILS ROSE
b. The first two statement are correct
c. On the captains PFD when the captains ILS pushbutton is selected ON
VOR ILS and NDB raw data information is displayed on the ND which of the
following modes ?
a. VOR RMI and NDB information may be displayed in the ARC or ROSE
NAV modes
b. VOR and ILS information can be displayed in the ROSE VOR and ROSE ILS
modes respectively
c. Both are correct
After the engine shutdown, you observe a pulsing STS message. What does it
mean ?
a. On the capt ND when the capt VOR bearing selector is selected to VOR
b. VOR #1 course information is available on the capt PFD and ND when
the captain ILS pb is selected
c. On the capt PFD when the capt VOR bearing selector is selected to VOR
The maximum speed to select next higher flap setting is indicated by two
amber dashes
a. False
b. True