Desarmado y Armado
Cit and C13 Engines
esi 01/12/2014 central 05/12/2014
‘Turbocharger - Remove - Low Pressure Turbocharger
swes 1052-01
Removal Procedure
1. Place identiaton mats onthe bellows for alignment and rintton during the instalation.
NOTICE
Failure to fllow established procedures can lead to damage of the
parts
Toaveid
that th
CAUTION
The ends ofthe bellows are very sharp Injury could occur ifthe bellowsss c9onnape EogmRCBELINEEWAS-€9 Donon
are not handled propery. Handle the bellows by the convolutions.
‘Note: Refer to Special Instruction, REHS1728, “Application Guideline forthe Bellows" for ations information on handing the bellows
2. Loosen clamp (4)
5. Position clamp (4) over bellows (8)
4, Loosen
6 Position clamp (6) ove below ()
7, Remove elbow (4), sow (8), and elbow (3)
8, Disconnect elbow (1)
9, Remove clamp (9)
10, Disconnect ol supply tube astembly (2) an oi dein tube assembly (10)
11, Remove nus (12)
12, Use a suitable iting device ‘The weigh of the turbocharger is approximately 29 kg (65 Ib) Remove turbocharger (13)
nentnsene inane mcenblahtatie pag