Desarmado y Armado
Cit and C13 Engines
Nero de mecio-Sts70%-11 Fach d pubnlon-01/12/2014
Camshaft Bearings - Install
sMes- 1211-012,
Installation Procedure
‘Tablet
Required Tools
Tool Part Number Part Description ay
85.2241 Camshaft Bearing Too! Groop_ |_|
2UI-A2I4 Receiving Sleeve 1
201-213 Puller Pate T
201-8209 Bearing Pilot i
A 201-8208 Backup Pate 1
‘Taperiock Stud
88-4292 Extension (Shor) 2
88-4293.) Extension (Long) T
NOTICE
‘Keep all parts clean from contaminants.
Contaminants may cause rapid wear and shortened component li
rach d actuteaclon-05/12/2014
1. Position new camshaft bearing (1) in Tooling (A) and install the bearing from the rear tothe font ofthe engine.
tesa tinea pt papipheineannetae Snes sh eee enc pthss 20pm CBINEEWAS-€9 Donen
2. The camshaft bearings are installed with Tooling (A). Measure the depth of the camshaft bearings from the font fee of the eylinder block to
the following distances
4 Dimension (A) 83650 mm (1.457 inch)
3 Dimension (Bs 19250 mm (7.579 inh,
«Dimension (C) is 3480 mm (13.720 inh),
4. Dimension (D) 8 S04 50 mm (19862 inc).
«Dimension () is 560.50 mam (25.04 ney,
£ mension (F) i 81650 mm (32.148 inc),
Dimension (G) is 972.50 mm (38.287 inch).
NOTICE
must be installed int their correct position, Failure
todo so will result in engine damage.
(2) Bearing joint
)oiale
{H) Bearing ol hoe is located a AS degre angle fom vertical All seven bearings have these angle
nd By:
4 Install the camshaft Refer to Disassembly and Assembly, "Camshaft Install"
by Install the lifter group. Refer to Disassembly and Assembly, “Lifter Group - Remove and Install”ss 9 onta Com RCBELINSEWES-€9 Donen
tesa tinea pt papipheineannetae Snes sh eee enc pth