Professional Documents
Culture Documents
MIL-I-2476W2
25 February 1992
SUPERSEDING
MIL-P-18177C
25 May 1%0
The requirements for acquiring the insulation material described herein shall consist of this
specification sheet and the issue of the following specification listed in that issue of the Department
of Defense Index of Specifications and Standards (DODISS) specified in the solicitation:
MILI-24768.
REQUIREMENTS:
Construction: The material shall consist of plies or layers of glass cloth or nonwoven parallel
aligned fibem impregnated and bonded with an epoxy-resin compound or binder, oriented and
processed to conform to this specification.
Intended use The laminated material covered by this specification is intended for use in
electronics applications requiring moisture resistance and high mechanical strength. The laminated
material GEE is not intended for applications requiring arc and flame resistance. Caution should
be used in applications involving high mechanical stresses at elevated temperatures.
Forms: Sheets, rolled tubes, and rods are recommended forms of laminated material covered by
this specification.
Temperature indices: The laminated material covered by this specification has a mechanical
strength test index of 140, and an electrical strength test index of 130.
Thickness of sheets: The thickness of laminated sheets, permissible variations, and the
applicable part number shall be as specified in table I.
lof9
MIL-I-24768f2
2
MIL-I-2476W2
lFor part numbers of sheets not listed in this table, the thickness shall be included after the part
number. Example of this for a 0.8125 inch thick sheet is: M24768/2-S-48-O.8125.
20n sheets of nominal thickness not listed in this table, the permissible variations shall be the same
as for the next greater thickness.
Diameter of roZled round rubes: The range of sizes for rolled round tubes shall be as speeified
in table II. The inside diameter and outside diameter shall be included in the part number.
An example of a part number for a rolled round tube with an inside diameter of 0.125 inch
and art outside diameter of 0.156 inch shall be: M2476W2-TRR-0. 125/0.156. The wall
thickness tolerances for rolled round tubes with an inside diameter up to 4 inches shall be as
specified in table 111.
0.010 to 0.015
0.016 to 0.030 0.006
0.031to 0.061 0.00s
0.052 to 0.124 0.009
0.125 to 0.249 0.011
0.250 to 0.500 0.013
Dbneter of rods: The range of sizes and tolerances for rods shall be as specified in table W.
The outside diameter of the rod shall be included in the part number. An example of a part
number for a rod with an outside diameter of 0.250 inch shall be: M2476W27-R-O.250.
3
MIL-I-247W2
a. Tracking resistance
b. Thermal endurance
c. SilieOne content
d. Flammability.
Testing: The laminated material covered by this specification shall be tested under qualification
inspection requirements.
4
MIL-I-247W2
0 w:
F v.
o r:
1- v,
5
6
—
u“
c
8
n-
/
MIL-I-2476W2
Review activities:
Army – MI, AR, EA
Navy – EC, OS
Air Force – 85
User activities:
Army – ME
Navy - MC, AS