The document provides instructions for setting anchors and securing an enclosure to the floor in 4 steps. It recommends using a stud type anchor with the enclosure's 1-hole washers since their diameter is 0.563 inches. It also notes the total height of the enclosure metal surrounding each mounting hole including the washer is 0.74 inches. The instructions then describe placing the enclosure over the anchoring holes and installing washers and nuts finger tight before checking for levelness and tightening the nuts.
The document provides instructions for setting anchors and securing an enclosure to the floor in 4 steps. It recommends using a stud type anchor with the enclosure's 1-hole washers since their diameter is 0.563 inches. It also notes the total height of the enclosure metal surrounding each mounting hole including the washer is 0.74 inches. The instructions then describe placing the enclosure over the anchoring holes and installing washers and nuts finger tight before checking for levelness and tightening the nuts.
The document provides instructions for setting anchors and securing an enclosure to the floor in 4 steps. It recommends using a stud type anchor with the enclosure's 1-hole washers since their diameter is 0.563 inches. It also notes the total height of the enclosure metal surrounding each mounting hole including the washer is 0.74 inches. The instructions then describe placing the enclosure over the anchoring holes and installing washers and nuts finger tight before checking for levelness and tightening the nuts.
Figure 8: Setting the Anchors and Securing the Enclosure to the Floor
Anchor Nut
Anchor Washer
Enclosure 1-Hole Washer
Stud Type Anchor
Setting the Anchors
1. Before setting the anchor, review manufacturer’s instructions.
2. A loose, ¼” [6.4 mm] thick seismic, 1-hole washer is provided at each corner. Since the 1-hole washer’s hole diameter is 0.563” [14.3 mm], a stud type anchor is recommended. 3. The total height of the enclosure metal surrounding each mounting hole, including 1-hole washer, is 0.74” [18.8 mm]. 4. Remove the nut and washer from the anchor. 5. For each anchor, drop the anchor into the drilled hole. Insert the anchor setting tool and hit it with a hammer to expand the anchor.
Placing and Securing the Enclosure to the Floor
1. Place the enclosure into position over the anchoring holes.
2. Install the anchor washer and anchor nut FINGER TIGHT for each anchor. 3. Check the enclosure is level front-to-back and side-to-side. Install shims if necessary. 4. When the enclosure is level, tighten all nuts to the appropriate torque.
Vertiv | NetSure 7100 Series -48V DC Power System Installation Manual (IM582127000) | Rev. BB 29