Professional Documents
Culture Documents
CROSS REGU (Final)
CROSS REGU (Final)
500 OF
NAME OF PROJECT : BIKANER CANAL
DESIGN DATA :
Generally the crest level of the distributory head regulator is kept .15 M TO .5 M higher than its U/S floor level.
Regulators are generally provided with a very wide and shallow water way. The drowned
weir formula is therefore,used for calculating the discharge.The system must be designed in
such a way that it should mitigate all type of head losses occurred during its regulation.
Assuming the effective clear water way under barrels is 108% average width of D/S canal
Effective water way = 24.40 m (% is taken to equalize water way provided)
Vb = 1.07 m/s
Head losses due to 3-D warped inlet & outlet transitions as per cl. 4.1 IS:7114-1973
HL = -0.020 m
L = 7.815
Waterway shall be worked out with the following formula
Q = C.BeHe3/2
Where,
hd = 170.000 - 170.000 = 0.000 m
He = 170.089 - 165.150 = 4.939 m
hd + ha
= 0.01796
He
From fig. 6.5,Varshney vol-II, The ratio of modified coefficient to free discharge works out to
Cs
= 0.195
C
Thus the coefficient of discharge = 1.820 X 0.195
= 0.356
(The value of 1.82 is for sharp crest free fall)
Substituting the values,
Be = 10.249 m
The effective width works out to very small.
So Minimum clear waterway = 60 % of distributary width
% Fluming = 4.800
Be = 10.249 m
Thus clear waterway required = 10.249 m
40.000
Discharge intensity q = --------- = 1.356 cumec/m
29.500
Head loss = u.s. F.S.L. - d.s. F.S.L.
= 170.000 - 170.000
= 0.000 m
for, q = 1.356 cumec/m and HL = 0.000 m
D/s specific energy Ef2 (from Blench curves) = 1.006 m
Cistern floor level required = D/s F.S.L. - Ef2
= 170.000 - 1.006
= 168.994 m
As per IS 6531 : 1994, on the upstream side of the head regulator, cut-off should be provided
to the same depth as the cut-off stream of diversion work, if it exists or may be calculated as
below :-
Discharge intensity 'q' = 1.356 cumec/m
Depth of scour 'R' = 1.35{q2/f}1/3 = 1.863 m
Anticipated scour = 1.25 R = 2.328 m
= 162.83
The floor shall be subjected to the maximum static head when full supply is being maintained in the
upstream for running the parent channel and there is no flow through the distributary head.
Since, H 1
GE = ---- ---------
d pÖl
Hence,
1 GE.d
------------- = ------------- = 0.100
pÖl H
From Khosla's exit gradient curve a = 19.238
Hence requirement of total floor length b = a .d
= 57.715 m
CREST 165.15 M
2 :1 d/s glacis
1 :1 u/s Cistern Level 165.000 C.B.L. 165.000
U/S Bed Level 165.000
### m 0.85
1.90 1.60 1.35
162.83
162.00
58.0 m
Accepted By
HL = 0.00
q = 1.36
DC = 0.57
HL/DC
Sequent depth determination
= 0.23 0.7
D1/DC = 0.60
D1 = 0.34 0.6
D2 = 0.89
D1/DC
0.5
Ef1 = 1.14
Ef2 = 1.01 0.4
0.3
0.2
1.01
0.1
0
0.000 10.000 20.000 HL/DC
30.000 40.000 50.000 60.000