VS PARTICULAR MATERIAL APPRAISAL
(PRESSURE EQUIPMENT DIRECTIVE-2014/68/EU)
Pressure Equipment Manufacturer: VRV ASIA PACIFIC PVT LTD
PMA Ref. No.
RV/CE/04 | Rev.No. 01 Material Group & Sub Group: 1&1
Material specification
IS 2062 : 2011
Grade: £250 Delivery condition: Killed or semi killed
Applicable Design Code: EN 13458-2
Dimension range :
Size : 40mm x 40mm to 100 mm x 100 mm
Thickness : 4 mm to 10 mm
Application: Detail ‘Comments
Vessel v | Type : Outer Jacket for
Piping -- | Cryogenic vessel
Equipment Pressure (angles, channels, beams)
Accessories
Assembly
Gas
Liquid -
Flu Group 1 v
Group 2
1
"
Category if
L Iv v
Operating Conditions: Details ‘Comments
‘Maximum Allowable Working Pressure bar_| 1.013 bar
Allowable Temperature Range ®C -20°C to 50°C
‘And where ever relevant
corrosion =
ageing =
formability Suitable for rolling
weldability Suitable for welding
‘machinability Suitable for machining
Specific Requirements
| Property Requirement Specification Comments
Min. Yield strength 250 Mpa Indian Standard governs the
Strength allowable stress and meets
Lo Min. Tensile strength __| 410 Mpa the requirement
Toughness at Lowest Grade meets the
Toughness operating temperature | 27) requirement
-208C
Ductility = Meets the requirement
Formability Suitable for machining | Suitable for machining and | s4.61s the requirement
and welding welding _
Indian Standard governs the
AllowableStess | sco iyps 250 Mpa allowable stress and meets
the requirement
Page 1 of 2
HHVY PARTICULAR MATERIAL APPRAISAL
(PRESSURE EQUIPMENT DIRECTIVE-2014/68/EU)
Conditions
In Addition to the requirements of the above specification each batch of material used in this application shall
be covered by a certificate of specific material control as evidence of conformity with the following
requirements
Property Requirement Test method(Specification) | Comment |
‘Chemical C-0.22%,Mn-1.5%,P- ie 2a
Composition __| 0.045%,5-0.045%, Si-0.4%
Tensile Strength-
Mechanical 410Mpa;Vield Strength-
Properties 250Mpa;Elongation-23% | '° 1608, IS 1599 & 181757
Toughness-27)
Certification according to
Certification according to EN
Material EN 10204:2004 . 10204:2004 inspection
Certification Inspection Certificate Certifeate "tyoe's 1"
minimum “type 3.1"
Traceability to heat/lot Manufacturer name or trade
Material Marking | identity of the material | ~ mark ,size, material
manufacturer specification
The above material has been appraised for compliance with the essential safety requirements of the PED for
the above application and has been granted a Particular Material Appraisal subject to the conditions listed.
Revisions to the parent specification, by the issuing authority, are to be reviewed by the manufacturer, and
where applicable advised to the notified body, and may result in invalidation of this PMA
WIL Be
Signed: Date: 26" 5uly elt
(Pressure Equipment Manufacturer)
Confirmed: Date:
Notified Body (Cats Ill & IV only)
Page 2 of 2