You are on page 1of 2
TECHNICAL DOCUMENT “arameter marking indicate sampling plan and acceptance criteria as mentioned below # wt ” 2 nos per lot & No defective 1 per lot & No defective 10 nos per lot & No defective For all other parameters (without marking) comprehensive inspection to be done ‘once in 3 months for 3 nos and no defectives ‘SMH 06/08/09 25/08 [0 6215 1 6239 2 Signature: -sd- lame:_C Sathish Kumar, [approved by: [Signature -sd- Name: __R. Anbuselvan, Format No.F/04/PD/6 Not! The doununt- teu Propud heyed en the rat diléuls (Speesfiaion Dovid by Mr. SriRemati (ac) LE. TECHNICAL DOCUMENT frechnical Doc, No[Date: 05.08.09 0244/2 lsheet 1 of 2 Parameters ‘Specification Method of Inspection 4 1 fe Condition fickel Plus Chromium Plating [Driple layer [Bottom (Dull) - 12.5 microns lickel Plating fiddle (High Sulphur) - 2.5 microns ISTEP test / Thickness Thickness # Trop (Bright) - 10 microns JGauge +ve Potential Difference : 100 - 200mY | ve Potential Difference : 15 - 35mV_ TEP Test / Thickness |Gauge / Microscopic IChromium Plating naeaer a \0.5 microns (Min.) yr [Heat 10 250°C for I hoi idhesion t# No Peel-off [a Quench in water at JRoom Temperature |Free from Peel-off, Pittings, Uncoverage of Nickel d& Visual Appearance ** Yon nom Visual Inspection should be covered Uniformly & neatly with Corrosion resistant Aluminum paint. All welded area, Hole Visual Inspection periphery should be covered 100%. Visual appearance at jweld joints & Holes ** Visual appearance at ‘i erraticnn Kinling, ‘SHOuld be covered uniformly and neatly with Corrosion fe [Resistant Aluminum paint/lacquer. Visual Inspection 1s feceptance rating shall |48 Hours min. in "Copper Accelerated A Se arora |Corrosion Resistance > {Spray (CASS) Test"as per IS 5528 lpeerey ats tors |#eat treatment after Electro-plating is required for items iydrogen ioe 1 heinecs abe. |Test Certificate lembrittement Relieg [ef Fensile Srengih above 1000Mpa o Hardness above Verification __ SMH 06/08/09 TTR [oy — ©2320 Thecked hus Signature: -sd- ISignature: sd Name: __S. Mubarak Hameed IName:__R. Anbuselvan Format No.F/0S/PD/16 No) Thi downunt hes Prspartd fared un the May'01 dail (speufiemlin Providid by Mr. SeiRamalu (oe RE.

You might also like