m™ 07842b5 0503980 960 mm
ANSI/AWS B2.1-1-016-94
Page 3 of 12
Standard Welding Procedure Specification (WPS)
POSTWELD HEAT TREATMENT
Postweld Heat Treatmer
‘Welds may either be as-wolded or postweld heat treated at 1100 to 1200°F. It
heat treated, the heat treatment time shall be 1 hour per inch of thickness.
(15 minutes minimum) unless otherwise noted in the fabrication document.
ELECTRICAL CHARACTERISTICS
Electrode"
Classification Dia? in, Amperes Polarity
£7018 3/82 70-110 DCEP (Reverse)
E7018 18 90-150 DCEP (Reverse)
£7018 5/32 120-190 DGEP (Reverse)
E7018 36 170-280 DCEP (Reverse)
1. The cara and storage of electrodes shall be as recommended by the electrode
manufacture.
2. 3/16 in. diameter shell not be used for tack or root pass welding nor for welding in
the vertical or overhead positions,
Pulsing Current: Not permitted
‘TECHNIQUE
Weave or Stringer Bes
Either
Not required; if used, proceed as permitted by the fabrication document
Chemical or mechanical joint shall be dy prior to welding
Interpass Cleaning: Mechanical only
Backgouging: ‘Mechanical or thermal when required by Figure 1
Gouging: Mechanical or thermal
Single or Multiple Passos: Either
Maximum Bead Thickness: 1/4 in.
COMPANY NAME
Inthe name of the Company stated above, | accept full esponsibility for the application of this Standard WPS
for use with:
Dated
Fabrication Document(s): such as Code, Specification or Contract Document
DATE APPROVED BY TITLE
oprah by the Ameian Nellag Soci
Satu 05 141634 1997