Professional Documents
Culture Documents
HT Viz ClipSpine PDF
HT Viz ClipSpine PDF
Introduction
In addition to clipping along a line, EnSight also provides clipping along a defined spline. Spline clips
will query the 2D or 3D parent parts at samples taken along the spline at evenly spaced intervals. Values
along a spline clip can be visualized using profiles, queried and sent to a plotter, or used in further
computations (for example, a line integral).
Basic Operation
1. Select the parent part.
4. Select the desired Spline (to create a Spline, see Use the Spline Tool (p. ?).
Note:
To adjust the clip you can grab the spline knot points and adjust. The clip will update.
Other Notes
It is sometimes useful to display just the nodes of a spline clip. Using the Feature Panel you can change
the display such that only nodes (not lines) are displayed. The nodes can be shown as dots, crosses, or
spheres. If displayed as crosses or spheres, the size (radius) can be constant or scaled by the value of a
variable. See Set Attributes for more information.
See Also
Introduction to Part Creation, Use the Spline Tool, Create Profile Plots (p. ?), Query/Plot
Release 2020 R1 - © ANSYS, Inc. All rights reserved. - Contains proprietary and confidential information
of ANSYS, Inc. and its subsidiaries and affiliates. 1
Create Clip Splines
Other clips: Create Clip Planes (p. ?), Create Clip Lines, Create Quadric Clips (p. ?), Create Box Clips,
Create IJK Clips (p. ?), Create XYZ Clips, Create RTZ Clips
Release 2020 R1 - © ANSYS, Inc. All rights reserved. - Contains proprietary and confidential information
2 of ANSYS, Inc. and its subsidiaries and affiliates.