Professional Documents
Culture Documents
www.victronenergy.com
Features
- Load output with low battery voltage disconnect function.
- Lighting control function, one timer only.
- Two digit seven segment display for quick and easy setting of the load output functionality,
including timer setting.
- Three stage battery charging (bulk, absorption, float), not programmable.
- Load output protected against over load and short circuit.
- Protected against reverse polarity connection of the solar array and/or battery.
BlueSolar PWM-Light 10 A
Day/night timing options
See manual for details
1) For 12V use 36 cell solar panels 2) The controller switches to the lower float voltage level 2
For 24V use 72 cell solar panels hours after the absorption voltage has been reached.
or 2x 36 cell in series Whenever the battery voltage becomes lower than 13 V, a
new charge cycle is triggered.
Revision : Rev 03
Date : 01-04-2015
d Debug mode
Same as L mode but without delay of 10s/1min
5. SPECIFICATIONS
Green LED: Overload protection Shut down after 5 s in case of 160% load
Off: No sunlight or not enough sunlight. Charger off. Short circuit: immediate shut down
Fast flashing: Bulk charge.
On: Absorption charge. Grounding Common positive
Slow flashing: Float charge. Operating temp. range -20 to +50°C (full load)
LED=Green: battery fully charged (> 13,4V) Humidity (non Max 95 %
LED=Orange: battery ok (12,4V - 13,4V) d i ) Settings
LED=Red: battery low (11,2V - 12,4V)
LED=Flashing Red: battery fully discharged (< 11,2V) Charge voltage 'absorption' 14.2 V / 28,4 V
(load output cut off level: 11,2V) Charge voltage 'float' 13.8 V / 27,6 V