Professional Documents
Culture Documents
Reb500 (Ahmed Elsherif) : 2-To Connect Via LAN Cable
Reb500 (Ahmed Elsherif) : 2-To Connect Via LAN Cable
Then connect the cable back side the central unit in (LAN1), then go through the relay
screen menu [Central unit][settings][LAN][HMI][IP address].
3- To take the settings in relay Go to (File)(upload from protection system)
4- To adjust Binary Inputs & outputs:
Then choose which o/p u need, and the time delay for the signal must be (0ms)
5- To configure led u have to configure the function u need first as input or output
REB500 (AHMED ELSHERIF )
Then , then choose the relay make new signalchoose from the
available binary signals.
Check Zone setting must be less than Bus zone settings or equal to it. As both must be activated
to pickup the diff.
U have to adjust (Diff curr alarm) behavior for both BZ & CZ. “ what it will do”. And u have also
adjust the behavior of the relay when isolator position disturbed as following:
REB500 (AHMED ELSHERIF )