The 10Gbps MediaProbe is a modular system implemented in a MicroTCA form- factor, with tailor-made algorithms that use FPGAs to enable full control and predictability for lossless monitoring of 10Gbps links at wirespeed.
Monitoring 10Gbps with Polystar’s MediaProbe
Full 10Gbps payload support. 6.4ns resolution timestamping.
Modularity Incoming payload measurements
Each 1U chassis can hold up to 12 cards. Up to four ◦◦Current of these can be 10Gbps receiver cards, one fibre ◦◦Peak each. Remaining slots can be used for output port cards, one connection each. Known limitations ◦◦Only Ethernet II is supported Monitored network connections ◦◦Only IPv4 is supported ◦◦ 10GBASE-SR/LR/LRM/ER, using SFP+ modules ◦◦ Direct Attach Power AC 110V to 240V with frequency 47-63Hz. Line interface DC -36V to -75V. ◦◦LC connector Single or redundant. ◦◦Multimode: 840 - 860 nm, max 300m link length (OM3 fibre) Power consumption ◦◦Singlemode: 1260 - 1600 nm, max 10km link length 140 W – 250 W (depending on configuration)
Supported tags/labels Physical Dimensions (w *h*d)
◦◦ 1 VLAN layer 450 mm (19'') x 44 mm (1U) x 600 mm. ◦◦ 4 MPLS layers Weight Load sharing supported for 12 kg ◦◦GTP TEID Operating temperature ◦◦Source and destination IP address 0° to 50° C. Loadshare GTP groups Relative Humidity ◦◦GTP-U 5 to 95 percent, non-condensing. ◦◦GTP-C ◦◦GTP' WEEE and RoHS compliant.