You are on page 1of 15

WIND ENERGY

Wind Energ. 2012; 15:83–97


Published online 14 April 2011 in Wiley Online Library (wileyonlinelibrary.com). DOI: 10.1002/we.470

SPECIAL ISSUE PAPER

Materials of large wind turbine blades: recent results


in testing and modeling
L. Mishnaevsky Jr1 , P. Brøndsted1 , Rogier Nijssen2 , D. J. Lekou3 and T. P. Philippidis4
1 Risø National Laboratory for Sustainable Energy, Technical University of Denmark, AFM-228, Frederiksborgvej 399, DK-4000,
Roskilde, Denmark
2 Knowledge Centre WMC, Kluisgat 5, 1771 MV, Wieringerwerf, The Netherlands
3 Centre for Renewable Energy Sources and Saving, 19th km Marathonos Ave., GR-190 09, Pikermi, Greece
4 University of Patras, Department of Mechanical Engineering and Aeronautics, PO Box 1401 GR-26504, Panepistimioupolis
Rio, Greece

ABSTRACT
The reliability of rotor blades is the pre-condition for the development and wide use of large wind turbines. In order
to accurately predict and improve the wind turbine blade behavior, three main aspects of the reliability and strength
of rotor blades were considered: (i) development of methods for the experimental determination of reliable mate-
rial properties used in the design of wind turbine blades and experimental validation of design models, (ii) develop-
ment of predictive models for the life prediction, prediction of residual strength and failure probability of the blades
and (iii) analysis of the effect of the microstructure of wind turbine blade composites on their strength and ways of
microstructural optimization of the materials. By testing reference coupons, the effect of testing parameters (temper-
ature and frequency) on the lifetime of blade composites was investigated, and the input data for advanced design
of wind turbine blades were collected. For assessing the residual strength and stiffness of wind turbine blades sub-
jected to irregular cyclic loads, a shell-based finite element numerical methodology was developed, taking into account
the non-linear response of plies, and experimentally validated. Two methods of structural reliability estimation of the
blade, which take into account the stochastic nature of the anisotropic material properties and loads, were devel-
oped on the basis of the response surface method and the Edgeworth expansion technique, respectively. The effects
of fiber clustering, misalignments, interface properties and other factors on the strength and lifetime of the wind
turbine blade materials were investigated in the micromechanical finite element simulations. The results described
in this paper stem from the Rotor Structure and Materials task of the UPWIND project. Copyright © 2011 John Wiley
& Sons, Ltd.
KEYWORDS
wind turbine blades; composite materials; testing; fatigue damage; reliability; micromechanics

Correspondence
L. Mishnaevsky Jr, Risø National Laboratory for Sustainable Energy, Technical University of Denmark, AFM-228, Frederiksborgvej
399, DK-4000, Roskilde, Denmark.
E-mail: lemi@risoe.dtu.dk

Received 3 June 2010; Revised 18 February 2011; Accepted 20 February 2011

1. INTRODUCTION
For larger wind turbines, the potential power yields scales with the square of the rotor diameter, but the blade mass scales
to the third power of rotor diameter (square-cube law). With the gravity load induced by the dead weight of the blades,
this increase of blade mass can even prevent successful and economical employment of larger wind turbines.1–3 In order
to meet this challenge and allow for the next generation of larger wind turbines, higher demands are placed on materials
and structures. This requires more thorough knowledge of materials and structural response, as well as further development
of reliability estimation methods. Previous projects have emphasized the necessity for improved and detailed fatigue life
modeling for reliable and optimal blade design.4

Copyright © 2011 John Wiley & Sons, Ltd. 83


Materials of large wind turbine blades L. Mishnaevsky Jr et al.

In this paper, the recent results on the structural reliability and mechanical behavior predictions and testing of blade mate-
rials and components are reported. In order to make it possible both to predict the wind turbine blade service properties and
ultimately to improve the blade materials, three main questions should be answered:
 How are the material mechanical properties required for the advanced design of wind turbine rotor blades consistently
collected?
 How is the accuracy in the prediction of the failure and the structural reliability of wind turbine blades on the basis of
the material layer properties improved?
 How do the microstructures of blade materials influence their strength, and can the service properties of the materials
be improved by modifying the microscale structures?
To solve these problems, advanced experimental methods (reference blade component testing, scanning electron
microscopy in situ static and fatigue experiments), theoretical approaches (kinetic strength theory, etc.) and numerical
methods (3D finite elements (FEs)) and micromechanical models) were employed. As a result, material testing proce-
dures were established, a progressive damage prediction tool was developed and probabilistic strength analysis of wind
turbine blades was carried out. The effects of different microstructural parameters and loading conditions on the strength
of the wind blade materials were studied. The detailed state-of-art overview of the materials for wind turbines was given in
Brøndsted et al.1 and the references therein. In this paper, focus is given on the recently developed methods and ideas that
give the possibility to answer the questions above.

2. HOW TO COLLECT MATERIAL PROPERTIES FOR BLADE DESIGN


In the process of blade design, various input parameters are required for reliable design. As design tools become more
sophisticated, the number of required material characteristics increases. The results from the experimental program
described in this part can be used by manufacturers and designers as reference data.
An important new concept in blade design is to use not only data collected from flat, uniaxial coupons, but from realistic
structural details. This concept was developed in the subcomponent tasks of the UPWIND project, through testing and
modeling of I-beams.
The main aim, however, of the static and fatigue experiments on coupons and subcomponents was to facilitate the
development and validation of models described in the following sections. In addition, test methods were developed, and
existing methods were compared in terms of numeric value of the results. Effects of temperature and testing frequency on
the strength degradation and life time of blade materials were studied.

2.1. Testing methods

A large part of the test program described here, which is reported from the UPWIND program (subtask Rotor Structures
and Materials), is based on the use of a reference coupon. This means that based on general consensus among the project
partners, a typical laminate representative for the rotor blade industry was chosen as the project reference. Subsequently,
a preliminary test program of (slightly) different specimen geometries was conducted to find an optimal combination of
planform and tab configuration that leads to acceptable results in all required tests methods.5 Finally, test methods, notably
the frequencies used in the fatigue tests, were fixed to a large extent.
The advantages of this reference specimen lie in the consistency of methods (e.g. performance at different R-values can
be compared in a straightforward manner, without the need to account for severe geometry differences). Disadvantages are
that in order to obtain the highest values for certain material characteristics (compression and shear), dedicated geometries
are still necessary and that the rectangular geometry selected is prone to failure in the tabbed area.
Details on the reference specimen and material and recent results are documented in e.g. Nijssen et al.6 The reference
specimen geometry, fatigue behavior in the form of a constant life diagram (CLD) and fatigue test setup are illustrated in
Figure 1.
Apart from the reference coupons, scores of other test geometries were used. Mechanical tests were carried out on ser-
vohydraulic test frames of various calibers and by using various dedicated load fixtures; results are discussed e.g. in van
Leeuwen et al.7 and briefly in the next section.

2.2. Results of fatigue tests

Approximately 250 static and fatigue tests were performed on the reference specimen at ambient conditions and various
R-values to describe the specimen fatigue life behavior in considerable detail (see the CLD in Figure 2). Different fatigue
models were fitted to the CA fatigue dataset to evaluate performance of these models statistically (see Figure 2).8,9

Wind Energ. 2012; 15:83–97 © 2011 John Wiley & Sons, Ltd.
84
DOI: 10.1002/we
L. Mishnaevsky Jr et al. Materials of large wind turbine blades

500

Amplitude of cyclic stress [MPa]


450 1000
55 400 10000

350 100000

300 1000000
20 250 10000000

200
130 150
100
50
0
-600 -400 -200 0 200 400 600 800 1000
20
Mean cyclic stress [MPa]

Figure 1. Reference coupon geometry, CLD and test configuration. The legend refers to the constant life lines, describing number
of cycles to failure.
500

Multislope
Piecewise lin.
400
Stress Amplitude [MPa]

Test data
10
10
10
300

10
10
200
100
0

-500 0 500 1000


Stress Mean [MPa]

Figure 2. Fit of piecewise continuous (dashed) and continuous (solid line) CLD models to constant amplitude (CA) data (dots indicate
experimental data).

2.2.1. Temperature and frequency.


The effect of temperature and frequency on fatigue life was investigated experimentally on the reference material. Tests
were performed at reference and increased frequencies and at low (40ı C), room (approximately 25ı C) and high (60ı C)
temperatures. Ambient and surface temperatures were measured during these tests. For tension fatigue, the test frequency
was increased from reference frequencies of 2 and 6 Hz at load levels corresponding to approximately 1000 and 106 cycles,
respectively, to 24 Hz for both load levels. This leads to lower lifetimes at ambient temperature, but no detrimental effect
of this frequency increase is seen when testing at low temperatures. In both cases, an increase in temperature difference
between the surface and the environment was observed in the high-frequency tests, but the temperature rise was, in most
cases, less than 10ı C, maximum 15ı C.
A temperature difference between the specimen surface temperature and the room temperature, which was limited to
the above-mentioned 10–15ı C, results in significantly deteriorated fatigue performance, both in the tension–tension (see
Raijmaekers et al.10 ) and tension–compression fatigue. The observation that this decreased performance did not occur at
low temperatures, albeit with similar surface temperature increase, gives rise to the hypothesis of a threshold tempera-
ture, potentially related to the glass transition temperature, above which the fatigue performance of the reference laminate
decreases significantly. Sufficiently below this threshold, the effect of testing temperature is negligible.

2.2.2. Adhesive testing.


In order to determine shear strength properties of an epoxy structural adhesive [Hexion BPR 135 (Hexion, Columbus,
OH, USA)] representative for manufacturing composite wind turbine blades, a series of experiments was conducted, partly
within the framework of the UPWIND project. The objective of the research included a comparison of shear test methods,
viz. bonded tubes in torsion, full adhesive tubes in torsion, V-notched rail shear, Iosipescu and strap joints. Shear strength
results of adhesives depend strongly on test methods. Employing a bonded tube in torsion gives the highest average shear

Wind Energ. 2012; 15:83–97 © 2011 John Wiley & Sons, Ltd.
85
DOI: 10.1002/we
Materials of large wind turbine blades L. Mishnaevsky Jr et al.

strength (>40 MPa), and this geometry allows for investigation of thickness effects and bi-axial loading. Other methods
give lower results, but e.g. the V-notched rail shear method yields similar values (approximately 10% lower than the bonded
tube) and is less labor intensive, since multiple specimens can be manufactured from a single flat panel, whereas the mold-
ing of a single composite tube as the adherent for the tube bonding paste tests requires significantly more effort. A method
that allows investigation of thickness effects is the strap joint, but the shear strengths measured with this method were the
lowest of all investigated methods.
The bonded tubes were used in an evaluation of the effect of the bondline thickness on the shear strength, where, within
the range of bondline thicknesses investigated (0.5 to 10 mm), no significant effect was observed.
Shear strength values obtained for bonding paste resin (double strap joint, bonded tubes, full adhesive tube and adhesive
using notched specimens) and fiber-reinforced plastic (FRP; the UPWIND glass/epoxy reference material) are shown in
Figure 3.

2.2.3. Subcomponents.
The subcomponent concept developed in the UPWIND project is aimed at bridging the gap between coupon tests and
full-scale testing. This is a new approach in wind turbine blade engineering. The main objective of the subcomponent pro-
gram was to develop a cost-effective test representative of blade structural detail(s). Such a subcomponent can be used for
various purposes, such as the evaluation of critical structural details, material tests, modeling and validation, investigating
influence of manufacturing methods, testing of repair methods and improvement of full-scale blade tests by prior assess-
ment of critical structural details. To limit the scope of evaluating this concept, this project focuses on the assessment of
bondline behavior in a load carrying spar. Two types of prismatic I-beams were manufactured and distributed over various
laboratories. Test methods were developed and executed by various partners, who investigate symmetric three-point and
four-point bending as well as cantilever beam bending. In parallel, advanced simulations of the static and fatigue beam
tests were performed to predict the beam behavior,11,12 using as input the material properties, including the adhesive prop-
erties, as determined within the previously described testing programs. An example of the comparison of a static test with
numerical simulation results is shown in Figure 4. Some results on three-point bending fatigue correlating with the adhesive
fatigue are shown in Nijssen et al.13 and Figure 5. This figure shows the fatigue curves of beams in three-point bending
(the red and green lines). These curves are slightly different because of the difference in geometry of the bondline between
the beam web and flanges. Since the beam fatigue behavior was expected to depend significantly on the adhesive shear
performance, V-notched rail shear tests were performed on flat bonding paste specimens in fatigue. These results are shown
as black dots in the figure. Slightly different beams were tested in Sayer et al.14 and related projects. Ample comparison
of measurements taken during static beam testing with numerical results demonstrated the necessity of detailed input data

Figure 3. Summary of shear test results and test setup for bonded tube tests in tension–torsion frame at Knowledge Centre WMC.

Wind Energ. 2012; 15:83–97 © 2011 John Wiley & Sons, Ltd.
86
DOI: 10.1002/we
L. Mishnaevsky Jr et al. Materials of large wind turbine blades

120
TEST - WMC
MARC - 2D - NoCohesive
100
MARC - 2D - Cohesive

80

Force (KN)
60

40

20

-
0.0 3.0 6.0 9.0 12.0 15.0 18.0 21.0 24.0
Displacement S01 (mm)

Figure 4. FE analysis of beam in symmetric three-point bending.

1.2
1

0.8

0.6

0.4
S=|σmax| [MPa] , normalised with static strength
Symmetric beam (S78)
Asymmetric beam (S79)
Bonding paste
regr. Symmetric beam (S78) (log N=-15.33·log S+0.5)
regr. Asymmetric beam (S79) (log N=-15.81·log S+0.1)
regr. Bonding paste (log N=-12.43·log S+0.1)
0.2
0 1 2 3 4 5 6 7 8
10 10 10 10 N 10 10 10 10 10

Figure 5. Normalized S –N diagram of bonding paste (shear) and I-beams (three-point bending); blue arrows refer to load introduction/
direction. The black arrows associate the left photo with the bonding paste data and the right photo with the beam data.

(strengths and stiffnesses of constituent materials). Failure predictions in static tests were made and in some cases could
predict strength and failure mode.

3. HOW TO PREDICT THE STRENGTH AND FAILURE OF WIND


TURBINE BLADES
In this task, the concepts and methods for exact and reliable life prediction, residual strength and stiffness prediction, as
well as estimation of failure probability for the structural reliability assessment of wind turbine rotor blades, are developed.

3.1. Damage tolerant design concept

Nowadays, FRP rotor blades are designed according to regulations based on the very first principles of composite mechan-
ics, in which ply failure of a multilayer element in an FE model is not followed by property degradation, and thus,

Wind Energ. 2012; 15:83–97 © 2011 John Wiley & Sons, Ltd.
87
DOI: 10.1002/we
Materials of large wind turbine blades L. Mishnaevsky Jr et al.

investigation of post first ply failure load bearing capability is not implemented. Furthermore, material constitutive equa-
tions are considered linear, although it is common knowledge that in-plane shear and transverse compressive response of
a unidirectional (UD) layer is from moderately to highly non-linear.16 No advantage is taken this way of damage tolerant
features of composite materials, and all design-related decisions refer to ‘safe life’ principles, i.e. no account is taken for
progressive damage development. This is due among other reasons to the lack of generally applicable damage assessment
schemes and suitable as well as reliable non destructive inspection (NDI) techniques. It also reflects to formulation weak-
nesses of most commercial FE shell elements, which do not possess possibilities for fatigue life prediction or estimation
of residual strength and stiffness. These shortcomings of state-of-the-art numerical tools and existing formulations of com-
posite mechanics result in uncertainty levels that imply high values of partial safety factors, hence rotor blades of increased
weight and cost.
Here, reliable methods to assess residual strength, stiffness, load bearing capacity and mechanical response of the rotor
blade after a number of operating years are developed on the basis of formulating a shell-based FE numerical methodology
suitable for the analysis of irregular cyclic loads. Development of such a tool for predicting the mechanical response of the
rotor blade consists of several major tasks: (i) non-linear stress analysis of the multilayer structure, (ii) failure prediction
of the building layer under static or cyclic loads by giving the option of using a number of different new generation failure
criteria not available in commercial codes, (iii) modeling of both progressive property degradation due to fatigue and sud-
den property change due to failure and finally, (iv) formulation of an ‘overall structural failure’ condition, resulting in the
prediction of remaining life, residual strength and stiffness.
The concept of modeling damage development in multilayer laminates under quasi-static loads has been discussed the-
oretically to some extent (see Antoniou et al.15–17 for recent account). However, very limited research results are available
from modeling damage accumulation as a result of cycling. One of the reasons for the lack of work in this field, besides
the considerable inherent difficulties associated with the multitude of failure mechanisms and their interaction, is the huge
effort required to create comprehensive material property databases with test results from static, cyclic and residual strength
experiments under multi-axial loading conditions. The simulation procedure that was implemented in FE shell code took
advantage of the O PTI DAT database.4
A continuum damage mechanics method was implemented in a ply-to-laminate life prediction scheme for composite
laminates under cyclic CA or variable amplitude (VA) loading. According to theoretical foundations of distributed
damage,18–21 instead of considering the geometric description of a type of defect induced by local failure, a set of appropri-
ate stiffness degradation rules is applied, resulting in a modified stiffness tensor, i.e. an equivalent homogeneous continuum
description, such that either the resulting strain field or strain energy density under the same load is similar to that of the
damaged medium. Thus, instead of adapting the mesh of an FE model and introducing new boundaries for progressing
cracks or other defect types, the stiffness tensors at elements where damage onset was predicted are suitably modified.
This effective medium description also requires, besides sudden stiffness degradation due to failure onset, progres-
sive strength and stiffness degradation expressed as a function of load cycles, n. Hence, residual strength and stiff-
ness after cycling become of importance for this approach of progressive damage mechanics and certainly require a
great experimental effort, besides efficient modeling, to cover the various loading conditions, e.g. tension–tension (T-T),
tension–compression (T-C), etc., at various stress ratio values and material principal directions.
To assess conditions for incipient failure in a specific mode, compatible with certain defect type and respective stiffness
degradation strategy, appropriate failure criteria considering separately the various failure modes22–25 were implemented
in the numerical procedure.
The material model consists also of the detailed description of fatigue strength in each principal material direction and
in-plane shear, for the basic building ply, for several R values to ease the implementation of CLD formulations.
For accuracy, a detailed load step-by-step simulation of each cycle is foreseen in the realization of the algorithm, although
this could be extremely time-consuming, especially when the routine is implemented in FE formulations. Alternatively, cal-
culations are performed in steps for a complete cycle and then after a block, n, of cycles again, a detailed complete cycle
and so forth. The size of cycle jump is defined by the user.
Non-linear response of the UD ply especially under in-plane shear and normal loading transversely to the fibers is
also taken into account, introducing appropriate models derived by fitting experimental data. In the numerical analysis,
non-linearity is modeled by implementing an incremental stress–strain constitutive law.16
An extensive comparison of life prediction numerical results with experimental data from CA or VA tensile cyclic test-
ing of a [˙45]S plate and loading at various R-ratios of a multidirectional (MD) Glass/Epoxy laminate [(˙45/0)4 /˙45]T
has been performed. As an example, in Figure 6, the numerically predicted S –N curve for the MD laminate under CA at
R D 0:1 along with experimental data is presented, whereas in Figure 7, damage patterns in the outer three layers after
700,000 cycles are shown. Coupons cut from the MD plate were loaded either on-axis, where fiber dominated failure modes
were observed, or off-axis at various directions where matrix damage had also significant contribution in the observed fail-
ure. Predictions of tensile residual strength after cyclic loading of [˙45]S coupons were also compared with test results
(see Figure 8). In all cases, the agreement of numerical predictions and test results was very good. More details on the
mechanics formulations, numerical procedures and results can be found in Philippidis and Eliopoulos.26

Wind Energ. 2012; 15:83–97 © 2011 John Wiley & Sons, Ltd.
88
DOI: 10.1002/we
L. Mishnaevsky Jr et al. Materials of large wind turbine blades

500

450 MD [0] R=0.1

FADAS
400

350

σmax [MPa]
300

250

200

150

100
1.E+02 1.E+03 1.E+04 1E+05 1.E+06 1.E+07 1.E+08
N

Figure 6. Comparison of the fatigue damage simulator predictions and experimental data; MD Gl/Ep under R D 0:1.

+45 -45

n=700000

IFFC IFFB IFFA FFC FFT

Figure 7. Damage modes according to Puck failure criteria of a [(˙45/0)4 /˙45] Gl/Ep MD coupon, at a stress level of max D 193
(MPa), R D 0:1.

120

100
σmax [MPa]

80

60 RS
FADAS
Broutman-Sahu
S-N curve
STT

40
1.E+02 1.E+03 1.E+04 1.E+05 1.E+06
N

Figure 8. Fatigue damage simulator predictions versus residual strength test data after R D 0:1 cyclic loading; [˙45]S Gl/Ep.

Wind Energ. 2012; 15:83–97 © 2011 John Wiley & Sons, Ltd.
89
DOI: 10.1002/we
Materials of large wind turbine blades L. Mishnaevsky Jr et al.

3.2. Probabilistic modeling of wind turbine blades

Quantification and assessment of the structural reliability level of the wind turbine blade with respect to its strength, stiff-
ness and elastic stability should be performed in probabilistic terms by relying both on load uncertainty quantification as
well as on material, because of the use of composite materials, exhibiting great inherent variability of mechanical proper-
ties. Substantial efforts have been directed toward load uncertainty investigation,27–32 with results already incorporated in
the relevant design standard IEC 61400-1.33
The structural reliability analysis of the wind turbine blade was addressed up to now (e.g. Braam,34 Ronold and Larsen35
and Veldkamp36 ), limiting the analysis to the failure of the root section of the blade, taking into account only the developed
stress in the axial direction due to bending in the flap direction and the respective strength of the laminate, disregarding the
multi-axial stress state of the anisotropic composite material.
For permitting the estimation of failure probability on the level where the material properties are certified, i.e. the layer,
two independent methodologies were developed in parallel within the UPWIND project; the first37 enables the connection
with currently employed aero-elastic wind turbine design codes and is based on the Edgeworth expansion methodology
(EDW), whereas the second38 employs the response surface method (RSM) with direct Monte Carlo (MC) simulation and
is combined with an FE shell model. In both methodologies, the stochastic nature of the anisotropic material properties, as
well as the loads, is considered for the reliability estimation of the layer and thereupon extended to the laminate, the blade
section and the overall blade.

3.2.1. Stochastic variables and failure functions.


Common to both developed methodologies is that the probability estimations are developed by performing a ply-by-ply
analysis using the quadratic version of the failure tensor polynomial, Tsai–Hahn.39 Since the numerical models of the rotor
blade consist of a great number of layered elements, each with a stacking sequence composed of numerous plies, it is
considered that each element forms a series system of layers, implying a first ply failure criterion for the element.37 It is
further assumed that the failure modes of the different layers are positively correlated. The same convention applies for the
failure probability of the rotor blade, by considering it as a series system of elements with the failure modes of the elements
presenting positive correlation. Thus, the maximum probability of failure of all the layers in all the elements defines the
probability of failure of the rotor blade.
For the statistical characterization of the variability of the material parameters, experimental databases are used, cov-
ering information not only for the strength properties of the orthotropic media but also for the relevant elastic properties,
such as that in Philippidis et al.40
Statistical analysis is also necessary to model the time series for the stress resultants at various sections of the
blade derived from aero-elastic simulations by the extreme maximum value distributions.38 IEC 61400-133 describes the
procedure for the estimation of the extreme distribution using extrapolation.

3.2.2. PRE-THIN, THIN and POST-THIN.


The tool has been divided into three modules (PRE-THIN, THIN and POST-THIN) in order to facilitate the use of the
available aero-elastic codes, accurately represent the mechanical properties of the full 3D blade in the 1D beam element
used in aero-elastic codes and enable the performance of the necessary detailed strength assessment after stress resultants at
each section have been calculated. PRE-THIN uses material layer properties and information on the lamination sequences
for the calculation of the effective properties of each laminate. The basic processor, THIN, is based on thin wall beam
theory, taking into account the inhomogeneity and elastic anisotropy of the cross-sectional elements, described in detail in
Philippidis et al.41 for the deterministic case and Lekou and Philippidis37 for the probabilistic. THIN estimates for each
section of the blade all sectional properties necessary for input to the aero-elastic codes, e.g. the bending and torsional
stiffness, in statistical terms. The aero-elastic simulation codes provide (for each load case) the internal resultant axial and
shear forces and bending and torsional moments for each section of the blade. Using this as an input, the normal stress
resultants, as well as the shear flows due to torsion and shear forces, are calculated for each ‘homogenized’ element on the
multi-cell section within THIN,41 including hygrothermal effects. These normal and shear stress resultants of each node
on every element of the section are provided as input to the POST-THIN module, where the stress field and reliability of
each layer in the lamination sequence is calculated.
For the probabilistic analysis, the EDW, as described for application with composite material laminates under multi-
axial loading in Lekou and Philippidis,42,43 was verified through crude MC simulations with indicative results presented
in Lekou and Philippidis.37 An example output of the developed tool is shown in Figure 9, where the results of the EDW
methodology are compared with MC simulations for the case when only the material layer properties (strength and elas-
ticity) are assumed to be stochastic (denoted as EDW_mat and MC_mat, respectively) and for the case where also the
variability of the loading is taken into account (marked EDW_mat&load and MC_mat&load, respectively). It should be
noted that the results presented are derived for a load case having an average value especially designed to cover both high

Wind Energ. 2012; 15:83–97 © 2011 John Wiley & Sons, Ltd.
90
DOI: 10.1002/we
L. Mishnaevsky Jr et al. Materials of large wind turbine blades

1.0 104
169
57
0.9 105
176 56
0.8
Probability of failure
0.7
0.6
0.5 EDW_mat&load
0.4 136 168 161
EDW_mat
0.3 MC_mat&load 25
137 167 24
0.2 MC_mat

0.1
0.0
0 30 60 90 120 150 180
Element number 2
1

Figure 9. Indicative output of the probability of failure using PRE-THIN, THIN and POST-THIN (left) and element numbering on the
blade section (right).

and low probabilities of failure around the section, so as to check the validity of the method throughout the design space.
Moreover, the load variance assumed for the present stochastic analysis is considered to be high, making the presented case
a conservative one. Taking into account the fact that the computational cost of the EDW methodology is comparable to
that of a pure deterministic analysis, the applicability of the method within the design process, requiring a large number of
loops and load cases before reaching the final structure, is evident. Regarding the sectional properties estimation, results of
the EDW method are within 1% for both the average values and the standard deviations outcome of the MC simulation.

3.2.3. Response Surface Method.


The RSM was used in Bacharoudis and Philippidis38 to estimate the reliability of the wind turbine blade using a 3D
detailed FE model. To this end, instead of repeatedly solving the FE model, following an MC simulation approach, approx-
imation (regression) models were formed through the use of RSM. Stress analysis is performed with a refined shell element
formulation of a commercial FE code, ANSYS (ANSYS, Inc., Canonsburg, PA). Because of computational complexity and
code limitations, only part of the reliability computation, specifically part of the ‘Design of Experiment’, is accomplished
with the commercial code, whereas the remaining computational tasks were developed and implemented in external user
routines in FORTRAN. Special care was taken in defining the stochastic character of the concentrated loads applied on a
3D shell element FE model starting from load series of sectional stress resultants from aero-elastic beam simulations.
The RSM involves central composite design composed of three different designs for the design of experiment (DoE):
second order polynomial models with or without cross terms, regression analysis and testing of model accuracy. DoE
provides the appropriate sample points that are used for a limited number of FE simulation experiments (e.g. for seven
input variables, 79 FE analyses are required). These results are then fed into a regression analysis to estimate the unknown
coefficients of the approximation models. Contrary to the common application of RSM, instead of approximating the limit
state function, in this case, the RSM is used for the derivation of approximate models for the in-plane strains developed at
any ply of any element in the blade, thus avoiding time-consuming FE solution repetitions.
The validity of the method, which could be used in the future as a design tool, was proved through comparison of failure
probability predictions with typical MC simulation results, focusing in the limit condition in the design space. In Figure 10,
a typical output representation of the application is shown.
Summarizing the results presented in Section 3.2, it is emphasized that both developed methods enable the reliability
estimation of the wind turbine blade on the layer level in every location of the blade taking into account the variability of
the anisotropic material properties, as well as that of the multi-axial loading acting on the blade. The computational cost
of the EDW methodology developed having as output the probability of failure on the layer level is comparable to that of
deterministic analysis methods. Although the statistical results for the elasticity sectional properties and the layer stresses
provided by the EDW methodology are in accordance with MC simulation results,37 if the variance of the stochastic vari-
ables is quite high, the EDW underestimates the reliability of the structure. The EDW method as applied enables direct
link with aeroelastic computational tools used for wind turbine simulations. The work conducted on the RSM methodology
presented showed that use of 3D FE models, with an accurate representation of the structure, using load data as delivered
by aero-elastic computational tools for wind turbines involves a number of assumptions, introducing uncertainties in the

Wind Energ. 2012; 15:83–97 © 2011 John Wiley & Sons, Ltd.
91
DOI: 10.1002/we
Materials of large wind turbine blades L. Mishnaevsky Jr et al.

Figure 10. Indicative output of the probability of failure using the RSM.38

final model estimations. Nevertheless, the RSM method results in probability of failure estimates in good agreement with
MC simulation outputs. Further work on direct comparison of the two stochastic analysis methodologies developed in the
frame of UPWIND project is under way.

4. HOW DO THE MICROSTRUCTURES OF WIND TURBINE BLADE


MATERIALS INFLUENCE THEIR STRENGTH?
The strength and reliability of wind turbine blades depend on the properties, mechanical behavior and strengths of the
material components (glass or carbon fibers and polymer matrix) and the interaction between them under loading. In
this task, the micromechanisms of strength, degradation and failure of the rotor blade materials are studied experimen-
tally, theoretically and numerically. The answers on the following questions were sought: Which physical mechanisms
control the strength and failure of the wind turbine blade materials? Which parameters of microstructures of the materi-
als influence the strength of wind turbine blade materials? How can the service properties of the materials be improved
by modifying the microscale structures? The sensitivity of the strength of the composites toward different microstructure
parameters and loading conditions has been studied with respect to static and cyclic strengths, and the most significant ones
are identified.

4.1. Effect of microstructural parameters on the strength and lifetime of composites

4.1.1. Effect of fiber orientation on damage mechanisms under static and cyclic loading:
scanning electron microscopy in situ experiments.
In order to clarify the effect of the loading direction on the wind blade strength, scanning electron microscopy in
situ experimental investigations of damage growth in glass FRPs under three-point bending, tensile, compressive and
(tension–tension) cyclic loadings under different angles between the loading and fibers have been carried out. The detailed
conditions of the experiments are described elsewhere.44 It was observed in the three-point bending experiments that the
peak strengths, elastic strengths and elastic modulus of the composites decrease when increasing the angles between load
vector and fibers almost linearly. Under compression, the peak strengths, elastic strengths and elastic modulus of the com-
posites decrease when increasing the angles of fibers at first and slightly increase thereafter. Under tension–tension cyclic
loading, it was observed that the cracks develop most often along the interface between main fibers and matrix.44

4.1.2. Effect of variability of fiber strengths, viscosity of matrix and competition of damage
modes: 3D micromechanical FE analysis.
In order to study the effect of microscale parameters of wind turbine blade composites on their strength, a special soft-
ware for the automatic generation of 3D computational micromechanical models of the composites was developed45 and
used in the numerical experiments. Figure 11 shows the micrograph of a composite and the 3D FE model as well as the
crack growth scheme. The effects of the statistical variability of fiber strengths, viscosity of the polymer matrix and the
interaction between the damage processes in matrix, fibers and interface are investigated numerically, by testing different
multifiber unit cell models of the composites.46,47 It was demonstrated in the simulations that fibers with constant strengths
ensure the higher strength of a composite at the pre-critical load, whereas the fibers with randomly distributed strengths
lead to the higher strength of the composite at post-critical loads. In the case of randomly distributed fiber strengths, the
damage growth in fibers seems to be almost independent from the crack length in matrix, whereas the influence of matrix

Wind Energ. 2012; 15:83–97 © 2011 John Wiley & Sons, Ltd.
92
DOI: 10.1002/we
L. Mishnaevsky Jr et al. Materials of large wind turbine blades

Figure 11. Micrograph of the composite, 3D FE micromechanical model, crack growth between the fibers and fiber bridging over the
matrix crack.45,46

cracks on the beginning of fiber cracking is clearly seen for the case of the constant fiber strength. Competition between
the matrix cracking and interface debonding was observed in the simulations: in the areas with intensive interface cracking,
both fiber fracture and matrix cracking are delayed. Reversely, in the area, where a long matrix crack is formed, the fiber
cracking does not lead to the interface damage.45,48

4.1.3. Fiber misalignment and clustering and their effect on the compressive and fatigue
strength of rotor blade materials.
In compression, the dominating failure mode of carbon fiber reinforced polymer composites is a so-called kink band
formation. In order to study the compressive strength of composites, statistical computational model was developed on the
basis of the MC method and the Budiansky–Fleck fiber kinking condition49 (see the schema of the multifiber unit cell with
random misalignments in Figure 12, left). The effects of fiber misalignment variability, fiber clustering, load sharing rules
on the damage in composite are studied numerically. It is demonstrated that the clustering of fibers has a negative effect
on the damage resistance of a composite (Figure 12, right). Further, the static compressive loading model is generalized
for the case of cyclic compressive loading, with and without microdegradation of the matrix and with and without random
variations of loading.49 It was observed that the random variations of loading shorten the lifetime of the composite: the
larger the variability of applied load, the shorter the lifetime. The model was further generalized to include the irregular
fiber waviness and the interface defects. Considering the cases of small and large interface defects with different density,
it was observed that the small interface microcracks do not lead to the sufficient reduction of compressive strength even at
unrealistically high microcrack density. In contrast, large interface defects have a strong effect on the compressive strength
of the composite.

4.1.3.1. Mesoscale ply stiffness degradation model. In order to provide the link between microscale struc-
ture damage analysis and macroscale wind turbine blade reliability studies and design, a ply level stiffness degradation
model has been developed.50 A theoretical solution linking the stiffness of the damaged UD composite with average open-
ing displacement of fiber breaks and its sliding displacement was obtained. Using this solution, it was demonstrated that
sliding displacement of a crack in a cracked layer of a laminate does not affect the longitudinal stiffness, and the effect of
the crack opening displacement of fiber breaks on the transverse and shear modulus is negligible as well. The significant
effect of the debond length on the stiffness reduction was observed.

D1=0.24 D1=0.24
D2=0.37 D2=0.43

Figure 12. Left: Schema of statistical models of fibers with randomly distributed misalignments. Right: Comparison of damage
(density of kinked fibers, D) for random and clustered fiber distributions (top view).49

Wind Energ. 2012; 15:83–97 © 2011 John Wiley & Sons, Ltd.
93
DOI: 10.1002/we
Materials of large wind turbine blades L. Mishnaevsky Jr et al.

Figure 13. Schema of the model of the moisture-induced degradation and the snapshots of the of moisture diffusion profiles (from
Abhilash et al.51 ).

4.2. Combined microstructure and loading conditions effect: computational analysis

4.2.1. Moisture-induced degradation of composites.


Moisture-induced interface damage evolution and debonding for different fiber realizations are studied numerically using
the FE method and micromechanical modeling.51 The interplay of the two time scales (diffusion time scale and the time
scale of the applied load) is considered by applying a strain rate comparable to the moisture diffusion rate. In the simu-
lations, it was observed that moisture-induced degradation of the interfacial properties brought in substantial increase in
the interface damage. It was observed that the unit cell model of composite subjected to loading after being saturated with
moisture has shown a decrease in the nominal stress achieved and the initial tangent modulus that is dependent on the fiber
distribution in the composite (Figure 13).

4.2.2. Loading frequency effect on fatigue lifetime.


A new approach to the modeling of material degradation under cyclic loading has been developed on the basis of
the kinetic theory of strength.52 In the model, it was assumed that the stress (and not stress increase) is responsible for the
damage growth in the materials under cyclic loading (what is characteristic for the viscous materials). With the use of the
kinetic theory, it has been shown that the damage growth per cycle decreases (and the lifetime decreases) when increasing
the loading frequency under such conditions. If, however, the damage is caused by stress increase (rate dependent damage),
the inverse effect will be observed: in this case, the lifetime should increase when increasing the loading frequency.
Summarizing the research described in this section, we can state that the strength of fiber/matrix interface, fiber misalign-
ment and variability of fiber properties, as well as clustering of fibers, are important parameters influencing the strength of
the blade materials. Controlling these parameters, one can improve the strength and lifetime of blade materials.

5. CONCLUSIONS
The work performed regarded material and modeling related issues of the wind turbine blade, covering experimental and
theoretical (numerical) investigations from the material microscale to the overall behavior of the structure. It should be
noted that the approaches and solutions developed in this work are also applicable to other composite structures.
A comprehensive program of experimental testing of different composites for wind turbine blades has been realized,
which includes the investigations of loading, temperature, frequency and orientation effect on the strength and lifetime of
composites including statistical analysis of CLD for the unidirectional glass/epoxy reference laminate.
In the collection of experimental data, the philosophy of using a ‘reference specimen’ was used to enable the construc-
tion of a consistent database, containing data that can be used e.g. in assessment of fatigue models at various loading types.
To obtain the best possible material characteristics, however, it is necessary to perform dedicated tests on optimal specimen
geometries.
The temperature and frequency investigation led to the hypothesis that there exists a threshold temperature above which
the fatigue performance of the UPWIND reference laminate decreases significantly. The value of this threshold temperature
and a potential relation to e.g. the glass transition temperature is yet to be determined.
Shear strength of adhesives, which is required for the detailed analysis of the wind turbine blade, depends strongly on
test methods. This implies that some test methods might be more sensitive to multi-axial stress states, reducing their appar-
ent shear strength values. Full-field strain measurement techniques are recommended to further quantify this. Employing

Wind Energ. 2012; 15:83–97 © 2011 John Wiley & Sons, Ltd.
94
DOI: 10.1002/we
L. Mishnaevsky Jr et al. Materials of large wind turbine blades

a bonded tube in torsion gives the highest average shear strength, and this geometry allows for investigation of multi-axial
and thickness effects. Other methods give lower results, but e.g. the V-notched rail shear method yields similar values
(approximately 10% lower than the tubes) and is less labor intensive.
An important new concept in blade design is to use data collected not only from flat, uni-axial coupons but from realistic
structural details. This concept was developed in the subcomponent tasks of the UPWIND project, through testing and
modeling of I-beams.
The development of the subcomponent concept from the UPWIND project shows promising results in terms of test
improvement including measurement techniques and validation of advanced structural models. Ample comparison of
measurements taken during static beam testing with numerical results demonstrated the necessity of detailed input data
(strengths and stiffnesses of constituent materials). Failure predictions in static tests were made and in some cases could
predict strength and failure mode.
An anisotropic non-linear constitutive model implementing progressive damage concepts to predict the residual
strength/stiffness and life of composite laminates subjected to static or cyclic multi-axial loading was formulated. In-plane
mechanical properties of the material were fully characterized at the ply level whereas static or fatigue strength of any MD
stacking sequence was predicted. The computational implementation of the theoretical model in an FE thick-shell formula-
tion routine, simulating fatigue damage progression in a composite laminate by means of a ply-to-laminate approach, was
achieved as well. The in-plane residual strength of the UD layer was used as fatigue damage metric. Strength and stiffness
degradation was modeled using simple and cost-effective schemes, whereas the failure criteria of Puck along with post
failure behavior of the material were implemented. The model was set up for a Glass/Epoxy material typical of the wind
turbine rotor blade industry and has been verified through a series of CA and VA fatigue tests on different lay-ups, sim-
ulating a variety of plane stress combinations and failure modes. Including progressive damage modeling in blade design
procedures could enhance the exploitation of material potential and increase confidence in structural design, especially
with respect to remaining strength and stiffness of a rotor blade during its operational life.
Two methodologies for the structural reliability assessment of the wind turbine blade were developed within the
UPWIND project, where the probability of failure is estimated on the layer level, taking into consideration the variability of
applied loads, in addition to the variability of the material strength and elasticity properties. One,37 based on the Edgeworth
expansion method, allows for direct connection with currently employed aero-elastic wind turbine design codes, while
being based on thin wall beam theory, taking into account the inhomogeneity and elastic anisotropy of the cross-sectional
elements sectional analysis. The other,38 employing the RSM, is combined with an FE shell model, more accurately re-
presenting the blade structure. Although each method presents its own limitations, extensively discussed within Lekou and
Philippidis37 and Bacharoudis and Philippidis,38 respectively, the advantages attained by enabling the structural reliability
evaluation of the wind turbine blade on the layer level at an early stage in the design process are apparent.
In the computational studies of the effects of microstructures of rotor blade materials on their strength and damage
resistance, it was observed that a weaker fiber/matrix interface prevents the development of matrix cracks in the compos-
ites. Further, replacement of fiber reinforcements by clusters or bundles of thinner fibers can ensure higher strength of the
composite. The effect of the loading frequency on the lifetime of materials depends strongly on the damage mechanisms:
whether it is rate dependent or creep-related damage. Generally, the microscale analysis and microstructure optimization
represent an important source of the optimization of the wind blade materials.
Summarizing the research and results described above, one can state that new approaches and methodologies of test-
ing and assessing wind turbine blade materials were developed, the prediction of lifetime, residual strength and structural
reliability of rotor blades were enabled and improved and the effects of material properties and loading conditions on the
strength and lifetime of blade materials were analysed.

ACKNOWLEDGEMENTS

Research presented was partly funded by the European Commission within the 6th Framework Programme, under research
project ‘Integrated Wind Turbine Design (UPWIND)’, contract number SES6-019945.

REFERENCES
1. Brøndsted P, Lilholt H, Lystrup A. Composite materials for wind power turbine blades. Annual Review of Materials
Research 2005; 35: 505–538.
2. Brøndsted P, Holmes JW, Sørensen BF. Wind rotor blade materials technology. European Sustainable Energy Review
2008: 36–41.
3. Hayman B, Wedel-Heinen J, Brøndsted P. Materials challenges in present and future wind energy. MRS Bulletin 2008;
33: 343–353.

Wind Energ. 2012; 15:83–97 © 2011 John Wiley & Sons, Ltd.
95
DOI: 10.1002/we
Materials of large wind turbine blades L. Mishnaevsky Jr et al.

4. OPTIMAT BLADES. Reliable optimal use of materials for wind turbine rotor blades, contract no. ENK6-CT-2001-
00552, 2001–2006. [Online]. Available: http://www.wmc.eu/optimatblades.php. (Accessed January 2011).
5. Nijssen RPL, Stammes E, Westphal T, Lekou D. UpWind preliminary tests—determination of a reference specimen
for material research. WCM-2007-35. Technical Report UPWIND Project. [Online]. Available: http://www.upwind.eu/
(Accessed January 2011).
6. Nijssen RPL, Westphal T, Stammes E, Sari J. Strength and fatigue of wind turbine rotor laminates and subcomponents.
Paper no. 1189. Proceedings of AIAA/ASME Wind Energy Symposium, Orlando, FL, 4–7 January 2010.
7. van Leeuwen DA, Nijssen RPL, Stammes E, Westphal T. Comparison of static shear test methodologies; test results
and analysis. Subject No. 2.11. Global Wind Power, Beijing, 2008.
8. Sari J, Nijssen RPL, Westphal T, Stammes E, van Delft DRV. Parameter estimation and comparison for linear and
modified Goodman diagrams. Proceedings of the EWEC, Warsaw, April 2010.
9. Westphal T. Statistical analysis of fatigue data. Presented at the Dutch Wind Workshops, Wieringerwerf, October 2010.
[Online]. Available: http://dww.wmc.eu/ (Accessed January 2011).
10. Raijmaekers S, Westphal T, Stammes E, Nijssen RPL. Effect of temperature and frequency on fatigue life—literature
study and tension fatigue experiments. Proceedings of the EWEC, Marseille, 16-19 March 2009.
11. Philippidis TP, Eliopoulos EN. Failure prediction of the asymmetric I-beam subcomponent under static loading.
Upwind document archive 3-09-WP-0150.
12. Nuin I. Subcomponent simulation results. Distributed via e-mail as KI01_S78_Results_UD.xls.
13. Nijssen RPL, Westphal T, Stammes E. Beam test report. Report no. WMC-2009-32. Upwind document archive
03-09-WP-0134 (and revisions).
14. Sayer F, van Wingerde A, Busmann H-G, Knops M, Windbichler R, Kleiner F, Trusheim M. Development of a new
test methodology for adhesive joints in the wind industry. Proceedings of the EWEC, Warsaw, 2010.
15. Antoniou AE, Kensche C, Philippidis TP. Mechanical behavior of glass/epoxy tubes under combined static loading.
Part I: Experimental. Composites Science and Technology 2009; 69: 2241–2247.
16. Antoniou AE, Kensche C, Philippidis TP. Mechanical behavior of glass/epoxy tubes under combined static loading:
Part II: Validation of FEA progressive damage model. Composites Science and Technology 2009; 69: 2248–2255.
17. Antoniou AE, Van Hemelrijck D, Philippidis TP. Failure prediction for a glass/epoxy cruciform specimen under static
biaxial loading. Composites Science and Technology 2010; 70: 1232–1241.
18. Lee JW, Allen DH, Harris CE. Internal state variable approach for predicting stiffness reductions in fibrous laminated
composites with matrix cracks. Journal of Composite Materials 1989; 23: 1273–1291.
19. Ladeveze P. A damage computational method for composite structures. Computers & Structures 1992; 44: 79–87.
20. Renard J, Favre J-P, Jeggy T. Influence of transverse cracking on ply behavior: introduction of a characteristic damage
variable. Composites Science and Technology 1993; 46: 29–37.
21. Maire JF, Chaboche JL. A new formulation of continuum damage mechanics (CDM) for composite materials.
Aerospace Science and Technology 1997; 4: 247–257.
22. Puck A, Schürmann H. Failure analysis of FPF laminates by means of physically based phenomenological models.
Composites Science and Technology 1998; 58: 1045–1067.
23. Puck A, Schürmann H. Failure analysis of FPF laminates by means of physically based phenomenological models.
Composites Science and Technology 2002; 62: 1633–1662.
24. Puck A, Kopp J, Knops M. Guidelines for the determination of the parameters in Puck’s action plane strength criterion.
Composites Science and Technology 2002; 62: 371–378.
25. Chang FK, Lessard BL. Damage tolerance of laminated composites containing an open hole and subjected to
compressive loadings. Part I—analysis. Journal of Composite Materials 1991; 25: 2–43.
26. Philippidis TP, Eliopoulos EN. A progressive damage mechanics algorithm for life prediction of composite materials
under cyclic complex stress. In Fatigue Life Prediction of Composites and Composite Structures, Vassilopoulos AP
(ed.). Woodhead Publishing Ltd: Cambridge, 2010.
27. Fitzwater LM, Winterstein SR. Predicting design wind turbine loads from limited data: comparing random process and
random peak models. Journal of Solar Energy Engineering 2001; 123: 364–372.
28. Veers PS, Butterfield S. Extreme load estimation for wind turbines: issues and opportunities for improved practice.
AIAA-2001-0044. Proceedings of the ASME Wind Energy Symposium, AIAA/ASME, Reno, NV, 2001.
29. Peeringa JM. Extrapolation of extreme responses of a multi megawatt wind turbine. ECN-C–03-131, Energy research
Centre of the Netherlands, 2003.

Wind Energ. 2012; 15:83–97 © 2011 John Wiley & Sons, Ltd.
96
DOI: 10.1002/we
L. Mishnaevsky Jr et al. Materials of large wind turbine blades

30. Moriarty PJ, Holley WE, Butterfield SP. Extrapolation of extreme and fatigue loads using probabilistic methods.
Technical Report No. NREL / TP-500-34421, National Renewable Energy Laboratory NREL, Golden, CO, 2003.
31. Genz R, Nielsen KB, Madsen PH. An investigation of load extrapolation according to IEC 61400-1 Ed.3., EWEC
2006. [Online]. Available: http://www.ewec2006proceedings.info/allfiles2/595_Ewec2006fullpaper.pdf. (Accessed 20
April 2010).
32. Saranyasoontorn K, Manuel L. Design loads for wind turbines using the environmental contour method. Journal of
Solar Energy Engineering 2006; 128: 554–561.
33. IEC 61400-1:2005. Wind turbines—part 1: design requirements (3rd edn), International Electrotechnical Commission,
2005.
34. Braam H, Christensen CJ, Ronold KO, Thogersen ML. PRODETO, a computer code for probabilistic fatigue design.
In Proceedings of the EWEC 1999: Wind Energy for the Next Millennium, Nice, 1–5 March 1999, Petersen EL, Hjuler
Jensen P, Rave K, Helm P, Ehmann H (eds). James & James Science Publishers: London, 1999.
35. Ronold KO, Larsen GC. Reliability-based design of wind-turbine rotor blades against failure in ultimate loading.
Engineering Structures 2000; 22: 565–574.
36. Veldkamp D. Chances in wind energy: a probabilistic approach to wind turbine fatigue design. PhD Thesis, DUWIND
Delft University Wind Energy Research Institute, 2006.
37. Lekou DJ, Philippidis TP. PRE- and POST-THIN: a tool for the probabilistic design and analysis of composite rotor
blade strength. Wind Energy 2009; 12: 676–691.
38. Bacharoudis KC, Philippidis TP. Structural reliability analysis of a composite rotor blade in ultimate loading. EAWE
3rd Conference: the Science of Making Torque from Wind (TORQUE 2010), FORTH Heraklion, Crete, 28–30 June
2010.
39. Tsai SW, Hahn HT. Introduction to Composite Materials. Technomic Publishing Co.: Westport, CT, 1980.
40. Philippidis TP, Lekou DJ, Baharoudis C. Assessment of failure probability under uni-axial and multi-axial static
and fatigue load. OPTIMAT BLADES Report OB_TG2_R035_rev.000, 2006. [Online]. Available: www.wmc.eu/
public_docs/index.htm (Accessed January 2011).
41. Philippidis TP, Vassilopoulos AP, Katopis KG, Voutsinas SG. THIN/PROBEAM: a software for fatigue design and
analysis of composite rotor blades. Wind Engineering 1996; 20: 349–362.
42. Philippidis TP, Lekou DJ. A probabilistic approach to failure prediction of FRP laminated composites. Mechanics of
Composite Materials and Structures 1998; 5: 371–382.
43. Lekou DJ, Philippidis TP. Mechanical property variability and its effect on failure prediction. Composites Part B:
Engineering 2008; 39: 1247–1256.
44. Zhou HW, Mishnaevsky Jr, L, Brøndsted P, Tan J, Gui L. SEM in situ laboratory investigations on damage growth in
GFRP composite under three-point bending tests. Chinese Science Bulletin 2010; 55: 1199–1208.
45. Mishnaevsky Jr, L, Brøndsted P. Micromechanisms of damage in unidirectional fiber reinforced composites: 3D
computational analysis. Composites Science and Technology 2009; 69: 1036–1044.
46. Mishnaevsky Jr, L. Computational Mesomechanics of Composites. Wiley: New York, NY, 2007.
47. Mishnaevsky Jr, L, Brøndsted P. Micromechanical modeling of damage and fracture of unidirectional fiber reinforced
composites: a review. Computational Materials Science 2009; 44: 1351–1359.
48. Wang HW, Zhou HW, Mishnaevsky Jr, L, Brøndsted P, Wang LN. Single fibre and multifibre unit cell analysis of
strength and cracking of unidirectional composites. Computational Materials Science 2009; 46: 810–820.
49. Mishnaevsky Jr, L, Brøndsted P. Statistical modelling of compression and fatigue damage of unidirectional fiber
reinforced composites. Composites Science and Technology 2009; 69: 477–484.
50. Varna J. Stiffness degradation model. Deliverable D3.2.1b Internal Report, Luleå Tekniska Universitet, 2008.
51. Abhilash AS, Joshi SP, Mukherjee A, Mishnaevsky Jr, L. Micromechanics of diffusion induced damage evolution in
reinforced polymers. Composites Science and Technology 2011; 71: 333–342.
52. Mishnaevsky Jr, L, Brøndsted P. Modeling of fatigue damage evolution on the basis of the kinetic concept of strength.
International Journal of Fracture 2007; 144: 149–158.

Wind Energ. 2012; 15:83–97 © 2011 John Wiley & Sons, Ltd.
97
DOI: 10.1002/we

You might also like