Professional Documents
Culture Documents
Experiment-13
Aim :
To implement this experiment we need Access Point- PT and different End devices such as, PC,
Laptop, Tablet, Smartphone, etc.
21 | P a g e
EXPERIMENT No.13 October 22, 2020
Step5 : Click on PC or any End devices then, in End devices physical settings turn off the device
first then drag the WMP300N from MODULES and put it on the connection part as shown in
picture that is given below. After this turn on the device.
Step6 : Now, go to Config > Wirless0. Go to SSID column enter the same ID which you
provided in Access Point-PT then in the Authentication part select WEP then in the WEP Key
column enter the same key which we provided in Access Point. After this go to IP
Configuration part select Static IP and provide IPv4 Address and it automatically fills the
subnet mask. For example, enter the same SSID - ‘ABC’ and Key – ‘9013778867’ that we
entered in Access Point then provide an IP such as 192.168.1.2, 192.168.1.3 , 192.168.1.4 , so on
for other devices.
22 | P a g e
EXPERIMENT No.13 October 22, 2020
Step7 : Perform the same step with other End devices to add SSID and Key to make devices
wireless. You need to do all these settings in only Wireless0 for the other devices too. When all
the devices got connected with the Access Point-PT at that time a wire will be visible as you can
see in the output image.
****************
23 | P a g e