Professional Documents
Culture Documents
online/)
Dashboard (https://www.tuvsud.online/tutor-dashboard/)
My Profile (https://www.tuvsud.online/tutor-dashboard/my-profile)
Wishlist (https://www.tuvsud.online/tutor-dashboard/wishlist)
Settings (https://www.tuvsud.online/tutor-dashboard/settings)
Logout (https://www.tuvsud.online/tutor-dashboard/logout)
Quiz Overview
3 What must be used to A plastic box cutter A plastic box cutter Correct
open boxes?
7 Which of the below All the needle pieces All the needle pieces must Incorrect
statements ARE must be located and be located and checked
correct? checked against a against a whole needle to
whole needle to make make sure all the pieces
sure all the pieces have been found.
have been found. The
workplace/workstation/bench
must be checked with a
magnetic sweeper or pencil/
pen type magnet or hand-
held metal detector before
work restarts.
The needle pieces must be
immediately and securely
attached to a Broken Needle
Report with clear adhesive
tape and all information
recorded.
A new needle may only be
issued when it is confirmed
that all the needle pieces are
found.
9 Where can you find and In Datalink, in the tab In Datalink, in the tab titled Correct
view the Primark metal titled Metal Policy. Metal Policy.
policy and appendices?
/
(https://www.tuvsud.online/)
18 If you cannot find all the The product being The product being worked Correct
pieces of a broken worked on and any on and any other work within
needle what must you other work within a 3 a 3 square meters proximity
do? square meters must be placed into a
proximity must be bag/basket or box and taken
placed into a to the isolation area by the
bag/basket or box supervisor for further
and taken to the checking by the authorised
isolation area by the person.
supervisor for further
checking by the
authorised person.
22 How many times in a At the start of the shift At the start of the shift and at Correct
shift should you and at least every 2 least every 2 hours?
calibrate the metal hours?
detector?
24 What should be fed A 1mm test piece A 1mm test piece placed at Correct
through the metal placed at 3 different 3 different heights on the
detector to calibrate the heights on the left- left-hand side of the
machine and how? hand side of the detector, middle of the
detector, middle of the detector and the right-hand
detector and the right- side of the metal detector).
hand side of the metal
detector).
25 In the event that a E. All of the above are E. All of the above are right. Correct
needle or any other right.
dangerous sharp or
unsafe object is found
once the product has
been shipped, which of
the below is correct:
/
Copyright TÜV SÜD Group (https://tuvsud.com/) - Platform managed by ekami (https://www.ekami.ch/)
(https://www.tuvsud.online/)
/