Professional Documents
Culture Documents
Cerrar SIS
Pantalla anterior
Desarmado y Armado
D342 VEHICULAR ENGINE FOR D8K TRACTOR
Número de medio -SENR7010-01 Fecha de publicación -01/09/1977 Fecha de actualización -12/10/2001
start by:
1. Turn the crankshaft until the connecting rod caps are down.
2. Remove nuts (1) and cap (2) from the connecting rods. Remove the lower half of the bearing (3) from the cap.
https://127.0.0.1/...isweb/sisweb/productsearch/productheaderinfoframeset.jsp&calledpage=/sisweb/sisweb/techdoc/techdoc_print_page.jsp[30/11/2020 09:05:44]
D342 VEHICULAR ENGINE 76V00001-00504 (MACHINE)(UEG0890S - 00) - Sistemas y componentes
3. Push the connecting rod away from the crankshaft. Remove the upper half of the bearing from the connecting rod.
4. Install the upper half of the bearing in the connecting rod. Put clean engine oil on the bearing and journal of the
crankshaft.
NOTE: Be sure the tabs in the back of the bearings are in the tab (slots) grooves of the connecting rods and caps.
9. Put clean engine oil on the threads of the rod bolts (4) and seat surfaces.
10. Install rod caps (2). Install the nuts that hold the caps to the connecting rod. Tighten each nut to a torque of 75 ±
5 lb.ft. (100 ± 7 N·m). Put a mark on the nuts and caps and tighten nuts an extra 60° ± 5° from the mark. Remove
the rod caps and check the bearing clearance from (A). The permissible clearance for a new bearing is .0021 to
.0063 in. (0.053 to 0.160 mm). The maximum permissible clearance for a used bearing is .012 in. (0.30 mm).
https://127.0.0.1/...isweb/sisweb/productsearch/productheaderinfoframeset.jsp&calledpage=/sisweb/sisweb/techdoc/techdoc_print_page.jsp[30/11/2020 09:05:44]
D342 VEHICULAR ENGINE 76V00001-00504 (MACHINE)(UEG0890S - 00) - Sistemas y componentes
11. Put clean engine oil on the lower half of the bearings. Install the rod cap again. Tighten each nut to a torque of 75
± 5 lb.ft. (100 ± 7 N·m). Put a mark on the nuts and cap and tighten each nut 60° ± 5° more from the mark.
NOTE: Be sure the numbers on the rod cap and rod are the same and are on the same side of the connecting rod.
end by:
Copyright 1993 - 2020 Caterpillar Inc. Mon Nov 30 09:05:32 EST 2020
Todos los derechos reservados.
Red privada para licenciados del SIS.
https://127.0.0.1/...isweb/sisweb/productsearch/productheaderinfoframeset.jsp&calledpage=/sisweb/sisweb/techdoc/techdoc_print_page.jsp[30/11/2020 09:05:44]