This document provides instructions for setting up the embedded Ethernet function on FANUC 160is and 180is CNC machines. It notes that the NC I/O channel must be set to 9 to use the embedded Ethernet. The document also states that the IP address and subnet mask of the NC control must be set on page 1 of the Ethernet parameters, and that the control must be restarted if these settings are changed.
This document provides instructions for setting up the embedded Ethernet function on FANUC 160is and 180is CNC machines. It notes that the NC I/O channel must be set to 9 to use the embedded Ethernet. The document also states that the IP address and subnet mask of the NC control must be set on page 1 of the Ethernet parameters, and that the control must be restarted if these settings are changed.
This document provides instructions for setting up the embedded Ethernet function on FANUC 160is and 180is CNC machines. It notes that the NC I/O channel must be set to 9 to use the embedded Ethernet. The document also states that the IP address and subnet mask of the NC control must be set on page 1 of the Ethernet parameters, and that the control must be restarted if these settings are changed.