Professional Documents
Culture Documents
Project : Petronas
Client : Petronas
Client : Petrenos
ELECTRICAL - 631
11 3.3KV VFD 0
17 VFD 2040000
32 FAG System 0
17 VFD 4761000
32 FAG System 0
TOTAL
ERECTION TOTAL (INR)
(INR)
3.59328
0.07985
0.7434
2.83333
2.13553
0.15025
1.62507
3.35316
1.02129
3.639
1.62507
2.87374
7.79449
17.5748
0.43788
0.23718
16.2321
0.91852
0.214
9.52885
0.14421
1.29871
0.08049
0.55015
0.09659
1.68336
0.11349
1.30258
0.23611
3.21969
1.24734
13.4164
100
TOTAL
ERECTION TOTAL (INR)
(INR)
3.19985
0.04998
0.52535
1.59949
1.78582
0.18933
0.4544
3.48138
0.11042
10.7695
0.4544
3.0808
7.77622
18.6036
0.72113
0.22402
1.82842
0.27264
0.24992
24.1225
0.04285
3.77823
0.0568
1.00611
0.1704
1.49195
0.09175
1.95669
0.16661
2.272
9.46741
100
Project: Petrenos USD MYR EUR CHF GBP
Client : Petrenos 62.62 16.86 67.47 63.7 101.56
SUBSTATION 631
1 11kV HT Panels
i 11kV,25kA/3sec HT switchboard1 with 13 13 Set 1276192 1276192 16740495 202320 202320 2630160
verticals & 2 verticals dummy
16740495 2630160
i 11kV,25kA XLPE, Cu. Ar. (E) - 3Cx 240sqmm 20 Set(s) #VALUE! 15000 Err:504 Err:504 1000 20000
i 11kV,25kA XLPE, Cu. Ar. (E) - 3Cx 240sqmm 4 No(s) #VALUE! Err:504 Err:504 Err:504 1000 4000
372000 24000
3
11kV HT FRLS Power Cables, Ar. XLPE
(E)- Cu.
a Cables
i 11kV,25kA XLPE, Cu. Ar. (E) - 3Cx 240sqmm 450 Mtr(s) #VALUE! Err:504 Err:504 Err:504 818 367970
b Glands
i 11kV,25kA XLPE, Cu. Ar. (E) - 3Cx 240sqmm 20 No(s) #VALUE! Err:504 Err:504 Err:504 500 10000
c Lugs -Copper
i 11kV,25kA XLPE, Cu. Ar. (E) - 3Cx 240sqmm 60 No(s) #VALUE! Err:504 Err:504 Err:504 500 30000
3463395 407970
13200000 526032
5 Power Transformers
9949086 2562720
6 Neutral earthing resistors
NER shall be mounted in Corrosion Resistance
Earthed enclosure.NER shall have IP55 degree of
protection for outdoor installation.Resistant
elememts shall be stainless steel of low
temperature coefficient. Resistor shall be
suitably painted to protect against corrosion.CT
for 51N shall be mounted in NER enclosure.
i NER (4 ohm, 874A,10s) 2 No(s) 350000 350000 700000 13488 13488 26976
700000 26976
7
Battery and Battery charger with
DCDB(Redundant type)
8 3.3kV HT Panels
i 3.3kV,25kA XLPE, Cu. Ar. (E) - 3Cx 240sqmm 1 No(s) #VALUE! Err:504 Err:504 Err:504 Err:504 Err:504
ii 3.3kV,25kA XLPE, Cu. Ar. (E) - 3Cx 185sqmm 10 No(s) #VALUE! Err:504 Err:504 Err:504 Err:504 Err:504
4758000 315000
10
HT FRLS Power Cables, Ar. XLPE (E)-
Cu.
a Cables
i 3.3kV,25kA XLPE, Cu. Ar. (E) - 3Cx 240sqmm 150 Mtr(s) #VALUE! Err:504 Err:504 Err:504 Err:504 #VALUE!
ii 3.3kV,25kA XLPE, Cu. Ar. (E) - 3Cx 185sqmm 2150 Mtr(s) #VALUE! Err:504 Err:504 Err:504 Err:504 #VALUE!
b Glands
Double compression, brass type gland with
sealing ring or compound filled seal confirming
to latest International standard
i 3.3kV,25kA XLPE, Cu. Ar. (E) - 3Cx 240sqmm 8 No(s) #VALUE! Err:504 Err:504 Err:504 500 4000
ii 3.3kV,25kA XLPE, Cu. Ar. (E) - 3Cx 185sqmm 300 No(s) #VALUE! Err:504 Err:504 Err:504 500 150000
c Lugs -Copper
i 3.3kV,25kA XLPE, Cu. Ar. (E) - 3Cx 240sqmm 24 No(s) #VALUE! Err:504 Err:504 Err:504 Err:504 Err:504
ii 3.3kV,25kA XLPE, Cu. Ar. (E) - 3Cx 185sqmm 900 No(s) #VALUE! Err:504 Err:504 Err:504 Err:504 Err:504
16953492 2496733
11 3.3KV VFD
Variable frequency drives along with Converter
transformer,harmonic filters,Reactors shall be as
per specification. number of pulses 12 or
more.with restarting/reacceleration facility and
communication protocol for integration with
DCS/ESD
i 3.3 kV 132 kW for DAF Feed pump 0 Set #VALUE! Err:504 Err:504 33720 33720 0
0 0
12
3.3KV Dry type Converter
transformer
Battery
3.3/3.3 charger
kv 315kVAshall
HTbeDryfloat type. The charger
type
i shall be static modular type.Battery shall be Ni-
transformer(VFD) 0 No(s) #VALUE! 800000 Err:504 16860 16860 0
cd and recombination type & rectifier shall be
thyristor controlled bridge rectifier.Degree of 0 0
protectionand
Battery shall Battery
be IP31.Eachcharger
batterywith
system
13 shall be provided with battery
DCDB(Redundant type) isolation circuit
breaker mounted within Ee Xd IIC T6 certified
a enclosure
For suitable for Zone 2 environment.It
3.3kV switchboard
shall be provided with communication protocol
i 110V DC Ni.cadmium type battery - 300AH
for integration with ENMCS,DCS,FGS and ESD 1 No(s) 67440 67440 67440
ii type. cum
Float It shall be provided
boost charger for with RS 232 batteries
110V,100A 1 No(s) 7570936 7570936 7570936 Err:504 Err:504 #VALUE!
iii communication port
DC distribution board for connection of Personal 1 No(s) Err:504 Err:504 #VALUE!
computer. - 30 min back-up
7570936 121392
14
Distribution Transformers (oil filled
outdoor)
As per IEC 60076,Oil filled, hermetically sealed
and naturally air cooled out door type, OFTC,
IP54 grade with necessary special tools
11kV/420V, 2500 KVA Oil filled transformer 2 No(s) #VALUE! 4163746 Err:504 Err:504 Err:504 #VALUE!
11kV/420V, 1000 KVA Oil filled transformer 2 No(s) #VALUE! 1756138 Err:504 Err:504 Err:504 #VALUE!
11kV/420V, 100 KVA Oil filled transformer 1 No(s) #VALUE! Err:504 Err:504 Err:504 Err:504 #VALUE!
315 KVA cast resin encapsulated winding - 1 No(s) #VALUE! Err:504 Err:504 Err:504 7587 7587
Lighting Transformers dry type
13388249 2941227
15 Bus Ducts
Sandwich busduct from TF to Panel with
elbows, bends and all other necessary
accessories to complete the busduct system
Compliance to relevant IEC 61439 International
standards. The enclouser shall be made of steel
or non ferrous metal. Insulating covers of
busbars shall be moisture proof,flame retardant
& corrosion resistant material.It shall be
provided with thermostats with hermatically
sealed contacts suitable for installation in Zone 2
area.Thermostatically controlled Space heaters
shall be provided. Degree of protection shall be
IP54/IP65 .
i 415V, 4P, 4000A, 65kA 50Hz Cu. (TF to LT Panel 2 Set #VALUE! Err:504 Err:504 Err:504 Err:504 #VALUE!
) - 10 Meters
i 415V, 4P, 1600A, 65kA 50Hz Cu. (TF to LT Panel 2 Set #VALUE! Err:504 Err:504 Err:504 Err:504 #VALUE!
) - 10 Meters
xi 400V,63A,20KVA, AC UPS Panel with Double 1 No(s) #VALUE! Err:504 Err:504 25290 Err:504 #VALUE!
I/C(INSTRUMENTATION - )
xii 400V,63A, 10KVA, AC UPS Panel with Double I/C 1 No(s) #VALUE! Err:504 Err:504 Err:504 Err:504 #VALUE!
xiii 400V,32A,5KVA,AC UPS Panel with Double I/C 1 No(s) #VALUE! Err:504 Err:504 Err:504 Err:504 #VALUE!
xiv 400V,63A,10KVA,DC UPS Panel with Double I/C 1 No(s) #VALUE! Err:504 Err:504 Err:504 Err:504 #VALUE!
xiv 400V , Interpose Relay Panel 1 No(s) #VALUE! Err:504 Err:504 Err:504 Err:504 #VALUE!
xiv 400V , Utility Distribution Panel 1 No(s) #VALUE! Err:504 Err:504 Err:504 Err:504 #VALUE!
xv 400V , Emergency Utility Distribution Panel 1 No(s) #VALUE! Err:504 Err:504 Err:504 Err:504 #VALUE!
xvi 415V, MLDB , Cu busbar 1 No(s) #VALUE! Err:504 Err:504 Err:504 Err:504 #VALUE!
xvii 415V, MPDB , Cu busbar 1 No(s) #VALUE! Err:504 Err:504 Err:504 Err:504 #VALUE!
81877945 1947330
17
VFD
Variable frequency drives along with Converter
transformer,harmonic filters,Reactors shall be as
per specification. number of pulses 12 or
more.with restarting/reacceleration facility and
communication protocol for integration with
DCS/ESD
i 400V 45kW for DAF Feed pump 3 Set #VALUE! Err:504 Err:504 Err:504 Err:504 #VALUE!
ii 400V 45kW for AOC receiving pit pump 3 Set #VALUE! Err:504 Err:504 Err:504 Err:504 #VALUE!
iii 400V 75kW forDAF recirculation pump 6 Set #VALUE! Err:504 Err:504 Err:504 Err:504 #VALUE!
Err:504 #VALUE!
b Outdoor LDBs
c PDBs
e Emergency LDB
Phase segregated 8 Way DB - 63A TPN MCB I/C -
i 1 No ,32A DP,30mA ELCB Sub I/c - 3 nos ,16A SP 8 No (s) #VALUE! Err:504 Err:504 Err:504 Err:504 Err:504
MCB -24 numbers
Flame proof , Phase segregated three phase DB
ii 32A TPN MCB I/C - 1 No , 32A DP,MCB Sub I/c - 3 2 No (s) #VALUE! Err:504 Err:504 Err:504 Err:504 Err:504
nos ,16A SP MCB -24 numbers
iv 400V,63A,5KVA,DC UPS Panel with Double 1 Set (s) #VALUE! Err:504 Err:504 Err:504 Err:504 #VALUE!
I/C((EMERGENCY LIGHTING) - 1hour
75622771 225924
20
Battery and Battery charger with
Battery charger shall be float type. The charger
DCDB(Redundant
shall type)
be static modular type.Battery shall be Ni-
cd and recombination type & rectifier shall be
thyristor controlled bridge rectifier.Degree of
protection shall be IP31.Each battery system
shall be provided with battery isolation circuit
breaker mounted within Ee Xd IIC T6 certified
enclosure suitable for Zone 2 environment.It
shall be provided with communication protocol
for integration with ENMCS,DCS,FGS and ESD
type. It shall be provided with RS 232
communication port for connection of Personal
a For 400V switchboard
computer. - 30 min back-up
i 110v Ni.cadmium type battery - 100AH 1 Set (s) 67440 67440 67440
ii Float cum boost charger for 110V,60 A batteries 1 Set (s) 4279239 4279239 4279239 Err:504 Err:504 #VALUE!
iii DC distribution board 1 Set (s) Err:504 Err:504 #VALUE!
4279239 121392
21 Local/Remote Control Unit
Local Push Button Station including
i local/Remote 74 No (s) #VALUE! 7500 Err:504 Err:504 500 37000
start/stop/running/tripped/available push
iii Same as above with Flame proof type 52 No (s) #VALUE! Err:504 Err:504 Err:504 500 26000
997000 63000
22 LV Cables, FRLS ( Copper cables)
0.6/1kV Cables shall conform to the latest
International standardss. XLPE insulated,plain
annealed copper or Circular tinned stranded
Copper, galvanised steel wire armoured,PVC
oversheathed
a Power cables
i 4C x 6 350 Mtr(s) #VALUE! Err:504 Err:504 Err:504 Err:504 #VALUE!
ii 4C x 10 200 Mtr(s) #VALUE! Err:504 Err:504 Err:504 Err:504 #VALUE!
iii 4C x 16 1500 Mtr(s) #VALUE! Err:504 Err:504 Err:504 Err:504 #VALUE!
iv 4C x 25 1800 Mtr(s) #VALUE! Err:504 Err:504 Err:504 Err:504 #VALUE!
i 3.5C x 70 350 Mtr(s) #VALUE! Err:504 Err:504 Err:504 Err:504 #VALUE!
ii 3.5C x 150 2200 Mtr(s) #VALUE! Err:504 Err:504 Err:504 Err:504 #VALUE!
iii 3.5C x 185 600 Mtr(s) #VALUE! Err:504 Err:504 Err:504 Err:504 #VALUE!
iv 3.5C x 240 800 Mtr(s) #VALUE! Err:504 Err:504 Err:504 Err:504 #VALUE!
v 3C x 4 6465 Mtr(s) #VALUE! Err:504 Err:504 Err:504 Err:504 #VALUE!
v 3C x 6 2640 Mtr(s) #VALUE! Err:504 Err:504 Err:504 Err:504 #VALUE!
vi 3C x 10 1610 Mtr(s) #VALUE! Err:504 Err:504 Err:504 Err:504 #VALUE!
vii 3C x 16 1130 Mtr(s) #VALUE! Err:504 Err:504 Err:504 Err:504 #VALUE!
viii 3C x 25 1220 Mtr(s) #VALUE! Err:504 Err:504 Err:504 Err:504 #VALUE!
ix 3C x 35 600 Mtr(s) #VALUE! Err:504 Err:504 Err:504 Err:504 #VALUE!
x 3C x 50 1120 Mtr(s) #VALUE! Err:504 Err:504 Err:504 Err:504 #VALUE!
xii 3C x 95 350 Mtr(s) #VALUE! Err:504 Err:504 Err:504 Err:504 #VALUE!
xiii 3C x 120 150 Mtr(s) #VALUE! Err:504 Err:504 Err:504 Err:504 #VALUE!
xiv 3C x 150 2640 Mtr(s) #VALUE! Err:504 Err:504 Err:504 Err:504 #VALUE!
xv 3C x 185 1800 Mtr(s) #VALUE! Err:504 Err:504 Err:504 Err:504 #VALUE!
ix 1C x 2.5 17515 Mtr(s) #VALUE! Err:504 Err:504 Err:504 Err:504 #VALUE!
x 1C x 25 1120 Mtr(s) #VALUE! Err:504 Err:504 Err:504 Err:504 #VALUE!
xii 1C x 35 3490 Mtr(s) #VALUE! Err:504 Err:504 Err:504 Err:504 #VALUE!
xiii 1C x 70 4840 Mtr(s) #VALUE! Err:504 Err:504 Err:504 Err:504 #VALUE!
xiv 1C x 95 2400 Mtr(s) #VALUE! Err:504 Err:504 Err:504 Err:504 #VALUE!
xv 1C x 120 800 Mtr(s) #VALUE! Err:504 Err:504 Err:504 Err:504 #VALUE!
44393268 8781593
23 LT power cable Terminations
a Glands
i 4C x 6 30 Nos #VALUE! Err:504 Err:504 Err:504 Err:504 #VALUE!
ii 4C x 10 10 Nos #VALUE! Err:504 Err:504 Err:504 Err:504 #VALUE!
i 4C x 16 30 Nos #VALUE! Err:504 Err:504 Err:504 Err:504 #VALUE!
ii 4C x 25 20 Nos #VALUE! Err:504 Err:504 Err:504 Err:504 #VALUE!
iii 3.5C x 70 20 Nos #VALUE! Err:504 Err:504 Err:504 Err:504 #VALUE!
iv 3.5C x 150 80 Nos #VALUE! Err:504 Err:504 Err:504 Err:504 #VALUE!
v 3.5C x 185 30 Nos #VALUE! Err:504 Err:504 Err:504 Err:504 #VALUE!
vi 3.5C x 240 40 Nos #VALUE! Err:504 Err:504 Err:504 Err:504 #VALUE!
vii 3C x 4 100 Nos #VALUE! Err:504 Err:504 Err:504 Err:504 #VALUE!
viii 3C x 6 70 Nos #VALUE! Err:504 Err:504 Err:504 Err:504 #VALUE!
ix 3C x 10 10 Nos #VALUE! Err:504 Err:504 Err:504 Err:504 #VALUE!
x 3C x 16 10 Nos #VALUE! Err:504 Err:504 Err:504 Err:504 #VALUE!
xi 3C x 25 16 Nos #VALUE! Err:504 Err:504 Err:504 Err:504 #VALUE!
xii 3C x 35 6 Nos #VALUE! Err:504 Err:504 Err:504 Err:504 #VALUE!
xiii 3C x 50 24 Nos #VALUE! Err:504 Err:504 Err:504 Err:504 #VALUE!
xiv 3C x 95 6 Nos #VALUE! Err:504 Err:504 Err:504 Err:504 #VALUE!
xv 3C x 120 16 Nos #VALUE! Err:504 Err:504 Err:504 Err:504 #VALUE!
xvi 3C x 150 20 Nos #VALUE! Err:504 Err:504 Err:504 Err:504 #VALUE!
xvii 3C x 185 12 Nos #VALUE! Err:504 Err:504 Err:504 Err:504 #VALUE!
xii 1C x 2.5 302 Nos #VALUE! Err:504 Err:504 Err:504 Err:504 #VALUE!
xiii 1C x 25 24 Nos #VALUE! Err:504 Err:504 Err:504 Err:504 #VALUE!
xiv 1C x 35 62 Nos #VALUE! Err:504 Err:504 Err:504 Err:504 #VALUE!
xv 1C x 70 100 Nos #VALUE! Err:504 Err:504 Err:504 Err:504 #VALUE!
xvi 1C x 95 42 Nos #VALUE! Err:504 Err:504 Err:504 Err:504 #VALUE!
xvii 1C x 120 40 Nos #VALUE! Err:504 Err:504 Err:504 Err:504 #VALUE!
b Lugs - copper
i 4C x 6 120 Nos #VALUE! Err:504 Err:504 Err:504 Err:504 #VALUE!
ii 4C x 10 40 Nos #VALUE! Err:504 Err:504 Err:504 Err:504 #VALUE!
iii 4C x 16 120 Nos #VALUE! Err:504 Err:504 Err:504 Err:504 #VALUE!
iv 4C x 25 80 Nos #VALUE! Err:504 Err:504 Err:504 Err:504 #VALUE!
v 3.5C x 70 80 Nos #VALUE! Err:504 Err:504 Err:504 Err:504 #VALUE!
vi 3.5C x 150 320 Nos #VALUE! Err:504 Err:504 Err:504 Err:504 #VALUE!
vii 3.5C x 185 120 Nos #VALUE! Err:504 Err:504 Err:504 Err:504 #VALUE!
viii 3.5C x 240 160 Nos #VALUE! Err:504 Err:504 Err:504 Err:504 #VALUE!
ix 3C x 4 300 Nos #VALUE! Err:504 Err:504 Err:504 Err:504 #VALUE!
i 3C x 6 210 Nos #VALUE! Err:504 Err:504 Err:504 Err:504 #VALUE!
ii 3C x 10 30 Nos #VALUE! Err:504 Err:504 Err:504 Err:504 #VALUE!
iii 3C x 16 30 Nos #VALUE! Err:504 Err:504 Err:504 Err:504 #VALUE!
iv 3C x 25 48 Nos #VALUE! Err:504 Err:504 Err:504 Err:504 #VALUE!
v 3C x 35 18 Nos #VALUE! Err:504 Err:504 Err:504 Err:504 #VALUE!
vi 3C x 50 72 Nos #VALUE! Err:504 Err:504 Err:504 Err:504 #VALUE!
vii 3C x 95 18 Nos #VALUE! Err:504 Err:504 Err:504 Err:504 #VALUE!
viii 3C x 120 48 Nos #VALUE! Err:504 Err:504 Err:504 Err:504 #VALUE!
ix 3C x 150 60 Nos #VALUE! Err:504 Err:504 Err:504 Err:504 #VALUE!
x 3C x 185 36 Nos #VALUE! Err:504 Err:504 Err:504 Err:504 #VALUE!
xi 1C x 2.5 906 Nos #VALUE! Err:504 Err:504 Err:504 Err:504 #VALUE!
xii 1C x 25 72 Nos #VALUE! Err:504 Err:504 Err:504 Err:504 #VALUE!
xiii 1C x 35 186 Nos #VALUE! Err:504 Err:504 Err:504 Err:504 #VALUE!
xiv 1C x 70 300 Nos #VALUE! Err:504 Err:504 Err:504 Err:504 #VALUE!
xv 1C x 95 126 Nos #VALUE! Err:504 Err:504 Err:504 Err:504 #VALUE!
xvi 1C x 120 120 Nos #VALUE! Err:504 Err:504 Err:504 Err:504 #VALUE!
c Cable joints
i 3.5C x 150 5 No (s) #VALUE! Err:504 Err:504 Err:504 Err:504 #VALUE!
ii 3c X 150 5 No (s) #VALUE! Err:504 Err:504 Err:504 Err:504 #VALUE!
iii 3c X 185 5 No (s) #VALUE! Err:504 Err:504 Err:504 Err:504 #VALUE!
671850 1993779
24 Control Cables & Terminations
a Cable - copper
i 3C X 2.5sqmm 18075 Mtr(s) #VALUE! Err:504 Err:504 Err:504 13 225938
ii 9C x 2.5sqmm 18075 Mtr(s) #VALUE! Err:504 Err:504 Err:504 25 451875
b Glands
i 3C X 2.5sqmm 236 No(s) #VALUE! Err:504 Err:504 Err:504 25 5900
ii 9C x 2.5sqmm 236 No(s) #VALUE! Err:504 Err:504 Err:504 25 5900
c Lugs - Copper
i 3C X 2.5sqmm 708 No(s) #VALUE! Err:504 Err:504 Err:504 Err:504 Err:504
ii 9C x 2.5sqmm 1652 No(s) #VALUE! Err:504 Err:504 Err:504 Err:504 Err:504
6050482 748613
25 Erection Material, Cable Pipes
a Hume Pipes
i 300 mm dia PVC hume pipe of standard length 250 Nos #VALUE! 1500 Err:504 400 200 50000
of 10 meters
Cable tray shall be of perforated sheet steel with Err:504 50000
formed flanges and min. 100mm width when
26 Cable Tray
accessible from one end, 200mm width when
accessible from both ends. Cable tray shall be
a hot dip type
Ladder galvanized. Cable
Tray with tray supports shall be
Cover
of a compatible finish with the associated cable
i 150
tray. 150 Mtr(s) #VALUE! Err:504 Err:504 Err:504 Err:504 #VALUE!
ii 300 200 Mtr(s) #VALUE! Err:504 Err:504 Err:504 Err:504 #VALUE!
iii 450 350 Mtr(s) #VALUE! Err:504 Err:504 Err:504 Err:504 #VALUE!
iv 600 300 Mtr(s) #VALUE! Err:504 Err:504 Err:504 Err:504 #VALUE!
v 900 150 Mtr(s) #VALUE! Err:504 Err:504 Err:504 Err:504 #VALUE!
b Perforated type Tray with Cover
i 50 100 Mtr(s) #VALUE! Err:504 Err:504 Err:504 Err:504 #VALUE!
ii 100 100 Mtr(s) #VALUE! Err:504 Err:504 Err:504 Err:504 #VALUE!
Err:504 #VALUE!
27 Supports (steel)
i Supports (steel) for Cable Tray, panel & LPBS 10 Ton #VALUE! 45000 Err:504 0 Err:504 #VALUE!
Err:504 #VALUE!
28 Earthing System
a Earth pits
For TF with necessary accessories for providing
and fixing earthing arrangement with copper
i earth rod 20mm dia including packing of 16 No (s) #VALUE! Err:504 Err:504 5901 Err:504 #VALUE!
charcoal powder and salt as per specification,
water pipe etc. complete with refilling the pit
For PMCC/ MCC Panel, APFC & UPS with
as required,
necessary accessories for providing and fixing
earthing arrangement with copper/stainless
steel earth electrode including packing of
ii charcoal powder and salt as per specification, 25 No (s) #VALUE! Err:504 Err:504 5901 Err:504 #VALUE!
water pipe etc. complete with refilling the pit
as required, but excluding the excavation of
earth pit.
For TF Neutral with necessary accessories for
providing and fixing earthing arrangement with
iii copper earth rod 20mm dia including packing 16 No (s) #VALUE! Err:504 Err:504 5901 Err:504 #VALUE!
of charcoal powder and salt as per
specification, water pipe etc. complete with
refilling the pit
For Plant with as required,
necessary accessories for
providing and fixing earthing arrangement with
iv copper earth rod 20mm dia including packing 30 No (s) #VALUE! Err:504 Err:504 5901 Err:504 #VALUE!
of charcoal powder and salt as per
b specification,
Cu cable water pipe etc. complete with
refilling the pit as required,
i 2 x 120 sqmm(t/f,LV panels) 1500 Mtr(s) #VALUE! Err:504 Err:504 Err:504 Err:504 #VALUE!
ii 2 x 70 sqmm( HV panels) 50 Mtr(s) #VALUE! Err:504 Err:504 Err:504 Err:504 #VALUE!
70 sqmm(main earth grid,cable
iii trays,lightning,for motors having cable cross 2500 Mtr(s) #VALUE! Err:504 Err:504 Err:504 Err:504 #VALUE!
section greater than 35sqmm)
iv 25sqmm(for motors less than 35sqmm) 1500 Mtr(s) #VALUE! Err:504 Err:504 Err:504 Err:504 #VALUE!
v 4swg for Dbs 500 Mtr(s) #VALUE! Err:504 Err:504 Err:504 Err:504 #VALUE!
v 8swg for LPBS,light fixtures 1500 Mtr(s) #VALUE! Err:504 Err:504 Err:504 Err:504 #VALUE!
c Earth Busbars
i Various sizes of bus-bars for interconnecting the 1 Lot #VALUE! Err:504 Err:504 134880 Err:504 #VALUE!
earthing system
Connectors, joints, bondings,clamps, and all
ii Accessories necessary to complete the earthing 1 Lot #VALUE! Err:504 Err:504 168600 Err:504 #VALUE!
system
Providing and fixing lightning arrangement with Err:504 #VALUE!
15 mm dia 3 meter long Cu rod, including
29 Lightning
packing Systempowder and salt as per
of charcoal
i specification, water pipe 15 mm. dia Cu. 3 Nos #VALUE! Err:504 Err:504 Err:504 Err:504 #VALUE!
ii connections etc. complete
3M long lightning spike withwith refilling the
all accessories 3 Nos #VALUE! Err:504 Err:504 Err:504 Err:504 #VALUE!
pit as required, but excluding the excavation
iii 25x3mm Cu
of earth pit. flat (Air terminals, DCs) 60 Mtrs #VALUE! Err:504 Err:504 Err:504 Err:504 #VALUE!
iv Test links 3 Nos #VALUE! Err:504 Err:504 Err:504 Err:504 #VALUE!
Connectors, joints, bondings,clamps, and all
Accessories necessary to complete the 1 Lot #VALUE! Err:504 Err:504 Err:504 Err:504 #VALUE!
v lighgtning system
Err:504 143310
30 Lighting & including
Light fixtures Small power system
all accessories like
electronic choke ,starter ,holder,control gear
,fixing accessories like down rod/chain
suspender including lamps,connecting
fitting.Luminaries shall be designed for
continous trouble free operations. Outdoor shall
a be weather
Indoor proof and rain proof type.
Lights
i Surface mounted Industrial type 2 x 36 HF for 135 Nos #VALUE! Err:504 Err:504 Err:504 Err:504 #VALUE!
Substation,FAR,OSB
Same as above with self-contained battery back-
ii 25 Nos #VALUE! Err:504 Err:504 Err:504 Err:504 #VALUE!
up - 1hour
iii False ceiling Mirror optic type 2 x 36 HF for 30 Nos #VALUE! Err:504 Err:504 Err:504 Err:504 #VALUE!
Control Room,Laboratory,Admin)
b Outdoor
Post Lights type Gate lights , weather
top lantern
proof, suitable for Metal halide lamp 70/150
watts and shall conform to IS 2149, Opel white
one piece double conical dome made of vandal
proof high density polyethylene resistant to ultra 5 Nos 2500 2500 12500 150 75 375
violet
radiation and heat
Post top lantern with
type IP 43,
Gate die, cast
lights weather
Aluminium MEVfor
proof, suitable treated. The pressure
Metal halide ring shall
lamp 70/150
be diaand
watts castshall
Aluminium
conformM.B.V. treated.
to IS 2149, Opel white
one piece double conical dome made of vandal
proof high density polyethylene resistant to ultra
violet 2 Nos 4000 4000 8000 150 75 150
radiation and heat with IP 43, die cast
Aluminium MEV treated. The pressure ring shall
be dia cast Aluminium M.B.V. treated. -
Emergency
1 x 70W HPSV back-up one hour with all accessories
type complete
and shall be Deep drawn Aluminium reflector
stove enameled grey outside and brightened 75 Nos 2500 2500 187500 150 75 5625
and anodized inside lined with felt gasket to
prevent insect entry -mSingle arm).
Non integral 1x250W HPSV Fl. Ftg. With sensor 60 Nos 3500 3500 210000 150 75 4500
Err:504 0
34 ELSOR study 1 Lot #VALUE! Err:504 Err:504 #N/A #N/A 0
5811136 0
ENMCS system & others
35 Electrical Network Monitoring Control System 1 Lot #VALUE! Err:504 Err:504 2529000 Err:504 #VALUE!
Man hours cost 1 Lot #VALUE! Err:504 Err:504 Err:504 Err:504 #VALUE!
Training 20 days #VALUE! Err:504 Err:504 Err:504 Err:504 #VALUE!
Interface Contractror Lot #VALUE! Err:504 Err:504 Err:504 Err:504 #VALUE!
Load Shedding Sysem 1 Lot #VALUE! Err:504 Err:504 Err:504 Err:504 #VALUE!
Taxes & duties 1 Lot #VALUE! Err:504 Err:504 Err:504 Err:504 #VALUE!
Freight 1 Lot #VALUE! Err:504 Err:504 Err:504 Err:504 #VALUE!
commissioning of HT panels 5 days #VALUE! Err:504 Err:504 Err:504 Err:504 #VALUE!
Commissioning of LT panels 10 days #VALUE! Err:504 Err:504 Err:504 Err:504 #VALUE!
Commissioning of VFD drives HT 0 days #VALUE! Err:504 Err:504 Err:504 Err:504 #VALUE!
Commissioning of UPS 2 days #VALUE! Err:504 Err:504 Err:504 Err:504 #VALUE!
Commissioning of Transformer 3 days #VALUE! Err:504 Err:504 Err:504 Err:504 #VALUE!
62504800 2529000
Type test
35 Type test for 1 Lot #VALUE! Err:504 Err:504
Cables 1 Lot #VALUE! Err:504 Err:504
HV panel 1 days #VALUE! Err:504 Err:504
LV panel 0 Lot #VALUE! Err:504 Err:504
Transformer 0 Lot #VALUE! Err:504 Err:504
Motors 1 Lot #VALUE! Err:504 Err:504
VFD 1 Lot #VALUE! Err:504 Err:504
0 0
TOTAL - ELECTRICAL PLANT 465882909 39514082
INR
1
TOTAL (INR)
19370655
19370655
320000
76000
396000
3681364
70000
120000
3871364
13726032
13726032
12511806
12511806
726976
726976
7638376
#VALUE!
#VALUE!
7692328
18580730
18580730
Err:504
Err:504
Err:504
Err:504
5073000
#VALUE!
#VALUE!
Err:504
Err:504
Err:504
Err:504
19450225
0
0
7638376
#VALUE!
#VALUE!
7692328
#VALUE!
#VALUE!
#VALUE!
307587
16329476
#VALUE!
#VALUE!
#VALUE!
#VALUE!
36758315
#VALUE!
#VALUE!
#VALUE!
#VALUE!
#VALUE!
#VALUE!
#VALUE!
#VALUE!
#VALUE!
#VALUE!
#VALUE!
#VALUE!
#VALUE!
#VALUE!
#VALUE!
#VALUE!
#VALUE!
#VALUE!
83825275
491160
491160
#VALUE!
#VALUE!
Err:504
Err:504
Err:504
Err:504
Err:504
Err:504
Err:504
Err:504
Err:504
Err:504
Err:504
1181500
#VALUE!
#VALUE!
#VALUE!
#VALUE!
75848695
4346679
#VALUE!
#VALUE!
4400631
Err:504
Err:504
1060000
#VALUE!
#VALUE!
#VALUE!
#VALUE!
#VALUE!
#VALUE!
#VALUE!
#VALUE!
#VALUE!
#VALUE!
#VALUE!
#VALUE!
#VALUE!
#VALUE!
#VALUE!
#VALUE!
#VALUE!
#VALUE!
#VALUE!
#VALUE!
#VALUE!
#VALUE!
#VALUE!
#VALUE!
#VALUE!
53174861
#VALUE!
#VALUE!
#VALUE!
#VALUE!
#VALUE!
#VALUE!
#VALUE!
#VALUE!
#VALUE!
#VALUE!
#VALUE!
#VALUE!
#VALUE!
#VALUE!
#VALUE!
#VALUE!
#VALUE!
#VALUE!
#VALUE!
#VALUE!
#VALUE!
#VALUE!
#VALUE!
#VALUE!
#VALUE!
#VALUE!
#VALUE!
#VALUE!
#VALUE!
#VALUE!
#VALUE!
#VALUE!
#VALUE!
#VALUE!
#VALUE!
#VALUE!
#VALUE!
#VALUE!
#VALUE!
#VALUE!
#VALUE!
#VALUE!
#VALUE!
#VALUE!
#VALUE!
#VALUE!
#VALUE!
#VALUE!
#VALUE!
#VALUE!
#VALUE!
#VALUE!
#VALUE!
2665629
Err:504
Err:504
Err:504
Err:504
Err:504
Err:504
6799095
Err:504
Err:504
#VALUE!
#VALUE!
#VALUE!
#VALUE!
#VALUE!
#VALUE!
#VALUE!
#VALUE!
#VALUE!
#VALUE!
#VALUE!
#VALUE!
#VALUE!
#VALUE!
#VALUE!
#VALUE!
#VALUE!
#VALUE!
#VALUE!
#VALUE!
#VALUE!
#VALUE!
#VALUE!
#VALUE!
#VALUE!
#VALUE!
#VALUE!
#VALUE!
672060
#VALUE!
#VALUE!
#VALUE!
#VALUE!
12875
8150
193125
230625
214500
30375
960000
1350000
#VALUE!
#VALUE!
#VALUE!
#VALUE!
#VALUE!
#VALUE!
#VALUE!
#VALUE!
#VALUE!
#VALUE!
#VALUE!
#VALUE!
#VALUE!
#VALUE!
#VALUE!
#VALUE!
#VALUE!
#VALUE!
#VALUE!
#VALUE!
#VALUE!
#VALUE!
9205608
#VALUE!
#VALUE!
Err:504
Err:504
Err:504
Err:504
Err:504
5811136
#VALUE!
#VALUE!
#VALUE!
#VALUE!
#VALUE!
#VALUE!
#VALUE!
#VALUE!
#VALUE!
#VALUE!
#VALUE!
#VALUE!
#VALUE!
0
472974021
Project: Petrenos USD MYR
UNIT
TOTAL
DISCOUNTED DISCOUNTED
Sl.No. Equipment Description Qty. Unit SUPPLY PRICE
SUPPLY PRICE (INR)
(INR)
SUBSTATION 632
1 11kV HT Panels
Switch gear VCB shall be of metal enclosed, single front, free standing, floor mounted and
fully compartmental execution, IP4X. Surge arrestor shall be provided for all incomers.
Earthing busbars shall be of copper. Main busbars shall be of copper. All protection relays
shall be of numerical type with communication protocol for optimising the integration
with ENMCS scheme as per IEC 61850.
21125774
The termination kits shall be suitable for termination of the cables to an indoor
switchgear or to a weather proof cable box of an outdoor mounted transformer/motor.
For outdoor terminations, weather shields/sealing ends and any other accessories
required shall also form part of the kit. The termination kits shall be from one of the
makes/types mentioned in the data sheet.
As per IEC 60076,Oil filled, hermatically sealed and naturally air cooled out door type,
b. OFTC, IP54 grade, fitted with removable link to connect secondary winding neutral point
to earth with HT cable box and LT cable box .
11790198
6 Neutral earthing resistors
NER shall be mounted in Corrosion Resistance Earthed enclosure.NER shall have IP55
degree of protection for outdoor installation.Resistant elememts shall be stainless steel of
low temperature coefficient. Resistor shall be suitably painted to protect against
corrosion.CT for 51N shall be mounted in NER enclosure.
1250000
7 Battery and Battery charger with DCDB(Redundant type)
Battery charger shall be float type. The charger shall be static modular type.Battery shall
be Ni-cd type & rectifier shall be thyristor controlled bridge rectifier.Degree of protection
shall be IP31.Each battery system shall be provided with battery isolation circuit breaker
mounted within Ee Xd IIC T6 certified enclosure suitable for Zone 2 environment.It shall
be provided with communication protocol for integration with ENMCS,DCS,FGS and ESD
type. It shall be provided with RS 232 communication port for connection of Personal
computer. - 30 min back-up
24
Project: Petrenos USD MYR
UNIT
TOTAL
DISCOUNTED DISCOUNTED
Sl.No. Equipment Description Qty. Unit SUPPLY PRICE
SUPPLY PRICE (INR)
(INR)
Switch gear VCB shall be of metal enclosed, single front, free standing, floor mounted and
fully compartmental execution, IP4X. Surge arrestor shall be provided for all incomers.
Earthing busbars shall be of copper. Main busbars shall be of copper. All protection relays
shall be of numerical type with communication protocol for optimising the integration
with ENMCS scheme as per IEC 61850.
22984449
9 Termination Kits with boots(E)
The termination kits shall be suitable for termination of the cables to an indoor
switchgear or to a weather proof cable box of an outdoor mounted transformer/motor.
For outdoor terminations, weather shields/sealing ends and any other accessories
required shall also form part of the kit. The termination kits shall be from one of the
makes/types mentioned in the data sheet.
Battery charger shall be float type. The charger shall be static modular type.Battery shall
be Ni-cd and recombination type & rectifier shall be thyristor controlled bridge
rectifier.Degree of protection shall be IP31.Each battery system shall be provided with
battery isolation circuit breaker mounted within Ee Xd IIC T6 certified enclosure suitable
for Zone 2 environment.It shall be provided with communication protocol for integration
with ENMCS,DCS,FGS and ESD type. It shall be provided with RS 232 communication port
for connection of Personal computer. - 30 min back-up
iv 11kV/420V, 315 KVA cast resin encapsulated winding - Lighting Transformers dry type 1 No(s) Err:504 Err:504
20339796
13 Bus Ducts
Sandwich busduct from TF to Panel with elbows, bends and all other necessary
accessories to complete the busduct system Compliance to relevant IEC 61439
International standards. The enclouser shall be made of steel or non ferrous metal.
Insulating covers of busbars shall be moisture proof,flame retardant & corrosion resistant
material.It shall be provided with thermostats with hermatically sealed contacts suitable
for installation in Zone 2 area.Thermostatically controlled Space heaters shall be
provided. Degree of protection shall be IP54/IP65 .
i 415V, 4P, 4000A, 65kA 50Hz Cu. (TF to LT Panel ) - 10 Meters 6 Set Err:504 Err:504
25
Project: Petrenos USD MYR
UNIT
TOTAL
DISCOUNTED DISCOUNTED
Sl.No. Equipment Description Qty. Unit SUPPLY PRICE
SUPPLY PRICE (INR)
(INR)
ii 415V, 4P, 2500A, 65kA 50Hz Cu. (TF to LT Panel ) - 10 Meters 1 Set Err:504 Err:504
Adaptor box with flexi joints in the two ends for 415V, 4P, 4000A, 50Hz Cu. busduct from
iii 12 Set Err:504 Err:504
(TF to LT Panel ) with all accessories
Adaptor box with flexi joints in the two ends for 415V, 4P, 2500A, 50Hz Cu. busduct from
iv 2 Set Err:504 Err:504
(TF to LT Panel ) with all accessories
51339416
i 400V, 2000A, Cu busbar with three I/C & two buscoupler (MDB 1) 1 No(s) Err:504 Err:504
ii 400V, 2000A, Cu busbar with two I/C & one buscoupler(MDB 2) 1 No(s) Err:504 Err:504
iii 400V, 1000A, Cu busbar with two I/C & one buscoupler(MDB 3) 1 No(s) Err:504 Err:504
iv 400V, 800A, MCC - 1 Cu busbar with single I/C 1 No(s) Err:504 Err:504
v 400V, 630A, MCC-2 Cu busbar with single I/C 1 No(s) Err:504 Err:504
vi 400V, 800A, MCC-3 Cu busbar with single I/C 1 No(s) Err:504 Err:504
vii 400V, 1000A, MCC-4 Cu busbar with single I/C 1 No(s) Err:504 Err:504
viii 400V,630A, MCC-5 Cu busbar with single I/C 1 No(s) Err:504 Err:504
ix 400V, 400A, MCC-6 Cu busbar with single I/C 1 No(s) Err:504 Err:504
x 400V,32A,5KVA,AC UPS Panel with Double I/C(INSTRUMENTATION - ENMCS) 1 No(s) Err:504 50000
xi
400V,32A,5KVA,DC UPS Panel with Double I/C(ELECTRICAL - EMERGENCY LIGHTING) 1 No(s) Err:504 Err:504
xii 400V , Interpose Relay Panel with single I/C 1 No(s) Err:504 Err:504
xiii 415V, MLDB , Cu busbar 1 No(s) Err:504 Err:504
xiv 415V, MPDB , Cu busbar 1 No(s) Err:504 Err:504
122822656
17 VFD
i 400V 45kW for DAF Recycling pump Motor 3 Set Err:504 480000
iii 400V 75kW for Overflow pit pumps 10 Set Err:504 Err:504
v 400V 110kW for Equilisation tank feed pump 3 Set Err:504 Err:504
4761000
18 Distribution Boards and accessories
a Building LDBs
Phase segregated 8 Way DB - 63A TPN MCB I/C - 1 No ,32A DP,30mA ELCB Sub I/c - 3
i nos ,16A SP MCB -24 numbers 10 No (s) Err:504 Err:504
Flame proof, Phase segregated 8 Way DB - 63A TPN MCB I/C - 1 No ,32A DP,30mA ELCB
ii Sub I/c - 3 nos ,16A SP MCB -24 numbers 5 No (s) Err:504 Err:504
b Outdoor LDBs
63A TPN MCB, 30mA ELCB I/C - 1 No with timer , 32A TPN, MCB O/Gs -12 numbers
i 5 No (s) Err:504 Err:504
63A TPN MCB I/C - 1 No with timer , 32A DP,30mA ELCB Sub I/c - 3 nos ,16A SP MCB -12
ii numbers 5 No (s) Err:504 Err:504
c PDBs
Phase segregated 8 Way DB - 63A TPN MCB I/C - 1 No ,32A DP,30mA ELCB Sub I/c - 3
i nos ,16A SP MCB -24 numbers 5 No (s) Err:504 Err:504
Flame proof, Phase segregated 8 Way DB - 63A TPN MCB I/C - 1 No ,32A DP,30mA ELCB
ii Sub I/c - 3 nos ,16A SP MCB -24 numbers 5 No (s) Err:504 Err:504
iii Single phase DB 16A DP MCB I/C - 1 No , 6A SP MCB - 8numbers 3 No (s) Err:504 Err:504
e Emergency LDB
Phase segregated 8 Way DB - 63A TPN MCB I/C - 1 No ,32A DP,30mA ELCB Sub I/c - 3
i nos ,16A SP MCB -24 numbers 10 No (s) Err:504 Err:504
Flame proof , Phase segregated three phase DB 32A TPN MCB I/C - 1 No , 32A DP,MCB
ii Sub I/c - 3 nos ,16A SP MCB -24 numbers 5 No (s) Err:504 Err:504
26
Project: Petrenos USD MYR
UNIT
TOTAL
DISCOUNTED DISCOUNTED
Sl.No. Equipment Description Qty. Unit SUPPLY PRICE
SUPPLY PRICE (INR)
(INR)
Flame proof, Phase segregated 8 Way DB - 63A TPN MCB I/C - 1 No ,32A DP,30mA ELCB
ii Sub I/c - 3 nos ,16A SP MCB -24 numbers 3 No (s) Err:504 Err:504
Err:504
19 UPS (redundant type)
UPS , Battery (Ni-Cd), Battery charger shall be three phase incoming supply with breaker,
1hr back up 415V Input and 415V AC & 110V DC with bypass arrangement.
i 400V,32A,5KVA,AC UPS Panel with Double I/C( ENMCS) 1 Set (s) Err:504 Err:504
ii 400V,32A,5KVA,DC UPS Panel with Double I/C( EMERGENCY LIGHTING) 1 Set (s) Err:504 Err:504
12071429
20 Battery and Battery charger with DCDB(Redundant type)
Battery charger shall be float type. The charger shall be static modular type.Battery shall
be Ni-cd and recombination type & rectifier shall be thyristor controlled bridge
rectifier.Degree of protection shall be IP31.Each battery system shall be provided with
battery isolation circuit breaker mounted within Ee Xd IIC T6 certified enclosure suitable
for Zone 2 environment.It shall be provided with communication protocol for integration
with ENMCS,DCS,FGS and ESD type. It shall be provided with RS 232 communication port
for connection of Personal computer. - 30 min back-up
0.6/1kV Cables shall conform to the latest International standardss. XLPE insulated,plain
annealed copper or Circular tinned stranded Copper, galvanised steel wire armoured,PVC
oversheathed
a Power cables
i 4C x 6 2000 Mtr(s) Err:504 Err:504
ii 4C x 10 200 Mtr(s) Err:504 Err:504
iii 4C x 16 2500 Mtr(s) Err:504 Err:504
iv 4C x 25 3500 Mtr(s) Err:504 Err:504
v 3.5C x 6 10000 Mtr(s) Err:504 Err:504
vi 3.5C x 10 5000 Mtr(s) Err:504 Err:504
vii 3.5C x 16 5200 Mtr(s) Err:504 Err:504
viii 3.5C x 25 8000 Mtr(s) Err:504 Err:504
ix 3.5C x 35 18500 Mtr(s) Err:504 Err:504
x 3.5C x 50 6000 Mtr(s) Err:504 Err:504
xi 3.5C x 70 1000 Mtr(s) Err:504 Err:504
xii 3.5C x 95 3000 Mtr(s) Err:504 Err:504
xiii 3.5C x 120 35000 Mtr(s) Err:504 Err:504
xiv 3.5C x 150 11500 Mtr(s) Err:504 Err:504
xv 3.5C x 185 1500 Mtr(s) Err:504 Err:504
xvi 3.5C x 240 1800 Mtr(s) Err:504 Err:504
xvii 1C x 70 (PEC) 2000 Mtr(s) Err:504 Err:504
159259375
23 LT power cable Terminations
a Glands
i 4C x 6 40 Nos Err:504 Err:504
ii 4C x 10 10 Nos Err:504 Err:504
iii 4C x 16 30 Nos Err:504 Err:504
iv 4C x 25 70 Nos Err:504 Err:504
v 3.5C x 6 60 Nos Err:504 Err:504
vi 3.5C x 10 25 Nos Err:504 Err:504
vii 3.5C x 16 20 Nos Err:504 Err:504
viii 3.5C x 25 15 Nos Err:504 Err:504
ix 3.5C x 35 45 Nos Err:504 Err:504
x 3.5C x 50 20 Nos Err:504 Err:504
xi 3.5C x 70 10 Nos Err:504 Err:504
xii 3.5C x 95 5 Nos Err:504 Err:504
xiii 3.5C x 120 125 Nos Err:504 Err:504
xiv 3.5C x 150 125 Nos Err:504 Err:504
xv 3.5C x 185 15 Nos Err:504 Err:504
xvi 3.5C x 240 70 Nos Err:504 Err:504
xvii 1C x 70 (PEC) 100 Nos Err:504 Err:504
b Lugs - copper
i 4C x 6 150 Nos Err:504 Err:504
ii 4C x 10 30 Nos Err:504 Err:504
iii 4C x 16 100 Nos Err:504 Err:504
27
Project: Petrenos USD MYR
UNIT
TOTAL
DISCOUNTED DISCOUNTED
Sl.No. Equipment Description Qty. Unit SUPPLY PRICE
SUPPLY PRICE (INR)
(INR)
Err:504
27 Supports (steel)
i Supports (steel) for Cable Tray, panel & LPBS 25 Ton 45000 Err:504
Err:504
28 Earthing System
a Earth pits
For TF with necessary accessories for providing and fixing earthing arrangement with
copper earth rod 20mm dia including packing of charcoal powder and salt as per
i specification, water pipe etc. complete with refilling the pit as required, 20 No (s) Err:504 Err:504
For PMCC/ MCC Panel, APFC & UPS with necessary accessories for providing and fixing
earthing arrangement with copper/stainless steel earth electrode including packing of
charcoal powder and salt as per specification, water pipe etc. complete with refilling
ii the pit as required, but excluding the excavation of earth pit. 30 No (s) Err:504 Err:504
28
Project: Petrenos USD MYR
UNIT
TOTAL
DISCOUNTED DISCOUNTED
Sl.No. Equipment Description Qty. Unit SUPPLY PRICE
SUPPLY PRICE (INR)
(INR)
For TF Neutral with necessary accessories for providing and fixing earthing arrangement
with copper earth rod 20mm dia including packing of charcoal powder and salt as per
iii specification, water pipe etc. complete with refilling the pit as required, 20 No (s) Err:504 Err:504
For Plant with necessary accessories for providing and fixing earthing arrangement with
copper earth rod 20mm dia including packing of charcoal powder and salt as per
iv specification, water pipe etc. complete with refilling the pit as required, 25 No (s) Err:504 Err:504
b Cu Flats
i 2 x 150 x 8mm 1500 Mtr(s) Err:504 Err:504
ii 2 x 120 x 8mm 2000 Mtr(s) Err:504 Err:504
iii 2 x 70 x 8mm flat 1000 Mtr(s) Err:504 Err:504
iv 2 x 25 x 3mm 2000 Mtr(s) Err:504 Err:504
v 6 SWG 5000 Mtr(s) Err:504 Err:504
c Earth Busbars
i Various sizes of bus-bars for interconnecting the earthing system 1 Lot Err:504 Err:504
Connectors, joints, bondings,clamps, and all Accessories necessary to complete the
ii earthing system 1 Lot Err:504 Err:504
Err:504
29 Lightning System
Providing and fixing lightning arrangement with 15 mm dia 3 meter long Cu rod, including
packing of charcoal powder and salt as per specification, water pipe 15 mm. dia Cu.
connections etc. complete with refilling the pit as required, but excluding the 3 Nos Err:504 Err:504
excavation of earth pit.
i 3M long lightning spike with all accessories 3 Nos Err:504 Err:504
ii 25x3mm Cu flat (Air terminals, DCs) 200 Mtrs Err:504 Err:504
iii Test links 3 Nos Err:504 Err:504
Connectors, joints, bondings,clamps, and all Accessories necessary to complete the
iv 1 Lot Err:504 Err:504
lighgtning system
Err:504
30 Lighting & Small power system
Light fixtures including all accessories like electronic choke ,starter ,holder,control gear
,fixing accessories like down rod/chain suspender including lamps,connecting
fitting.Luminaries shall be designed for continous trouble free operations. Outdoor shall
be weather proof and rain proof type.
a Indoor Lights
i Surface mounted Industrial type 2 x 36 HF for Control Room, Substation,FAR,OSB 125 Nos Err:504 Err:504
29
Project: Petrenos USD MYR
UNIT
TOTAL
DISCOUNTED DISCOUNTED
Sl.No. Equipment Description Qty. Unit SUPPLY PRICE
SUPPLY PRICE (INR)
(INR)
conduit surface mounted on the roof slab/wall of medium duty GI conduit pipe along
with all required conduit accessories,junction boxes,pull out boxes etc.,25mm. Dia
medium duty conduit pipe for lighting and power circuits.
f
i 25 mm. Dia GI conduit pipe 1200 Mtrs Err:504 Err:504
ii 32 mm. Dia GI conduit pipe 1000 Mtrs Err:504 Err:504
g Lighting & power cables
Indoor lighting circuit/single phase 5A sockets/ceiling fan from DB with 600V grade 1C x
2.5sq.mm. pvc copper FRLS wire (P+N+E) 35000 Mtrs Err:504 Err:504
i
Single phase 15A sockets from DB with 600V grade 3C x 2.5sq.mm. XLPE copper FRLS
wire (P+N+E) 3500 Mtrs Err:504 Err:504
ii
Outdoor lighting circuit from DB with 600V grade 4C x 35sq.mm. XLPE armoured, copper
cable 10000 Mtrs Err:504 Err:504
iii
20A / 32A / 63 A three phase sockets from DB with 600V grade 3.5 x 25 sq.mm. XLPE
copper cable 750 Mtrs Err:504 Err:504
iv
v 4 way junction box of 100 x 100 mm size 150 Nos Err:504 Err:504
vi Ceiling rose 350 Nos Err:504 Err:504
vii Flexible hose of PVC 50mm 500 Mtrs Err:504 Err:504
Err:504
31 Safety equipments as per relevant standards
Safety equipments as per relevant standards and specification 1 Lot Err:504 Err:504
Err:504
32 FAG System
FAG System 0 Lot Err:504 Err:504
Err:504
33 Electrical system studies & softwares
HAZOP, ETAP, Micro-statioN, 3D electrical modelling, Smart Plant Electrical, Lighting Soft
wares, PDMS, ELSOR 1 Lot Err:504 Err:504
Err:504
34 ENMCS system & Others
Electrical Network Monitoring Control System 1 Lot Err:504 Err:504
Man hours cost 1 Lot Err:504 Err:504
Training 20 days Err:504 Err:504
Interface Contractror Lot Err:504 Err:504
Load Shedding Sysem 1 Lot Err:504 Err:504
Taxes & duties 1 Lot Err:504 Err:504
Freight 1 Lot Err:504 Err:504
commissioning of HT panels 5 days Err:504 Err:504
Commissioning of LT panels 10 days Err:504 Err:504
Commissioning of VFD drives HT 0 days Err:504 Err:504
Commissioning of UPS 2 days Err:504 Err:504
Commissioning of Transformer 3 days Err:504 Err:504
30
01/19/2021
Working
Total Type of Calculated
Motor / Feeder Running Low Volt No of Breaker Type of Starting Load per Load on T/F Working on Load on DG
Feeder Name Quantity connected Supply Current in Efficiency PF Load Factor Demand Factor
Load (kW) Load in kW (kV) Phase rating Breaker Method Drive (in (kVA) DG (kVA)
load in kW Voltage Amps Ampacity
kVA)
Appx. Cable Selected Total No. Of for selected
Cable Type No of cores Size in Sq.mm cable size Runs cable
Lead Sheath
working Standby Installed 0.4 1 Y/N insulated Cu.
Conductor
SUBSTATION 631
11kV HV Switchgear
Incomers
Bus 1
Incomer 1 From 11KV Switchgear SB - 622-C-01 1 0 1 5718 5718 4092 HV 11 3 268 1000 VCB DIRECT NA NA NA NA NA NA n 0.00 Lead Sheath insulated Refer
Cu. Conductor 3 240 240 1 catalogue
Bus coupler NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA
Bus 2
Incomer 2 From 11KV Switchgear SB - 622-C-01 1 0 1 5718 5718 4092 HV 11 3 268 1000 VCB DIRECT NA NA NA NA NA NA n 0.00 Lead Sheath insulated Refer
Cu. Conductor 3 240 240 1 catalogue
Outgoings
Bus 1
11/3.45kV 3MVA Transformer 1 Primary 1 0 1 1542 1542 639 HV 11 3 42 630 VCB DIRECT NA NA NA NA NA 600.57869098634 NA NA Lead Sheath insulated Refer
Cu. Conductor 3 240 240 1 catalogue
2.5MVA Transformer 2 Primary 1 0 1 2486 2486 2284 HV 11 3 150 630 VCB DIRECT NA NA NA NA NA 1517.46 n 0.00 Lead Sheath insulated Refer
Cu. Conductor 3 240 240 1 catalogue
2.5MVA Transformer 3 Primary 1 0 1 1691 1691 1170 HV 11 3 77 630 VCB DIRECT NA NA NA NA NA 741.07 n 0.00 Lead Sheath insulated Refer
Cu. Conductor 3 240 240 1 catalogue
BUS 2
11/3.45kV 3MVA Transformer 4 Primary 1 0 1 1542.00 1542.00 639.00 HV 11 3 42 630 VCB DIRECT NA NA NA NA NA 600.57869098634 NA NA Lead Sheath insulated Refer
Cu. Conductor 3 240 240 1 catalogue
2.5MVA Transformer 5 Primary 1 0 1 2485.92 2485.92 2283.51 HV 11 3 150 630 VCB DIRECT NA NA NA NA NA 1517.46 n 0.00 Lead Sheath insulated Refer
Cu. Conductor 3 240 240 1 catalogue
2.5MVA Transformer 6 Primary 1 0 1 1690.55 1690.55 1169.50 HV 11 3 77 630 VCB DIRECT NA NA NA NA NA 741.07 n 0.00 Lead Sheath insulated Refer
Cu. Conductor 3 240 240 1 catalogue
3.3kV HV Switchgear
Incomers
Bus 1
Bus 2
Outgoings
Bus 1
31
01/19/2021
DAF Treated Water transfer pump 1 0 1 132 132.00 132 HV 3.3 3 29 630 VCB DOL 0.95 0.88 157.89 0.80 1.00 126.32 y 126.32 Lead Sheath insulated
Cu. Conductor 3 185 185 19 216
DAF Treated Water transfer pump 0 1 1 132 132.00 0 HV 3.3 3 0 630 VCB DOL 0.95 0.88 0.00 0.80 1.00 0.00 y 0.00 Lead Sheath insulated
Cu. Conductor 3 185 185 19 216
DAF Treated Water transfer pump 0 1 1 132 132.00 0 HV 3.3 3 0 630 VCB DOL 0.95 0.88 0.00 0.80 1.00 0.00 y 0.00 Lead Sheath insulated
Cu. Conductor 3 185 185 19 216
Oxidation air compressor 1 0 1 375 375.00 375 HV 3.3 3 82 630 VCB DOL 0.958 0.9 434.93 0.80 1.00 347.95 y 347.95 Lead Sheath insulated
Cu. Conductor 3 185 185 19 216
BUS 2
DAF Treated Water transfer pump 1 0 1 132 132.00 132 HV 3.3 3 29 630 VCB DOL 0.95 0.88 157.89 0.80 1.00 126.32 y 126.32 Lead Sheath insulated
Cu. Conductor 3 185 185 19 216
DAF Treated Water transfer pump 0 1 1 132 132.00 0 HV 3.3 3 0 630 VCB DOL 0.95 0.88 0.00 0.80 1.00 0.00 y 0.00 Lead Sheath insulated
Cu. Conductor 3 185 185 19 216
DAF Treated Water transfer pump 0 1 1 132 132.00 0 HV 3.3 3 0 630 VCB DOL 0.95 0.88 0.00 0.80 1.00 0.00 y 0.00 Lead Sheath insulated
Cu. Conductor 3 185 185 19 216
Oxidation air compressor 0 1 1 375 375.00 0 HV 3.3 3 0 630 VCB DOL 0.958 0.9 0.00 0.80 1.00 0.00 y 0.00 Lead Sheath insulated
Cu. Conductor 3 185 185 19 216
Incomers
BUS 1
BUS 2
Outgoings - Bus A
MCC-1(Unit 6300) 1 0 1 599.80 599.80 548.90 LV 0.4 3 1089 1250 ACB DIRECT NA NA NA NA NA 240.52 y #REF! Lead Sheath insulated
Cu. Conductor 3.5 240 240 5 252
MCC-2(Unit 6350) 1 0 1 356.12 356.12 337.11 LV 0.4 3 669 800 MCCB DIRECT NA NA NA NA NA 122.71 n #REF! Lead Sheath insulated
Cu. Conductor 3.5 240 240 4 252
400V AC UPS(20KVA) 1 0 1 47 47.00 47 LV 0.4 3 85 125 MCCB DIRECT 0.95 0.85 58.20 1.00 1.00 58.20 y 58.20 Lead Sheath insulated
Cu. Conductor 3.5 70 70 1 126
Battery & Battery Charger 1 0 1 34 34.00 34 LV 0.4 3 61 63 MCCB DIRECT 0.95 0.85 42.11 1.00 1.00 42.11 y 42.11 Lead Sheath insulated
Cu. Conductor 4 25 25 1 72
HVAC Panel 1 0 1 100 100.00 100 LV 0.4 3 180 315 MCCB DIRECT 1 0.85 117.65 1.00 1.00 117.65 y 117.65 Lead Sheath insulated
Cu. Conductor 3.5 150 150 2 194.4
Normal Distribution Panel 1 0 1 120 120.00 120 LV 0.4 3 217 315 MCCB DIRECT 1 0.85 141.18 1.00 1.00 141.18 y 141.18 Lead Sheath insulated
Cu. Conductor 3.5 150 150 2 194.4
Utility Distribution Panel 1 0 1 10 10.00 10 LV 0.4 3 18 315 MCCB DIRECT 1 0.85 11.76 1.00 1.00 11.76 y 11.76 Lead Sheath insulated
Cu. Conductor 3.5 150 150 2 194.4
Static Load 1 0 1 20 20.00 20 LV 0.4 3 36 63 MCCB DIRECT 1 0.85 23.53 1.00 1.00 23.53 y 23.53 Lead Sheath insulated
Cu. Conductor 4 25 25 1 72
Spare 0 1 1 NA NA NA NA NA NA NA 1250 NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA
Bus B
MCC-3(Unit 6300) 1 0 1 795.00 795.00 662.50 LV 0.4 3 1315 1600 ACB DIRECT NA NA NA NA NA 563.26 y 0.00 Lead Sheath insulated
Cu. Conductor 3.5 240 240 7 252
400V AC UPS(100KVA) 1 0 1 14 14.00 14 LV 0.4 3 25 125 MCCB DIRECT 0.95 0.85 17.34 1.00 1.00 17.34 y 17.34 Lead Sheath insulated
Cu. Conductor 3.5 70 70 1 126
HVAC Panel 1 0 1 100 100.00 100 LV 0.4 3 180 315 MCCB DIRECT 1 0.85 117.65 1.00 1.00 117.65 y 117.65 Lead Sheath insulated
Cu. Conductor 3.5 150 150 2 194.4
Utility Distribution Panel 1 0 1 5 5.00 5 LV 0.4 3 9 315 MCCB DIRECT 1 0.85 5.88 1.00 1.00 5.88 y 5.88 Lead Sheath insulated
Cu. Conductor 3.5 150 150 2 194.4
32
01/19/2021
Static Load 1 0 1 20 20.00 20 LV 0.4 3 36 63 MCCB DIRECT 1 0.85 23.53 1.00 1.00 23.53 y 23.53 Lead Sheath insulated
Cu. Conductor 4 25 25 1 72
Spare 0 1 1 NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA
Bus C
Emergency Utility Distribution Panel 1 0 1 5 5.00 5 LV 0.4 3 10 315 MCCB DIRECT 1 0.85 5.88 1.00 0.10 0.59 y #REF! Lead Sheath insulated
Cu. Conductor 3.5 150 150 2 194.4
Emergency Distribution Panel 1 0 1 40 40.00 40 LV 0.4 3 79 315 MCCB DIRECT 1 0.85 47.06 1.00 0.10 4.71 n #REF! Lead Sheath insulated
Cu. Conductor 3.5 150 150 2 194.4
HVAC DB 1 0 1 15 15.00 15 LV 0.4 3 30 315 MCCB DIRECT 1 0.85 17.65 1.00 0.10 1.76 n 0.00 Lead Sheath insulated
Cu. Conductor 3.5 150 150 2 194.4
HVAC DB 1 0 1 15 15.00 15 LV 0.4 3 27 315 MCCB DIRECT 1 0.85 17.65 1.00 0.10 1.76 y 1.76 Lead Sheath insulated
Cu. Conductor 3.5 150 150 2 194.4
400V AC UPS(100KVA) 1 0 1 47 47.00 47 LV 0.4 3 85 125 MCCB DIRECT 0.95 0.85 58.20 1.00 0.10 5.82 y 5.82 Lead Sheath insulated
Cu. Conductor 3.5 70 70 1 126
400V AC UPS(20KVA) 1 0 1 14 14.00 14 LV 0.4 3 25 125 MCCB DIRECT 0.95 0.85 17.34 1.00 0.10 1.73 y 1.73 Lead Sheath insulated
Cu. Conductor 3.5 70 70 1 126
400V AC UPS(100KVA) 1 0 1 47 47.00 47 LV 0.4 3 85 125 MCCB DIRECT 0.95 0.85 58.20 1.00 0.10 5.82 y 5.82 Lead Sheath insulated
Cu. Conductor 3.5 70 70 1 126
400V AC UPS(20KVA) 1 0 1 14 14.00 14 LV 0.4 3 25 125 MCCB DIRECT 0.95 0.85 17.34 1.00 0.10 1.73 y 1.73 Lead Sheath insulated
Cu. Conductor 3.5 70 70 1 126
110V DC UPS(10KVA) 1 0 1 34 34.00 34 LV 0.4 3 61 125 MCCB DIRECT 0.95 0.85 42.11 1.00 0.10 4.21 y 4.21 Lead Sheath insulated
Cu. Conductor 3.5 70 70 1 126
Battery & Battery Charger 1 0 1 34 34.00 34 LV 0.4 3 61 63 MCCB DIRECT 1 0.85 40.00 1.00 0.10 4.00 y 4.00 Lead Sheath insulated
Cu. Conductor 4 25 25 1 72
Spare 0 1 1 NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA
MCC-1(Unit 6300)
Incomers
Incomer From PCC bus 1 1 0 1 599.80 599.80 548.90 LV 0.4 3 1089 1250 ACB DIRECT NA NA NA NA NA NA NA NA
Included
Outgoings
Lead Sheath insulated
Acid dosing pump 1 0 1 45 45.00 45 LV 0.4 3 81 100 MCCB DOL 0.939 0.88 54.46 0.80 0.60 26.14 y 26.14
Cu. Conductor 3 50 50 1 104.4
Acid dosing pump 0 1 1 45 45.00 0 LV 0.4 3 81 100 MCCB DOL 0.939 0.88 0.00 0.80 0.60 0.00 y 0.00 Lead Sheath insulated
Cu. Conductor 3 50 50 1 104.4
Off-spec COC/PW Effluent Tank Mixer 1 0 1 37 37.00 37 LV 0.4 3 67 100 MCCB DOL 0.936 0.88 44.92 0.80 0.60 21.56 y 21.56 Lead Sheath insulated
Cu. Conductor 3 50 150 1 194.4
Off-spec COC/PW Effluent Pump 1 0 1 15 15.00 15 LV 0.4 3 27 32 MCCB DOL 0.918 0.88 18.57 0.80 0.60 8.91 y 8.91 Lead Sheath insulated
Cu. Conductor 3 4 150 1 194.4
Offd spec treated effluent pump 1 0 1 2.2 2.20 2.2 LV 0.4 3 4 32 MCCB DOL 0.864 0.88 2.89 0.80 0.60 1.39 y 1.39 Lead Sheath insulated
Cu. Conductor 3 4 150 1 194.4
Offd spec treated effluent pump 0 1 1 2.2 2.20 0 LV 0.4 3 4 16 MCCB DOL 0.864 0.88 0.00 0.80 0.60 0.00 y 0.00 Lead Sheath insulated
Cu. Conductor 3 4 150 1 194.4
Vent Gas Blower Motor 1 0 1 125 125.00 125 LV 0.4 3 226 250 MCCB DOL 0.95 0.88 149.52 0.80 0.60 71.77 y 71.77 Lead Sheath insulated
Cu. Conductor 3 95 95 2 151.2
Off-spec COC/PW Effluent skimming package 1 0 1 5.5 5.50 5.5 LV 0.4 3 10 16 MCCB DIRECT 0.95 0.85 6.81 0.80 0.60 3.27 y 3.27 Lead Sheath insulated
Cu. Conductor 3.5 10 10 1 43.92
Slop Oil Pump 1 0 1 5.5 5.50 5.5 LV 0.4 3 10 16 MCCB DOL 0.892 0.88 7.01 0.80 0.60 3.36 y 3.36 Lead Sheath insulated
Cu. Conductor 3 16 16 1 56.16
Alkali dosing pump 1 0 1 1.5 1.50 1.5 LV 0.4 3 3 16 MCCB DOL 0.85 0.88 2.01 0.80 0.60 0.96 y 0.96 Lead Sheath insulated
Cu. Conductor 3 25 25 1 72
Alkali dosing pump 0 1 1 1.5 1.50 0 LV 0.4 3 3 16 MCCB DOL 0.85 0.88 0.00 0.80 0.60 0.00 y 0.00 Lead Sheath insulated
Cu. Conductor 3 25 25 1 72
Waste backwash water pumps 1 0 1 2.2 2.20 2.2 LV 0.4 3 4 16 MCCB DOL 0.864 0.88 2.89 0.80 0.60 1.39 y 1.39 Lead Sheath insulated
Cu. Conductor 3 4 4 1 26.64
Waste backwash water pumps 0 1 1 2.2 2.20 0 LV 0.4 3 4 16 MCCB DOL 0.864 0.88 0.00 0.80 0.60 0.00 y 0.00 Lead Sheath insulated
Cu. Conductor 3 4 4 1 26.64
Welding sockets 1 0 1 150 150.00 150 LV 0.4 3 271 315 MCCB DIRECT 1 1 150.00 1.00 0.30 45.00 y 45.00 Lead Sheath insulated
Cu. Conductor 3.5 150 150 2 194.4
Welding sockets 1 0 1 150 150.00 150 LV 0.4 3 271 315 MCCB DIRECT 1 1 150.00 1.00 0.30 45.00 y 45.00 Lead Sheath insulated
Cu. Conductor 3.5 150 150 2 194.4
Spare 1 0 1 1 NA NA NA LV 0.4 3 NA 250 MCCB DOL NA NA NA NA NA NA NA NA NA NA NA NA NA NA
33
01/19/2021
MCC-3(Unit 6300)
Incomers
Incomer From PCC bus 2 1 0 1 795.00 795.00 662.50 LV 0.4 3 1315 1600 ACB DIRECT NA NA NA NA NA NA NA NA
Included
Outgoings
ETP outfal pumps 1 0 1 110 110.00 110 LV 0.4 3 198 200 MCCB DOL 0.952 0.88 131.30 0.80 1.00 105.04 y 105.04 Lead Sheath insulated
Cu. Conductor 3 150 150 2 194.4
ETP outfal pumps 1 0 1 110 110.00 110 LV 0.4 3 198 200 MCCB DOL 0.952 0.88 131.30 0.80 1.00 105.04 y 105.04 Lead Sheath insulated
Cu. Conductor 3 150 150 2 194.4
ETP outfal pumps 1 0 1 110 110.00 110 LV 0.4 3 198 200 MCCB DOL 0.952 0.88 131.30 0.80 1.00 105.04 y 105.04 Lead Sheath insulated
Cu. Conductor 3 150 150 2 194.4
ETP outfal pumps 0 1 1 110 110.00 0 LV 0.4 3 198 200 MCCB DOL 0.952 0.88 0.00 0.80 1.00 0.00 y 0.00 Lead Sheath insulated
Cu. Conductor 3 150 150 2 194.4
ETP ACC collection pumps 1 1 0 1 15 15.00 15 LV 0.4 3 27 32 MCCB DOL 0.918 0.88 18.57 0.80 0.60 8.91 y 8.91 Lead Sheath insulated
Cu. Conductor 3 35 35 1 86.4
ETP ACC collection pumps 1 0 1 1 15 15.00 0 LV 0.4 3 27 32 MCCB DOL 0.918 0.88 0.00 0.80 0.60 0.00 y 0.00 Lead Sheath insulated
Cu. Conductor 3 35 35 1 86.4
ETP ACC collection pumps 2 1 0 1 7.5 7.50 7.5 LV 0.4 3 13.5 16 MCCB DOL 0.9 0.88 9.47 0.80 0.60 4.55 y 4.55 Lead Sheath insulated
Cu. Conductor 3 16 16 1 56.16
ETP ACC collection pumps 2 0 1 1 7.5 7.50 0 LV 0.4 3 13.5 16 MCCB DOL 0.9 0.88 0.00 0.80 0.60 0.00 y 0.00 Lead Sheath insulated
Cu. Conductor 3 16 16 1 56.16
Welding sockets 1 0 1 150 150.00 150 LV 0.4 3 270.6 315 MCCB DIRECT 0.95 0.85 185.76 1.00 0.60 111.46 y 111.46 Lead Sheath insulated
Cu. Conductor 3.5 150 150 2 194.4
Welding sockets 1 0 1 150 150.00 150 LV 0.4 3 270.6 315 MCCB DIRECT 0.95 0.85 185.76 1.00 0.60 111.46 y 111.46 Lead Sheath insulated
Cu. Conductor 3.5 150 150 2 194.4
Incomers
Incomer From PCC bus 1 1 0 1 356.12 356.12 337.11 LV 0.4 3 669 800 MCCB DIRECT NA NA NA NA NA NA NA NA
Included
Outgoings
Receiving pit transfer pumps 1 0 1 3.7 3.70 3.7 LV 0.4 3 7 16 MCCB VSD 0.883 0.88 4.76 0.80 1.00 3.81 n 0.00 Lead Sheath insulated
Cu. Conductor 3 6 6 1 33.84
Receiving pit transfer pumps 1 0 1 3.7 3.70 3.7 LV 0.4 3 7 16 MCCB VSD 0.913 0.88 4.61 0.80 1.00 3.68 n 0.00 Lead Sheath insulated
Cu. Conductor 3 6 6 1 33.84
Receiving pit transfer pumps 0 1 1 3.7 3.70 0 LV 0.4 3 7 16 MCCB VSD 0.913 0.88 0.00 0.80 1.00 0.00 n 0.00 Lead Sheath insulated
Cu. Conductor 3 6 6 1 33.84
Fine screen 1 0 1 2.2 2.20 2.2 LV 0.4 3 4 16 MCCB DOL 0.864 0.88 2.89 0.80 0.60 1.39 n 0.00 Lead Sheath insulated
Cu. Conductor 3 6 6 1 33.84
Fine screen 0 1 1 2.2 2.20 0 LV 0.4 3 4 16 MCCB DOL 0.864 0.88 0.00 0.80 0.60 0.00 n 0.00 Lead Sheath insulated
Cu. Conductor 3 6 6 1 33.84
Receiving Pit Air Extraction Fan Motor 1 0 1 3.7 3.70 3.7 LV 0.4 3 7 16 MCCB DOL 0.913 0.88 4.61 0.80 0.60 2.21 n 0.00 Lead Sheath insulated
Cu. Conductor 3 6 6 1 33.84
Equalization Tank Mixer 1 0 1 2.2 2.20 2.2 LV 0.4 3 4 16 MCCB DOL 0.864 0.88 2.89 0.80 0.60 1.39 n 0.00 Lead Sheath insulated
Cu. Conductor 3 6 6 1 33.84
Equalization Tank Mixer 1 0 1 2.2 2.20 2.2 LV 0.4 3 4 16 MCCB DOL 0.864 0.88 2.89 0.80 0.60 1.39 n 0.00 Lead Sheath insulated
Cu. Conductor 3 6 6 1 33.84
ASP feed pumps 1 0 1 1.1 1.10 1.1 LV 0.4 3 2 16 MCCB VSD 0.838 0.88 1.49 0.80 1.00 1.19 n 0.00 Lead Sheath insulated
Cu. Conductor 3 6 6 1 33.84
ASP feed pumps 1 0 1 1.1 1.10 1.1 LV 0.4 3 2 16 MCCB VSD 0.838 0.88 1.49 0.80 1.00 1.19 n 0.00 Lead Sheath insulated
Cu. Conductor 3 6 6 1 33.84
ASP feed pumps 0 1 1 1.1 1.10 0 LV 0.4 3 2 16 MCCB VSD 0.838 0.88 0.00 0.80 1.00 0.00 n 0.00 Lead Sheath insulated
Cu. Conductor 3 6 6 1 33.84
Blowers 1 0 1 5 5.00 5 LV 0.4 3 9 16 MCCB DOL 0.892 0.88 6.37 0.80 1.00 5.10 n 0.00 Lead Sheath insulated
Cu. Conductor 3 6 6 1 33.84
Blowers 0 1 1 5 5.00 0 LV 0.4 3 9 16 MCCB DOL 0.892 0.88 0.00 0.80 1.00 0.00 n 0.00 Lead Sheath insulated
Cu. Conductor 3 6 6 1 33.84
Clarified Scraper drive 1 0 1 1.1 1.10 1.1 LV 0.4 3 2 16 MCCB DOL 0.838 0.88 1.49 0.80 1.00 1.19 n 0.00 Lead Sheath insulated
Cu. Conductor 3 6 6 1 33.84
Clarified Scraper drive 1 0 1 1.1 1.10 1.1 LV 0.4 3 2 16 MCCB DOL 0.838 0.88 1.49 0.80 1.00 1.19 n 0.00 Lead Sheath insulated
Cu. Conductor 3 6 6 1 33.84
34
01/19/2021
Scum pit pumps 1 0 1 0.75 0.75 0.75 LV 0.4 3 1 16 MCCB DOL 0.838 0.88 1.02 0.80 0.60 0.49 n 0.00 Lead Sheath insulated
Cu. Conductor 3 6 6 1 33.84
Scum pit pumps 1 0 1 0.75 0.75 0.75 LV 0.4 3 1 16 MCCB DOL 0.838 0.88 1.02 0.80 0.60 0.49 n 0.00 Lead Sheath insulated
Cu. Conductor 3 6 6 1 33.84
Sludge Recovery Pump Motor 1 0 1 2.2 2.20 2.2 LV 0.4 3 4 16 MCCB DOL 0.864 0.88 2.89 0.80 1.00 2.31 n 0.00 Lead Sheath insulated
Cu. Conductor 3 6 6 1 33.84
Sludge Recovery Pump Motor 0 1 1 2.2 2.20 0 LV 0.4 3 4 16 MCCB DOL 0.864 0.88 0.00 0.80 1.00 0.00 n 0.00 Lead Sheath insulated
Cu. Conductor 3 6 6 1 33.84
Sodium bicarbonate dosing pump 1 0 1 0.37 0.37 0.37 LV 0.4 3 1 16 MCCB DOL 0.838 0.88 0.75 0.80 1.00 0.45 0.35 0.25 0.15
3 6 6 1 33.84
Sodium bicarbonate dosing pump 0 1 1 0.37 0.37 0 LV 0.4 3 1 16 MCCB DOL 0.838 0.88 0.75 0.80 1.00 0.45 0.35 0.25 0.15
3 6 6 1 33.84
Mixers for above 1 0 1 0.75 0.75 0.75 LV 0.4 3 1 16 MCCB DOL 0.838 0.88 1.02 0.80 1.00 0.81 n 0.00 Lead Sheath insulated
Cu. Conductor 3 6 6 1 33.84
Fecl3 Dosing pumps 1 0 1 0.37 0.37 0.37 LV 0.4 3 1 16 MCCB DOL 0.838 0.88 0.50 0.80 1.00 0.40 n 0.00 Lead Sheath insulated
Cu. Conductor 3 6 6 1 33.84
Fecl3 Dosing pumps 0 1 1 0.37 0.37 0 LV 0.4 3 1 16 MCCB DOL 0.838 0.88 0.00 0.80 1.00 0.00 n 0.00 Lead Sheath insulated
Cu. Conductor 3 6 6 1 33.84
Mixers for above 1 0 1 0.75 0.75 0.75 LV 0.4 3 1 16 MCCB DOL 0.838 0.88 1.02 0.80 1.00 0.81 n 0.00 Lead Sheath insulated
Cu. Conductor 3 6 6 1 33.84
NaOCl dosing pumps 1 0 1 0.37 0.37 0.37 LV 0.4 3 1 16 MCCB DOL 0.838 0.88 0.50 0.80 1.00 0.40 n 0.00 Lead Sheath insulated
Cu. Conductor 3 6 6 1 33.84
NaOCl dosing pumps 0 1 1 0.37 0.37 0 LV 0.4 3 1 16 MCCB DOL 0.838 0.88 0.00 0.80 1.00 0.00 n 0.00 Lead Sheath insulated
Cu. Conductor 3 6 6 1 33.84
Off spec pumps 1 0 1 2.2 2.20 2.2 LV 0.4 3 4 16 MCCB DOL 0.864 0.88 2.89 0.80 0.60 1.39 n 0.00 Lead Sheath insulated
Cu. Conductor 3 6 6 1 33.84
Off spec pumps 0 1 1 2.2 2.20 0 LV 0.4 3 4 16 MCCB DOL 0.864 0.88 0.00 0.80 0.60 0.00 n 0.00 Lead Sheath insulated
Cu. Conductor 3 6 6 1 33.84
Filter screen washing pumps 1 0 1 1.5 1.50 1.5 LV 0.4 3 3 16 MCCB DOL 0.85 0.88 2.01 0.80 0.60 0.96 n 0.00 Lead Sheath insulated
Cu. Conductor 3 6 6 1 33.84
Filter screen washing pumps 0 1 1 1.5 1.50 0 LV 0.4 3 3 16 MCCB DOL 0.85 0.88 0.00 0.80 0.60 0.00 n 0.00 Lead Sheath insulated
Cu. Conductor 3 6 6 1 33.84
Welding sockets 1 0 1 150 150.00 150 LV 0.4 3 271 315 MCCB DIRECT 1 1 150.00 1.00 0.30 45.00 n 0.00 Lead Sheath insulated
Cu. Conductor 3.5 150 150 2 194.4
Welding sockets 1 0 1 150 150.00 150 LV 0.4 3 271 315 MCCB DIRECT 1 1 150.00 1.00 0.30 45.00 n 0.00 Lead Sheath insulated
Cu. Conductor 3.5 150 150 2 194.4
Spare 1 0 1 1 NA NA NA LV 0.4 3 NA 315 MCCB DOL NA NA NA NA NA NA NA NA NA NA NA NA NA NA
Incomers
BUS 1
Bus coupler 1 0 1 NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA
Outgoings - Bus A
MCC-4(Unit 6320) 1 0 1 448.30 448.30 352.40 LV 0.4 3 699 800 ACB DIRECT NA NA NA NA NA 237.01 y #REF! Lead Sheath insulated
Cu. Conductor 3.5 185 185 4 216
MCC-5(Unit 6330) 1 0 1 429.70 429.70 369.50 LV 0.4 3 733 800 ACB DIRECT NA NA NA NA NA 157.89 n 0.00 Lead Sheath insulated
Cu. Conductor 3.5 185 185 4 216
Static Load 1 0 1 20 20.00 20 LV 0.4 3 36 63 MCCB DIRECT 0.95 0.85 24.77 1.00 1.00 24.77 y 24.77 Lead Sheath insulated
Cu. Conductor 4 25 25 1 72
Spare 0 1 1 NA NA NA NA NA NA NA 800 ACB DIRECT NA NA NA NA NA NA y NA NA NA NA NA NA NA
35
01/19/2021
Bus B
MCC-6(Unit 6320) 1 0 1 772.55 772.55 407.60 LV 0.4 3 809 800 ACB DIRECT NA NA NA NA NA 296.63 y #REF! Lead Sheath insulated
Cu. Conductor 3.5 185 185 4 216
Static Load 1 0 1 20 20.00 20 LV 0.4 3 36 63 MCCB DIRECT 0.95 0.85 24.77 1.00 1.00 24.77 y 24.77 Lead Sheath insulated
Cu. Conductor 4 25 25 1 72
Spare 0 1 1 NA NA NA NA NA NA NA 800 ACB DIRECT NA NA NA NA NA NA y NA NA NA NA NA NA NA
MCC-4(Unit 6320)
Incomers
Incomer From PCC bus 1 1 0 1 448.30 448.30 352.40 LV 0.4 3 699 800 ACB DIRECT NA NA NA NA NA NA NA NA
Included
Outgoings
AOC receiving pit skimmer 1 0 1 5.5 5.50 5.5 LV 0.4 3 10 16 MCCB DOL 0.892 0.88 7.01 0.80 1.00 5.61 y 5.61 Lead Sheath insulated
Cu. Conductor 3 4 4 1 26.64
AOC receiving pit pump 1 0 1 45 45.00 45 LV 0.4 3 81 100 MCCB VSD 0.939 0.88 54.46 0.80 1.00 43.57 y 43.57 Lead Sheath insulated
Cu. Conductor 3 50 50 1 104.4
AOC receiving pit pump 1 0 1 45 45.00 45 LV 0.4 3 81 100 MCCB VSD 0.939 0.88 54.46 0.80 1.00 43.57 y 43.57 Lead Sheath insulated
Cu. Conductor 3 50 50 1 104.4
AOC receiving pit pump 0 1 1 45 45.00 0 LV 0.4 3 81 100 MCCB VSD 0.939 0.88 0.00 0.80 1.00 0.00 y 0.00 Lead Sheath insulated
Cu. Conductor 3 50 50 1 104.4
CPI bottom sludge extraction pump 1 0 1 2.2 2.20 2.2 LV 0.4 3 4 16 MCCB DOL 0.864 0.88 2.89 0.80 0.60 1.39 y 1.39 Lead Sheath insulated
Cu. Conductor 3 4 150 1 194.4
CPI bottom sludge extraction pump 1 0 1 2.2 2.20 2.2 LV 0.4 3 4 16 MCCB DOL 0.864 0.88 2.89 0.80 0.60 1.39 y 1.39 Lead Sheath insulated
Cu. Conductor 3 4 150 1 194.4
CPI bottom sludge extraction pump 1 0 1 2.2 2.20 2.2 LV 0.4 3 4 16 MCCB DOL 0.864 0.88 2.89 0.80 0.60 1.39 y 1.39 Lead Sheath insulated
Cu. Conductor 3 4 4 1 26.64
CPI bottom sludge extraction pump 1 0 1 2.2 2.20 2.2 LV 0.4 3 4 16 MCCB DOL 0.864 0.88 2.89 0.80 0.60 1.39 y 1.39 Lead Sheath insulated
Cu. Conductor 3 4 4 1 26.64
CPI bottom sludge extraction pump 1 0 1 2.2 2.20 2.2 LV 0.4 3 4 16 MCCB DOL 0.864 0.88 2.89 0.80 0.60 1.39 y 1.39 Lead Sheath insulated
Cu. Conductor 3 4 4 1 26.64
CPI bottom sludge extraction pump 1 0 1 2.2 2.20 2.2 LV 0.4 3 4 16 MCCB DOL 0.864 0.88 2.89 0.80 0.60 1.39 y 1.39 Lead Sheath insulated
Cu. Conductor 3 4 4 1 26.64
CPI bottom sludge extraction pump 0 1 1 2.2 2.20 0 LV 0.4 3 4 16 MCCB DOL 0.864 0.88 0.00 0.80 0.60 0.00 y 0.00 Lead Sheath insulated
Cu. Conductor 3 4 4 1 26.64
Slop Oil Recovery Pit Pump Motor 1 0 1 3.7 3.70 3.7 LV 0.4 3 7 16 MCCB DOL 0.883 0.88 4.76 0.80 1.00 3.81 y 3.81 Lead Sheath insulated
Cu. Conductor 3 4 4 1 26.64
Slop Oil Recovery Pit Pump Motor 0 1 1 3.7 3.70 0 LV 0.4 3 7 16 MCCB DOL 0.883 0.88 0.00 0.80 1.00 0.00 y 0.00 Lead Sheath insulated
Cu. Conductor 3 4 4 1 26.64
DAF Feed Pump Motor 1 0 1 45 45.00 45 LV 0.4 3 81.2 100 MCCB VSD 0.939 0.88 54.46 0.80 1.00 43.57 y 43.57 Lead Sheath insulated
Cu. Conductor 3 50 50 1 104.4
DAF Feed Pump Motor 1 0 1 45 45.00 45 LV 0.4 3 81 100 MCCB VSD 0.939 0.88 54.46 0.80 1.00 43.57 y 43.57 Lead Sheath insulated
Cu. Conductor 3 50 50 1 104.4
DAF Feed Pump Motor 0 1 1 45 45.00 0 LV 0.4 3 81.2 100 MCCB VSD 0.939 0.88 0.00 0.80 1.00 0.00 y 0.00 Lead Sheath insulated
Cu. Conductor 3 50 50 1 104.4
Power & Welding sockets 1 0 1 150 150.00 150 LV 0.4 3 271 315 MCCB DIRECT 1 1 150.00 1.00 0.30 45.00 y 45.00 Lead Sheath insulated
Cu. Conductor 3.5 150 150 2 194.4
Spare 1 0 1 1 NA NA NA LV 0.4 3 NA 315 MCCB DIRECT NA NA NA NA NA NA NA NA NA NA NA NA NA NA
MCC-6(Unit 6320)
Incomers
Incomer From PCC bus 2 1 0 1 772.55 772.55 407.60 LV 0.4 3 809 800 ACB DIRECT NA NA NA NA NA NA NA NA
Included
Outgoings
pH adjustment/coagulant tank mixer 1 0 1 1.5 1.50 1.5 LV 0.4 3 3 16 MCCB DOL 0.85 0.88 2.01 0.80 1.00 1.60 y 1.60 Lead Sheath insulated
Cu. Conductor 3 4 4 1 26.64
pH adjustment/coagulant tank mixer 1 0 1 1.5 1.50 1.5 LV 0.4 3 3 16 MCCB DOL 0.85 0.88 2.01 0.80 1.00 1.60 y 1.60 Lead Sheath insulated
Cu. Conductor 3 4 4 1 26.64
pH adjustment/coagulant tank mixer 0 1 1 1.5 1.50 0 LV 0.4 3 3 16 MCCB DOL 0.85 0.88 0.00 0.80 1.00 0.00 y 0.00 Lead Sheath insulated
Cu. Conductor 3 4 4 1 26.64
Flocculation tank mixer 1 0 1 3.7 3.70 3.7 LV 0.4 3 7 16 MCCB DOL 0.883 0.88 4.76 0.80 1.00 3.81 y 3.81 Lead Sheath insulated
Cu. Conductor 3 10 10 1 43.92
36
01/19/2021
Flocculation tank mixer 1 0 1 3.7 3.70 3.7 LV 0.4 3 7 16 MCCB DOL 0.883 0.88 4.76 0.80 1.00 3.81 y 3.81 Lead Sheath insulated
Cu. Conductor 3 10 10 1 43.92
Flocculation tank mixer 0 1 1 3.7 3.70 0 LV 0.4 3 7 16 MCCB DOL 0.883 0.88 0.00 0.80 1.00 0.00 y 0.00 Lead Sheath insulated
Cu. Conductor 3 10 10 1 43.92
Carriage drive motor 1 0 1 1.5 1.50 1.5 LV 0.4 3 3 16 MCCB DOL 0.85 0.88 2.01 0.80 1.00 1.60 y 1.60 Lead Sheath insulated
Cu. Conductor 3 4 4 1 26.64
Carriage drive motor 1 0 1 1.5 1.50 1.5 LV 0.4 3 3 16 MCCB DOL 0.85 0.88 2.01 0.80 1.00 1.60 y 1.60 Lead Sheath insulated
Cu. Conductor 3 4 4 1 26.64
Carriage drive motor 0 1 1 1.5 1.50 0 LV 0.4 3 3 16 MCCB DOL 0.85 0.88 0.00 0.80 1.00 0.00 y 0.00 Lead Sheath insulated
Cu. Conductor 3 4 4 1 26.64
Spiral sccop drive motor 1 0 1 1.5 1.50 1.5 LV 0.4 3 3 16 MCCB DOL 0.85 0.88 2.01 0.80 1.00 1.60 y 1.60 Lead Sheath insulated
Cu. Conductor 3 4 4 1 26.64
Spiral sccop drive motor 1 0 1 1.5 1.50 1.5 LV 0.4 3 3 16 MCCB DOL 0.85 0.88 2.01 0.80 1.00 1.60 y 1.60 Lead Sheath insulated
Cu. Conductor 3 4 4 1 26.64
Spiral sccop drive motor 0 1 1 1.5 1.50 0 LV 0.4 3 3 16 MCCB DOL 0.85 0.88 0.00 0.80 1.00 0.00 y 0.00 Lead Sheath insulated
Cu. Conductor 3 4 4 1 26.64
DAF recirculation pump 1 0 1 75 75.00 75 LV 0.4 3 135 160 MCCB VSD 0.947 0.88 90.00 0.80 1.00 72.00 y 72.00 Lead Sheath insulated
Cu. Conductor 3 185 185 1 216
DAF recirculation pump 1 0 1 75 75.00 75 LV 0.4 3 135 160 MCCB VSD 0.947 0.88 90.00 0.80 1.00 72.00 y 72.00 Lead Sheath insulated
Cu. Conductor 3 185 185 1 216
DAF recirculation pump 0 1 1 75 75.00 0 LV 0.4 3 135 160 MCCB VSD 0.947 0.88 0.00 0.80 1.00 0.00 y 0.00 Lead Sheath insulated
Cu. Conductor 3 185 185 1 216
DAF recirculation pump 0 1 1 75 75.00 0 LV 0.4 3 135 160 MCCB VSD 0.947 0.88 0.00 0.80 1.00 0.00 y 0.00 Lead Sheath insulated
Cu. Conductor 3 185 185 1 216
DAF recirculation pump 0 1 1 75 75.00 0 LV 0.4 3 135 160 MCCB VSD 0.947 0.88 0.00 0.80 1.00 0.00 y 0.00 Lead Sheath insulated
Cu. Conductor 3 185 185 1 216
DAF recirculation pump 0 1 1 75 75.00 0 LV 0.4 3 135 160 MCCB VSD 0.947 0.88 0.00 0.80 1.00 0.00 y 0.00 Lead Sheath insulated
Cu. Conductor 3 185 185 1 216
DAF Sludge pit mixer 1 0 1 0.75 0.75 0.75 LV 0.4 3 1 16 MCCB DOL 0.85 0.88 1.00 0.80 1.00 0.80 y 0.80 Lead Sheath insulated
Cu. Conductor 3 4 4 1 26.64
DAF sludge pit pump 1 0 1 11 11.00 11 LV 0.4 3 20 32 MCCB VSD 0.91 0.88 13.74 0.80 1.00 10.99 y 10.99 Lead Sheath insulated
Cu. Conductor 3 25 25 1 72
DAF sludge pit pump 0 1 1 11 11.00 0 LV 0.4 3 20 32 MCCB VSD 0.91 0.88 0.00 0.80 1.00 0.00 y 0.00 Lead Sheath insulated
Cu. Conductor 3 25 25 1 72
Self Cleaning Media Filter 1 0 1 3.7 3.70 3.7 LV 0.4 3 7 16 MCCB DOL 0.883 0.88 4.76 0.80 1.00 3.81 y 3.81 Lead Sheath insulated
Cu. Conductor 3 10 10 1 43.92
Self Cleaning Media Filter 0 1 1 3.7 3.70 0 LV 0.4 3 6.7 16 MCCB DOL 0.883 0.88 0.00 0.80 1.00 0.00 y 0.00 Lead Sheath insulated
Cu. Conductor 3 10 10 1 43.92
ETP Service Water Pump Motor 1 0 1 30 30.00 30 LV 0.4 3 54 63 MCCB DOL 0.932 0.88 36.58 0.80 1.00 29.26 y 29.26 Lead Sheath insulated
Cu. Conductor 3 25 25 1 72
ETP Service Water Pump Motor 1 0 1 30 30.00 30 LV 0.4 3 54.1 63 MCCB DOL 0.932 0.88 36.58 0.80 1.00 29.26 y 29.26 Lead Sheath insulated
Cu. Conductor 3 25 25 1 72
ETP Service Water Pump Motor 0 1 1 30 30.00 0 LV 0.4 3 54 63 MCCB DOL 0.932 0.88 0.00 0.80 1.00 0.00 y 0.00 Lead Sheath insulated
Cu. Conductor 3 25 25 1 72
Backwash waste water pump 1 0 1 9.3 9.30 9.3 LV 0.4 3 17 32 MCCB VSD 0.91 0.88 11.61 0.80 1.00 9.29 y 9.29 Lead Sheath insulated
Cu. Conductor 3 6 6 1 33.84
Backwash waste water pump 0 1 1 9.3 9.30 0 LV 0.4 3 17 32 MCCB VSD 0.91 0.88 0.00 0.80 1.00 0.00 y 0.00 Lead Sheath insulated
Cu. Conductor 3 6 6 1 33.84
Coagulation dosing pump 1 0 1 0.55 0.55 0.55 LV 0.4 3 1 16 MCCB DOL 0.838 0.88 0.75 0.80 1.00 0.60 y 0.60 Lead Sheath insulated
Cu. Conductor 3 4 4 1 26.64
Coagulation dosing pump 1 0 1 0.55 0.55 0.55 LV 0.4 3 1 16 MCCB DOL 0.838 0.88 0.75 0.80 1.00 0.60 y 0.60 Lead Sheath insulated
Cu. Conductor 3 4 4 1 26.64
Coagulation dosing pump 0 1 1 0.55 0.55 0 LV 0.4 3 1 16 MCCB DOL 0.838 0.88 0.00 0.80 1.00 0.00 y 0.00 Lead Sheath insulated
Cu. Conductor 3 4 4 1 26.64
Flocculant dosing pump 1 0 1 0.55 0.55 0.55 LV 0.4 3 1 16 MCCB DOL 0.838 0.88 0.75 0.80 1.00 0.60 y 0.60 Lead Sheath insulated
Cu. Conductor 3 4 4 1 26.64
Flocculant dosing pump 1 0 1 0.55 0.55 0.55 LV 0.4 3 1 16 MCCB DOL 0.838 0.88 0.75 0.80 1.00 0.60 y 0.60 Lead Sheath insulated
Cu. Conductor 3 4 4 1 26.64
Flocculant dosing pump 0 1 1 0.55 0.55 0 LV 0.4 3 1 16 MCCB DOL 0.838 0.88 0.00 0.80 1.00 0.00 y 0.00 Lead Sheath insulated
Cu. Conductor 3 4 4 1 26.64
Flocculant dosing tank feeder 1 0 1 1.5 1.50 1.5 LV 0.4 3 3 16 MCCB DIRECT 0.85 0.88 2.01 0.80 1.00 1.60 y 1.60 Lead Sheath insulated
Cu. Conductor 3.5 4 150 1 194.4
Acid dosing pump 1 0 1 0.55 0.55 0.55 LV 0.4 3 1 16 MCCB DOL 0.838 0.88 0.75 0.80 1.00 0.60 y 0.60 Lead Sheath insulated
Cu. Conductor 3 4 4 1 26.64
Acid dosing pump 1 0 1 0.55 0.55 0.55 LV 0.4 3 1 16 MCCB DOL 0.838 0.88 0.75 0.80 1.00 0.60 y 0.60 Lead Sheath insulated
Cu. Conductor 3 4 4 1 26.64
Acid dosing pump 0 1 1 0.55 0.55 0 LV 0.4 3 1 16 MCCB DOL 0.838 0.88 0.00 0.80 1.00 0.00 y 0.00 Lead Sheath insulated
Cu. Conductor 3 4 4 1 26.64
Caustic Soda dosing pump 1 0 1 0.55 0.55 0.55 LV 0.4 3 1 16 MCCB DOL 0.838 0.88 0.75 0.80 1.00 0.60 y 0.60 Lead Sheath insulated
Cu. Conductor 3 4 4 1 26.64
37
01/19/2021
Caustic Soda dosing pump 1 0 1 0.55 0.55 0.55 LV 0.4 3 1 16 MCCB DOL 0.838 0.88 0.75 0.80 1.00 0.60 y 0.60 Lead Sheath insulated
Cu. Conductor 3 4 4 1 26.64
Caustic Soda dosing pump 0 1 1 0.55 0.55 0 LV 0.4 3 1 16 MCCB DOL 0.838 0.88 0.00 0.80 1.00 0.00 y 0.00 Lead Sheath insulated
Cu. Conductor 3 4 4 1 26.64
Biocide dosing pump 1 0 1 0.55 0.55 0.55 LV 0.4 3 1.0 16 MCCB DOL 0.838 0.88 0.75 0.80 1.00 0.60 y 0.60 Lead Sheath insulated
Cu. Conductor 3 4 4 1 26.64
Biocide dosing pump 0 1 1 0.55 0.55 0 LV 0.4 3 1 16 MCCB DOL 0.838 0.88 0.00 0.80 1.00 0.00 y 0.00 Lead Sheath insulated
Cu. Conductor 3 4 4 1 26.64
Power & Welding sockets 1 0 1 150 150.00 150 LV 0.4 3 270.6 315 MCCB DIRECT 1 1 150.00 1.00 0.30 45.00 y 45.00 Lead Sheath insulated
Cu. Conductor 3.5 150 150 2 194.4
Spare 1 0 1 1 NA NA NA LV 0.4 3 NA 315 MCCB DIRECT NA NA NA NA NA NA NA NA
NA NA NA NA NA NA
MCC-5(Unit 6330)
Incomers
Incomer From PCC bus 1 1 0 1 429.70 429.70 369.50 LV 0.4 3 733 800 ACB DIRECT NA NA NA NA NA NA NA NA
Included
Outgoings
High pressure feed pump 1 0 1 55 55.00 55 LV 0.4 3 99 100 MCCB DOL 0.942 0.88 66.35 0.80 1.00 53.08 y 53.08 Lead Sheath insulated
Cu. Conductor 3 50 50 1 104.4
High pressure feed pump 0 1 1 55 55.00 0 LV 0.4 3 99 100 MCCB DOL 0.942 0.88 0.00 0.80 1.00 0.00 y 0.00 Lead Sheath insulated
Cu. Conductor 3 50 50 1 104.4
Scrubber pump 1 0 1 2.2 2.20 2.2 LV 0.4 3 4 16 MCCB DOL 0.864 0.88 2.89 0.80 1.00 2.31 y 2.31 Lead Sheath insulated
Cu. Conductor 3 4 4 1 26.64
Scrubber pump 0 1 1 2.2 2.20 0 LV 0.4 3 4 16 MCCB DOL 0.864 0.88 0.00 0.80 1.00 0.00 y 0.00 Lead Sheath insulated
Cu. Conductor 3 4 4 1 26.64
1st stage acid pump 1 0 1 1.5 1.50 1.5 LV 0.4 3 3 16 MCCB VSD 0.85 0.88 2.01 0.80 1.00 1.60 y 1.60 Lead Sheath insulated
Cu. Conductor 3 4 150 1 194.4
1st stage acid pump 0 1 1 1.5 1.50 0 LV 0.4 3 3 16 MCCB VSD 0.85 0.88 0.00 0.80 1.00 0.00 y 0.00 Lead Sheath insulated
Cu. Conductor 3 4 150 1 194.4
2nd stage acid pump 1 0 1 1.5 1.50 1.5 LV 0.4 3 3 16 MCCB VSD 0.85 0.88 2.01 0.80 1.00 1.60 y 1.60 Lead Sheath insulated
Cu. Conductor 3 4 4 1 26.64
2nd stage acid pump 0 1 1 1.5 1.50 0 LV 0.4 3 3 16 MCCB VSD 0.85 0.88 0.00 0.80 1.00 0.00 y 0.00 Lead Sheath insulated
Cu. Conductor 3 4 4 1 26.64
Agitator in spent caustic feed tank 1 0 1 9.3 9.30 9.3 LV 0.4 3 17 32 MCCB DOL 0.91 0.88 11.61 0.80 1.00 9.29 y 9.29 Lead Sheath insulated
Cu. Conductor 3 16 16 1 56.16
Power & Welding sockets 1 0 1 150 150.00 150 LV 0.4 3 271 315 MCCB DIRECT 1 1 150.00 1.00 0.30 45.00 y 45.00 Lead Sheath insulated
Cu. Conductor 3.5 150 150 2 194.4
Power & Welding sockets 1 0 1 150 150.00 150 LV 0.4 3 271 315 MCCB DIRECT 1 1 150.00 1.00 0.30 45.00 y 45.00 Lead Sheath insulated
Cu. Conductor 3.5 150 150 2 194.4
SUBSTATION 632
11kV HV Switchgear
Incomers
Bus 1
Incomer 1 From 11KV Switchgear SB - 622-C-01 1 0 1 6571 6571 4714 HV 11 3 309 800 VCB DIRECT NA NA NA NA NA NA n 0.00 Lead Sheath insulated Refer
Cu. Conductor 3 240 240 1 catalogue
Bus 2
38
01/19/2021
Incomer 2 From 11KV Switchgear SB - 622-C-01 1 0 1 6571 6571 4714 HV 11 3 309 800 VCB DIRECT NA NA NA NA NA NA n 0.00 Lead Sheath insulated Refer
Cu. Conductor 3 240 240 1 catalogue
Outgoings
Bus 1
11/3.45kV 5MVA Transformer 1 Primary 1 0 1 2910 2910 2120 HV 11 3 139 630 VCB DIRECT NA NA NA NA NA 2275.94 NA NA
NA NA NA NA NA NA
2.5MVA Transformer 2 Primary 1 0 1 1604 1604 1189 HV 11 3 78 630 VCB DIRECT NA NA NA NA NA 1047.61 n 0.00 Lead Sheath insulated Refer
Cu. Conductor 3 240 240 1 catalogue
2.5MVA Transformer 3 Primary 1 0 1 1539 1539 946 HV 11 3 62 630 VCB DIRECT NA NA NA NA NA 827.22 n 0.00 Lead Sheath insulated Refer
Cu. Conductor 3 240 240 1 catalogue
2.5MVA Transformer 4 Primary 1 0 1 519 519 458 HV 11 3 30 630 VCB DIRECT NA NA NA NA NA 251.23 n 0.00 Lead Sheath insulated Refer
Cu. Conductor 3 240 240 1 catalogue
BUS 2
11/3.45kV 5MVA Transformer 5 Primary 1 0 1 2910.00 2910.00 2120.00 HV 11 3 139 630 VCB DIRECT NA NA NA NA NA 2275.94 NA NA
NA NA NA NA NA NA
2.5MVA Transformer 6 Primary 1 0 1 1603.94 1603.94 1189.26 HV 11 3 78 630 VCB DIRECT NA NA NA NA NA 1047.61 n 0.00 Lead Sheath insulated Refer
Cu. Conductor 3 240 240 1 catalogue
2.5MVA Transformer 7 Primary 1 0 1 1538.50 1538.50 946.20 HV 11 3 62 630 VCB DIRECT NA NA NA NA NA 827.22 n 0.00 Lead Sheath insulated Refer
Cu. Conductor 3 240 240 1 catalogue
2.5MVA Transformer 8 Primary 1 0 1 518.94 518.94 458.47 HV 11 3 30 630 VCB DIRECT NA NA NA NA NA 251.23 NA NA
NA NA NA NA NA NA
3.3kV HV Switchgear
Incomers
Bus 1
Bus 2
Bus 3
Outgoings
Bus 1
Aerobic Basin Air Blower Motor 1 0 1 160 160.00 160 HV 3.3 3 35 630 VCB DOL 0.943 0.88 192.81 0.8 0.8 123.40 n 0.00 Lead Sheath insulated
Cu. Conductor 3 240 240 19 252
Aerobic Basin Air Blower Motor 1 0 1 160 160.00 160 HV 3.3 3 35 630 VCB DOL 0.943 0.88 192.81 0.8 0.8 123.40 NA NA Lead Sheath insulated
Cu. Conductor 3 240 240 19 252
Aerobic Basin Air Blower Motor 0 1 1 160 160.00 0 HV 3.3 3 0 630 VCB DOL 0.943 0.88 0.00 0.8 0.8 0.00 n 0.00 Lead Sheath insulated
Cu. Conductor 3 240 240 19 252
Aerobic Basin Air Blower Motor 0 1 1 160 160.00 0 HV 3.3 3 0 630 VCB DOL 0.943 0.88 0.00 0.8 0.8 0.00 n 0.00 Lead Sheath insulated
Cu. Conductor 3 240 240 19 252
Off spec treated COC/PW pumps 1 0 1 160 160.00 160 HV 3.3 3 35 630 VCB DOL 0.943 0.88 192.81 0.8 0.6 92.55 NA NA Lead Sheath insulated
Cu. Conductor 3 240 240 19 252
CPI & DAF ASP low temperature sludge dryers 1 0 1 660 660.00 660 HV 3.3 3 144 630 VCB DOL 0.962 0.91 753.92 0.8 1 603.14 NA NA Lead Sheath insulated
Cu. Conductor 3 240 240 19 252
39
01/19/2021
BUS 2
Aerobic Basin Air Blower Motor 1 0 1 160 160.00 160 HV 3.3 3 35 630 VCB DOL 0.956 0.88 190.19 0.8 0.8 121.72 n 0.00 Lead Sheath insulated
Cu. Conductor 3 240 240 19 252
Aerobic Basin Air Blower Motor 1 0 1 160 160.00 160 HV 3.3 3 35 630 VCB DOL 0.956 0.88 190.19 0.8 0.8 121.72 NA NA Lead Sheath insulated
Cu. Conductor 3 240 240 19 252
Aerobic Basin Air Blower Motor 0 1 1 160 160.00 0 HV 3.3 3 0 630 VCB DOL 0.956 0.88 0.00 0.8 0.8 0.00 n 0.00 Lead Sheath insulated
Cu. Conductor 3 240 240 19 252
Aerobic Basin Air Blower Motor 0 1 1 160 160.00 0 HV 3.3 3 0 630 VCB DOL 0.956 0.88 0.00 0.8 0.8 0.00 n 0.00 Lead Sheath insulated
Cu. Conductor 3 240 240 19 252
Off spec treated COC/PW pumps 0 1 1 150 150.00 0 HV 3.3 3 0 630 VCB DOL 0.956 0.88 0.00 0.8 0.6 0.00 NA NA Lead Sheath insulated
Cu. Conductor 3 240 240 19 252
CPI & DAF ASP low temperature sludge dryers 1 0 1 660 660.00 660 HV 3.3 3 144 630 VCB DOL 0.962 0.91 753.92 0.8 1 603.14 NA NA Lead Sheath insulated
Cu. Conductor 3 240 240 19 252
Spare 0 1 1 NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA
Spare 0 1 1 NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA
Space 0 1 1 NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA
BUS 3
Aerobic Basin Air Blower Motor 1 0 1 160 160.00 160 HV 3.3 3 35 630 VCB DOL 0.956 0.88 190.19 0.8 0.8 121.72 n 0.00 Lead Sheath insulated
Cu. Conductor 3 240 240 19 252
Aerobic Basin Air Blower Motor 1 0 1 160 160.00 160 HV 3.3 3 35 630 VCB DOL 0.956 0.88 190.19 0.8 0.8 121.72 NA NA Lead Sheath insulated
Cu. Conductor 3 240 240 19 252
Aerobic Basin Air Blower Motor 1 0 1 160 160.00 160 HV 3.3 3 35 630 VCB DOL 0.956 0.88 190.19 0.8 0.8 121.72 n 0.00 Lead Sheath insulated
Cu. Conductor 3 240 240 19 252
Aerobic Basin Air Blower Motor 1 0 1 160 160.00 160 HV 3.3 3 35 630 VCB DOL 0.956 0.88 190.19 0.8 0.8 121.72 n 0.00 Lead Sheath insulated
Cu. Conductor 3 240 240 19 252
Space 0 1 1 NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA
PCC-6340
Incomers
BUS 1
Bus coupler 1 0 1 NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA
BUS 2
Bus coupler 1 0 1 NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA
BUS 3
Outgoings - Bus A
MCC-1(Unit 6340) 1 0 1 531.84 531.84 331.06 LV 0.4 3 657 800 ACB DIRECT NA NA NA NA NA 319.22 y #REF! Lead Sheath insulated
Cu. Conductor 3.5 240 240 4 252
400V AC UPS 1 0 1 10 10.00 10 LV 0.4 3 18 125 MCCB DIRECT 0.95 0.85 12.38 1.00 1.00 12.38 y 12.38 Lead Sheath insulated
Cu. Conductor 3.5 70 70 1 126
400V AC UPS 1 0 1 10 10.00 10 LV 0.4 3 18 125 MCCB DIRECT 0.95 0.85 12.38 1.00 1.00 12.38 y 12.38 Lead Sheath insulated
Cu. Conductor 3.5 70 70 1 126
Battery & Battery Charger 1 0 1 34 34.00 34 LV 0.4 3 61 63 MCCB DIRECT 0.95 0.85 42.11 1.00 1.00 42.11 y 42.11 Lead Sheath insulated
Cu. Conductor 4 25 25 1 72
HVAC Panel 1 0 1 100 100.00 100 LV 0.4 3 180 315 MCCB DIRECT 0.95 0.85 123.84 1.00 1.00 123.84 y 123.84 Lead Sheath insulated
Cu. Conductor 3.5 150 150 2 194.4
Normal Distribution Panel 1 0 1 80 80.00 80 LV 0.4 3 144 315 MCCB DIRECT 0.95 0.85 99.07 1.00 1.00 99.07 y 99.07 Lead Sheath insulated
Cu. Conductor 3.5 150 150 2 194.4
Welding sockets 1 0 1 150 150.00 150 LV 0.4 3 271 315 MCCB DIRECT 1 1 150.00 1.00 0.30 45.00 y 45.00 Lead Sheath insulated
Cu. Conductor 3.5 150 150 2 194.4
Utility Distribution Panel 1 0 1 10 10.00 10 LV 0.4 3 18 315 MCCB DIRECT 0.95 0.85 12.38 1.00 1.00 12.38 y 12.38 Lead Sheath insulated
Cu. Conductor 3.5 150 150 2 194.4
40
01/19/2021
Static Load 1 0 1 20 20.00 20 LV 0.4 3 36 63 MCCB DIRECT 0.95 0.85 24.77 1.00 1.00 24.77 y 24.77 Lead Sheath insulated
Cu. Conductor 4 25 25 1 72
Spare 0 1 1 NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA
Spare 0 1 1 NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA
Space 0 1 1 NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA
Bus B
MCC-2(Unit 6340) 1 0 1 484.30 484.30 270.40 LV 0.4 3 537 630 ACB DIRECT NA NA NA NA NA 250.77 y #REF! Lead Sheath insulated
Cu. Conductor 3.5 240 240 3 252
Utility Distribution Panel 1 0 1 5 5.00 5 LV 0.4 3 9 32 MCCB DIRECT 0.95 0.85 6.19 1.00 1.00 6.19 y 6.19 Lead Sheath insulated
Cu. Conductor 4 25 25 1 72
Static Load 1 0 1 20 20.00 20 LV 0.4 3 36 63 MCCB DIRECT 0.95 0.85 24.77 1.00 1.00 24.77 y 24.77 Lead Sheath insulated
Cu. Conductor 4 25 25 1 72
Spare 0 1 1 NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA
Space 0 1 1 NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA
Bus C
MCC - 6340(Emergency) 1 0 1 64.80 64.80 64.80 LV 0.4 3 129 160 MCCB DIRECT 0.95 0.85 80.25 1 0.1 64.32 y #REF! Lead Sheath insulated
Cu. Conductor 3.5 150 150 1 194.4
Emergency Utility Distribution Panel 1 0 1 5 5.00 5 LV 0.4 3 10 315 MCCB DIRECT 0.95 0.85 6.19 1 0.1 0.62 y #REF! Lead Sheath insulated
Cu. Conductor 3.5 150 150 2 194.4
Emergency Distribution Panel 1 0 1 30 30.00 30 LV 0.4 3 60 315 MCCB DIRECT 0.95 0.85 37.15 1 0.1 3.72 n #REF! Lead Sheath insulated
Cu. Conductor 3.5 150 150 2 194.4
HVAC DB 1 0 1 15 15.00 15 LV 0.4 3 30 315 MCCB DIRECT 0.95 0.85 18.58 1 0.1 1.86 n 0.00 Lead Sheath insulated
Cu. Conductor 3.5 150 150 2 194.4
Battery & Battery Charger 1 0 1 34 34.00 34 LV 0.4 3 61 63 MCCB DIRECT 0.95 0.85 42.11 1 0.1 4.21 y 4.21 Lead Sheath insulated
Cu. Conductor 4 25 25 1 72
Spare 0 1 1 NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA
Spare 0 1 1 NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA
Space 0 1 1 NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA
MCC-1(Unit 6340)
Incomers
Incomer From PCC bus 1 1 0 1 531.84 531.84 331.06 LV 0.4 3 657 800 ACB DIRECT NA NA NA NA NA NA NA NA
Included
Outgoings
Oil skimmer drive 1 0 1 7.5 7.50 7.5 LV 0.4 3 14 16 MCCB DOL 0.901 0.88 9.46 0.80 1.00 7.57 y 7.57 Lead Sheath insulated
Cu. Conductor 3 6 6 1 33.84
Recceiving pit transfer pumps 1 0 1 18.5 18.50 18.5 LV 0.4 3 33 63 MCCB VSD 0.922 0.88 22.80 0.80 1.00 18.24 y 18.24 Lead Sheath insulated
Cu. Conductor 3 25 25 2 72
Recceiving pit transfer pumps 1 0 1 18.5 18.50 18.5 LV 0.4 3 33 63 MCCB VSD 0.922 0.88 22.80 0.80 1.00 18.24 y 18.24 Lead Sheath insulated
Cu. Conductor 3 25 25 2 72
Recceiving pit transfer pumps 0 1 1 18.5 18.50 0 LV 0.4 3 33 63 MCCB VSD 0.922 0.88 0.00 0.80 1.00 0.00 y 0.00 Lead Sheath insulated
Cu. Conductor 3 25 25 2 72
Oil skimmer - CPI cell 1 0 1 3.7 3.70 3.7 LV 0.4 3 7 16 MCCB DOL 0.883 0.88 4.76 0.80 1.00 3.81 y 3.81 Lead Sheath insulated
Cu. Conductor 3 6 6 1 33.84
Oil skimmer - CPI cell 1 0 1 3.7 3.70 3.7 LV 0.4 3 7 16 MCCB DOL 0.883 0.88 4.76 0.80 1.00 3.81 y 3.81 Lead Sheath insulated
Cu. Conductor 3 6 6 1 33.84
Oil skimmer - CPI cell 1 0 1 3.7 3.70 3.7 LV 0.4 3 7 16 MCCB DOL 0.883 0.88 4.76 0.80 1.00 3.81 y 3.81 Lead Sheath insulated
Cu. Conductor 3 6 6 1 33.84
Oil skimmer - CPI cell 0 1 1 3.7 3.70 0 LV 0.4 3 7 16 MCCB DOL 0.883 0.88 0.00 0.80 1.00 0.00 y 0.00 Lead Sheath insulated
Cu. Conductor 3 6 6 1 33.84
Slop Oil Recovery Pit Pump Motor 1 0 1 3.7 3.70 3.7 LV 0.4 3 7 16 MCCB DOL 0.883 0.88 4.76 0.80 1.00 3.81 y 3.81 Lead Sheath insulated
Cu. Conductor 3 10 10 1 43.92
Slop Oil Recovery Pit Pump Motor 0 1 1 3.7 3.70 0 LV 0.4 3 7 16 MCCB DOL 0.883 0.88 0.00 0.80 1.00 0.00 y 0.00 Lead Sheath insulated
Cu. Conductor 3 10 10 1 43.92
CPI Sludge pumps 1 0 1 3.7 3.70 3.7 LV 0.4 3 7 16 MCCB DOL 0.883 0.88 4.76 0.80 1.00 3.81 y 3.81 Lead Sheath insulated
Cu. Conductor 3 10 10 1 43.92
CPI Sludge pumps 0 1 1 3.7 3.70 0 LV 0.4 3 7 16 MCCB DOL 0.883 0.88 0.00 0.80 1.00 0.00 y 0.00 Lead Sheath insulated
Cu. Conductor 3 10 10 1 43.92
Equilization tank feed pumps 1 0 1 110 110.00 110 LV 0.4 3 198 200 MCCB VSD 0.952 0.88 131.30 0.80 1.00 105.04 y 105.04 Lead Sheath insulated
Cu. Conductor 3 185 185 4 216
Equilization tank feed pumps 1 0 1 110 110.00 110 LV 0.4 3 198.5 200 MCCB VSD 0.952 0.88 131.30 0.80 1.00 105.04 y 105.04 Lead Sheath insulated
Cu. Conductor 3 185 185 4 216
Equilization tank feed pumps 0 1 1 110 110.00 0 LV 0.4 3 198 200 MCCB VSD 0.952 0.88 0.00 0.80 1.00 0.00 y 0.00 Lead Sheath insulated
Cu. Conductor 3 185 185 4 216
Equilization tank mixers 1 0 1 25 25.00 25 LV 0.4 3 45 63 MCCB DOL 0.932 0.88 30.48 0.80 1.00 24.39 y 24.39 Lead Sheath insulated
Cu. Conductor 3 35 35 4 86.4
41
01/19/2021
Equilization tank mixers 0 1 1 25 25.00 0 LV 0.4 3 45 63 MCCB DOL 0.932 0.88 0.00 0.80 1.00 0.00 y 0.00 Lead Sheath insulated
Cu. Conductor 3 35 35 4 86.4
Equilization tank mixers 0 1 1 25 25.00 0 LV 0.4 3 45 63 MCCB DOL 0.932 0.88 0.00 0.80 1.00 0.00 y 0.00 Lead Sheath insulated
Cu. Conductor 3 35 35 4 86.4
Vent compressor 1 0 1 2.3 2.30 2.3 LV 0.4 3 4 16 MCCB DOL 0.864 0.88 3.03 0.80 0.60 1.45 y 1.45 Lead Sheath insulated
Cu. Conductor 3 4 150 1 194.4
Vent compressor 0 1 1 2.3 2.30 0 LV 0.4 3 4 16 MCCB DOL 0.864 0.88 0.00 0.80 0.60 0.00 y 0.00 Lead Sheath insulated
Cu. Conductor 3 4 150 1 194.4
Hydrogen peroxide dosing pumps 1 0 1 0.37 0.37 0.37 LV 0.4 3 1 16 MCCB DOL 0.838 0.88 0.50 0.80 1.00 0.40 y 0.40 Lead Sheath insulated
Cu. Conductor 3 4 4 1 26.64
Hydrogen peroxide dosing pumps 0 1 1 0.37 0.37 0 LV 0.4 3 1 16 MCCB DOL 0.838 0.88 0.00 0.80 1.00 0.00 y 0.00 Lead Sheath insulated
Cu. Conductor 3 4 4 1 26.64
Mixer for above 1 0 1 0.75 0.75 0.75 LV 0.4 3 1 16 MCCB DOL 0.838 0.88 1.02 0.80 0.60 0.49 y 0.49 Lead Sheath insulated
Cu. Conductor 3 4 4 1 26.64
Sodium hydroxide dosing pumps 1 0 1 0.37 0.37 0.37 LV 0.4 3 1 16 MCCB DOL 0.838 0.88 0.50 0.80 1.00 0.40 y 0.40 Lead Sheath insulated
Cu. Conductor 3 4 4 1 26.64
Sodium hydroxide dosing pumps 0 1 1 0.37 0.37 0 LV 0.4 3 1 16 MCCB DOL 0.838 0.88 0.00 0.80 1.00 0.00 y 0.00 Lead Sheath insulated
Cu. Conductor 3 4 4 1 26.64
Mixer for above 1 0 1 0.75 0.75 0.75 LV 0.4 3 1 16 MCCB DOL 0.838 0.88 1.02 0.80 0.60 0.49 y 0.49 Lead Sheath insulated
Cu. Conductor 3 4 4 1 26.64
Coagulation tank mixers 1 0 1 3.7 3.70 3.7 LV 0.4 3 7 16 MCCB VSD 0.883 0.88 4.76 0.80 1.00 3.81 y 3.81 Lead Sheath insulated
Cu. Conductor 3 25 25 1 72
Coagulation tank mixers 1 0 1 3.7 3.70 3.7 LV 0.4 3 6.7 16 MCCB VSD 0.95 0.88 4.43 0.80 1.00 3.54 y 3.54 Lead Sheath insulated
Cu. Conductor 3 25 25 1 72
Coagulation tank mixers 0 1 1 3.7 3.70 0 LV 0.4 3 7 16 MCCB VSD 0.95 0.88 0.00 0.80 1.00 0.00 y 0.00 Lead Sheath insulated
Cu. Conductor 3 25 25 1 72
Flocculation tank mixer 1 0 1 3.7 3.70 3.7 LV 0.4 3 7 16 MCCB VSD 0.95 0.88 4.43 0.80 1.00 3.54 y 3.54 Lead Sheath insulated
Cu. Conductor 3 25 25 1 72
Flocculation tank mixer 1 0 1 3.7 3.70 3.7 LV 0.4 3 7 16 MCCB VSD 0.95 0.88 4.43 0.80 1.00 3.54 y 3.54 Lead Sheath insulated
Cu. Conductor 3 25 25 1 72
Flocculation tank mixer 0 1 1 3.7 3.70 0 LV 0.4 3 7 16 MCCB VSD 0.95 0.88 0.00 0.80 1.00 0.00 y 0.00 Lead Sheath insulated
Cu. Conductor 3 25 25 1 72
Coagulant Dosing pumps pkg 1 0 1 1.49 1.49 1.49 LV 0.4 3 3 16 MCCB DIRECT 0.85 0.88 1.99 0.80 1.00 1.59 y 1.59 Lead Sheath insulated
Cu. Conductor 3.5 4 150 1 194.4
Flocculant Dosing pumps pkg 1 0 1 1.49 1.49 1.49 LV 0.4 3 3 16 MCCB DIRECT 0.85 0.88 1.99 0.80 1.00 1.59 y 1.59 Lead Sheath insulated
Cu. Conductor 3.5 10 10 1 43.92
Acid dosing pump 1 0 1 0.37 0.37 0.37 LV 0.4 3 1 16 MCCB DOL 0.838 0.88 0.50 0.80 1.00 0.40 y 0.40 Lead Sheath insulated
Cu. Conductor 3 4 4 1 26.64
Acid dosing pump 0 1 1 0.37 0.37 0 LV 0.4 3 1 16 MCCB DOL 0.838 0.88 0.00 0.80 1.00 0.00 y 0.00 Lead Sheath insulated
Cu. Conductor 3 4 4 1 26.64
Sodium hydroxide dosing pumps 1 0 1 0.37 0.37 0.37 LV 0.4 3 1 16 MCCB DOL 0.838 0.88 0.50 0.80 1.00 0.40 y 0.40 Lead Sheath insulated
Cu. Conductor 3 4 4 1 26.64
Sodium hydroxide dosing pumps 0 1 1 0.37 0.37 0 LV 0.4 3 1 16 MCCB DOL 0.838 0.88 0.00 0.80 1.00 0.00 y 0.00 Lead Sheath insulated
Cu. Conductor 3 4 4 1 26.64
Spare - 1 0 1 1 NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA
Spare - 2 0 1 1 NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA
Spare - 3 0 1 1 NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA
Spare - 4 0 1 1 NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA
Spare - 5 0 1 1 NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA
Spare - 6 0 1 1 NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA
Spare - 7 0 1 1 NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA
Spare - 8 0 1 1 NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA
Space - 1 0 1 1 NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA
Space - 2 0 1 1 NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA
Space - 3 0 1 1 NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA
Space - 4 0 1 1 NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA
MCC-2(Unit 6340)
Incomers
Incomer From PCC bus 2 1 0 1 484.30 484.30 270.40 LV 0.4 3 537 630 ACB DIRECT NA NA NA NA NA NA NA NA
Included
Outgoings
DAF Feed Pump Motor 1 0 1 75 75.00 75 LV 0.4 3 135 160 MCCB VSD 0.947 0.88 90.00 0.80 1.00 72.00 y 72.00 Lead Sheath insulated
Cu. Conductor 3 150 150 2 194.4
42
01/19/2021
DAF Feed Pump Motor 1 0 1 75 75.00 75 LV 0.4 3 135 160 MCCB VSD 0.947 0.88 90.00 0.80 1.00 72.00 y 72.00 Lead Sheath insulated
Cu. Conductor 3 150 150 2 194.4
DAF Feed Pump Motor 0 1 1 75 75.00 0 LV 0.4 3 135 160 MCCB VSD 0.947 0.88 0.00 0.80 1.00 0.00 y 0.00 Lead Sheath insulated
Cu. Conductor 3 150 150 2 194.4
DAF Feed Pump Motor 0 1 1 75 75.00 0 LV 0.4 3 135 160 MCCB VSD 0.947 0.88 0.00 0.80 1.00 0.00 y 0.00 Lead Sheath insulated
Cu. Conductor 3 150 150 2 194.4
Oil skimmer 1 0 1 9.3 9.30 9.3 LV 0.4 3 17 32 MCCB DOL 0.91 0.88 11.61 0.80 0.60 5.57 y 5.57 Lead Sheath insulated
Cu. Conductor 3 10 10 1 43.92
Oil skimmer 1 0 1 9.3 9.30 9.3 LV 0.4 3 17 32 MCCB DOL 0.91 0.88 11.61 0.80 0.60 5.57 y 5.57 Lead Sheath insulated
Cu. Conductor 3 10 10 1 43.92
Oil skimmer 0 1 1 9.3 9.30 0 LV 0.4 3 17 32 MCCB DOL 0.91 0.88 0.00 0.80 0.60 0.00 y 0.00 Lead Sheath insulated
Cu. Conductor 3 10 10 1 43.92
DAF air dissolving drums 1 0 1 2.2 2.20 2.2 LV 0.4 3 4 16 MCCB DOL 0.864 0.88 2.89 0.80 0.60 1.39 y 1.39 Lead Sheath insulated
Cu. Conductor 3 10 10 1 43.92
DAF air dissolving drums 1 0 1 2.2 2.20 2.2 LV 0.4 3 4 16 MCCB DOL 0.864 0.88 2.89 0.80 0.60 1.39 y 1.39 Lead Sheath insulated
Cu. Conductor 3 10 10 1 43.92
DAF air dissolving drums 0 1 1 2.2 2.20 0 LV 0.4 3 4 16 MCCB DOL 0.864 0.88 0.00 0.80 0.60 0.00 y 0.00 Lead Sheath insulated
Cu. Conductor 3 10 10 1 43.92
DAF recycling pumps 1 0 1 45 45.00 45 LV 0.4 3 81.2 100 MCCB VSD 0.939 0.88 54.46 0.80 1.00 43.57 y 43.57 Lead Sheath insulated
Cu. Conductor 3 185 185 1 216
DAF recycling pumps 1 0 1 45 45.00 45 LV 0.4 3 81 100 MCCB VSD 0.939 0.88 54.46 0.80 1.00 43.57 y 43.57 Lead Sheath insulated
Cu. Conductor 3 185 185 1 216
DAF recycling pumps 0 1 1 45 45.00 0 LV 0.4 3 81 100 MCCB VSD 0.939 0.88 0.00 0.80 1.00 0.00 y 0.00 Lead Sheath insulated
Cu. Conductor 3 185 185 1 216
DAF sludge Pit Mixers 1 0 1 3.7 3.70 3.7 LV 0.4 3 7 16 MCCB DOL 0.883 0.88 4.76 0.80 0.50 1.90 y 1.90 Lead Sheath insulated
Cu. Conductor 3 16 16 1 56.16
DAF sludge Pit Mixers 0 1 1 3.7 3.70 0 LV 0.4 3 7 16 MCCB DOL 0.883 0.88 0.00 0.80 0.50 0.00 y 0.00 Lead Sheath insulated
Cu. Conductor 3 16 16 1 56.16
DAF Sludge pit pumps 1 0 1 3.7 3.70 3.7 LV 0.4 3 7 16 MCCB VSD 0.883 0.88 4.76 0.80 1.00 3.81 y 3.81 Lead Sheath insulated
Cu. Conductor 3 16 16 1 56.16
DAF Sludge pit pumps 0 1 1 3.7 3.70 0 LV 0.4 3 7 16 MCCB VSD 0.883 0.88 0.00 0.80 1.00 0.00 y 0.00 Lead Sheath insulated
Cu. Conductor 3 16 16 1 56.16
MCC - 6340(Emergency)
Incomers
Incomer From PCC bus 3 1 0 1 64.80 64.80 64.80 LV 0.4 3 129 160 MCCB DIRECT NA NA NA NA NA NA NA NA
Included
Outgoings
Equilisation tank mixers 1 0 1 25 25.00 25 LV 0.4 3 45 63 MCCB DOL 0.926 0.88 30.68 0.80 1.00 24.54 y 24.54 Lead Sheath insulated
Cu. Conductor 3 35 35 4 86.4
Equilisation tank mixers 1 0 1 25 25.00 25 LV 0.4 3 45 63 MCCB DOL 0.926 0.88 30.68 0.80 1.00 24.54 y 24.54 Lead Sheath insulated
Cu. Conductor 3 35 35 4 86.4
Clarifier scraper drive 1 0 1 3.7 3.70 3.7 LV 0.4 3 7 16 MCCB DOL 0.883 0.88 4.76 0.80 1.00 3.81 y 3.81 Lead Sheath insulated
Cu. Conductor 3 4 4 1 26.64
Clarifier scraper drive 1 0 1 3.7 3.70 3.7 LV 0.4 3 7 16 MCCB DOL 0.883 0.88 4.76 0.80 1.00 3.81 y 3.81 Lead Sheath insulated
Cu. Conductor 3 6 6 1 33.84
Clarifier scraper drive 1 0 1 3.7 3.70 3.7 LV 0.4 3 7 16 MCCB DOL 0.883 0.88 4.76 0.80 1.00 3.81 y 3.81 Lead Sheath insulated
Cu. Conductor 3 6 6 1 33.84
Clarifier scraper drive 1 0 1 3.7 3.70 3.7 LV 0.4 3 7 16 MCCB DOL 0.883 0.88 4.76 0.80 1.00 3.81 y 3.81 Lead Sheath insulated
Cu. Conductor 3 10 10 1 43.92
Spare - 1 0 1 1 NA NA NA LV 0.4 3 NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA
Spare - 2 0 1 1 NA NA NA LV 0.4 3 NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA
Space - 1 0 1 1 NA NA NA LV 0.4 3 NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA
PCC-6340
Incomers
BUS 1
43
01/19/2021
Outgoings - Bus A
MCC-3(Unit 6340) 1 0 1 418.30 418.30 334.70 LV 0.4 3 664 1000 ACB DIRECT NA NA NA NA NA 331.79 y #REF! Lead Sheath insulated
Cu. Conductor 3.5 240 240 4 252
Welding sockets 1 0 1 150 150.00 150 LV 0.4 3 271 250 MCCB DIRECT 1 0.85 176.47 0.80 0.30 42.35 y 42.35 Lead Sheath insulated
Cu. Conductor 3.5 70 70 2 126
Static Load 1 0 1 20 20.00 20 LV 0.4 3 36 63 MCCB DIRECT 1 0.85 23.53 1.00 1.00 23.53 y 23.53 Lead Sheath insulated
Cu. Conductor 4 25 25 1 72
Spare 0 1 1 NA NA NA NA NA NA NA 1000 ACB DIRECT NA NA NA NA NA NA y NA Lead Sheath insulated
Cu. Conductor NA NA NA NA NA
Space 0 1 1 NA NA NA LV 0.4 3 NA 1000 NA NA NA NA NA NA NA NA NA NA
NA NA NA NA NA NA
Bus B
MCC-4(Unit 6340) 1 0 1 930.20 930.20 421.50 LV 0.4 3 837 800 ACB DIRECT NA NA NA NA NA 404.55 y #REF! Lead Sheath insulated
Cu. Conductor 3.5 240 240 4 252
Static Load 1 0 1 20 20.00 20 LV 0.4 3 36 63 MCCB DIRECT 1 0.8 25.00 1.00 1.00 25.00 y 25.00 Lead Sheath insulated
Cu. Conductor 4 25 25 1 72
MCC-3(Unit 6340)
Incomers
Incomer From PCC bus 2 1 0 1 418.30 418.30 334.70 LV 0.4 3 664 800 ACB DIRECT NA NA NA NA NA NA NA NA
Included
Outgoings
Anoxic tank mixers 1 0 1 15 15.00 15 LV 0.4 3 27 32 MCCB DOL 0.918 0.88 18.57 0.80 1.00 14.85 y 14.85 Lead Sheath insulated
Cu. Conductor 3 4 150 1 194.4
Anoxic tank mixers 1 0 1 15 15.00 15 LV 0.4 3 27 32 MCCB DOL 0.918 0.88 18.57 0.80 1.00 14.85 y 14.85 Lead Sheath insulated
Cu. Conductor 3 4 150 1 194.4
Anoxic tank mixers 1 0 1 15 15.00 15 LV 0.4 3 27 32 MCCB DOL 0.918 0.88 18.57 0.80 1.00 14.85 y 14.85 Lead Sheath insulated
Cu. Conductor 3 35 35 1 86.4
Anoxic tank mixers 1 0 1 15 15.00 15 LV 0.4 3 27 32 MCCB DOL 0.918 0.88 18.57 0.80 1.00 14.85 y 14.85 Lead Sheath insulated
Cu. Conductor 3 35 35 1 86.4
Anoxic tank mixers 1 0 1 15 15.00 15 LV 0.4 3 27 32 MCCB DOL 0.918 0.88 18.57 0.80 1.00 14.85 y 14.85 Lead Sheath insulated
Cu. Conductor 3 25 25 2 72
Anoxic tank mixers 1 0 1 15 15.00 15 LV 0.4 3 27 32 MCCB DOL 0.918 0.88 18.57 0.80 1.00 14.85 y 14.85 Lead Sheath insulated
Cu. Conductor 3 25 25 2 72
Anoxic tank mixers 1 0 1 15 15.00 15 LV 0.4 3 27 32 MCCB DOL 0.918 0.88 18.57 0.80 1.00 14.85 y 14.85 Lead Sheath insulated
Cu. Conductor 3 25 25 2 72
Anoxic tank mixers 1 0 1 15 15.00 15 LV 0.4 3 27 32 MCCB DOL 0.918 0.88 18.57 0.80 1.00 14.85 y 14.85 Lead Sheath insulated
Cu. Conductor 3 25 25 2 72
Aeration tank mixers 1 0 1 7.5 7.50 7.5 LV 0.4 3 14 16 MCCB DOL 0.901 0.88 9.46 0.80 1.00 7.57 y 7.57 Lead Sheath insulated
Cu. Conductor 3 25 25 1 72
Aeration tank mixers 1 0 1 7.5 7.50 7.5 LV 0.4 3 13.5 16 MCCB DOL 0.901 0.88 9.46 0.80 1.00 7.57 y 7.57 Lead Sheath insulated
Cu. Conductor 3 25 25 1 72
Aeration tank mixers 1 0 1 7.5 7.50 7.5 LV 0.4 3 14 16 MCCB DOL 0.901 0.88 9.46 0.80 1.00 7.57 y 7.57 Lead Sheath insulated
Cu. Conductor 3 25 25 1 72
Aeration tank mixers 1 0 1 7.5 7.50 7.5 LV 0.4 3 14 16 MCCB DOL 0.901 0.88 9.46 0.80 1.00 7.57 y 7.57 Lead Sheath insulated
Cu. Conductor 3 25 25 1 72
Aeration tank mixers 1 0 1 7.5 7.50 7.5 LV 0.4 3 14 16 MCCB DOL 0.901 0.88 9.46 0.80 1.00 7.57 y 7.57 Lead Sheath insulated
Cu. Conductor 3 25 25 1 72
Aeration tank mixers 1 0 1 7.5 7.50 7.5 LV 0.4 3 14 16 MCCB DOL 0.901 0.88 9.46 0.80 1.00 7.57 y 7.57 Lead Sheath insulated
Cu. Conductor 3 25 25 1 72
Aeration tank mixers 1 0 1 7.5 7.50 7.5 LV 0.4 3 14 16 MCCB DOL 0.901 0.88 9.46 0.80 1.00 7.57 y 7.57 Lead Sheath insulated
Cu. Conductor 3 25 150 1 194.4
Aeration tank mixers 1 0 1 7.5 7.50 7.5 LV 0.4 3 14 16 MCCB DOL 0.901 0.88 9.46 0.80 1.00 7.57 y 7.57 Lead Sheath insulated
Cu. Conductor 3 25 150 1 194.4
Aeration tank mixers 1 0 1 7.5 7.50 7.5 LV 0.4 3 14 16 MCCB DOL 0.901 0.88 9.46 0.80 1.00 7.57 y 7.57 Lead Sheath insulated
Cu. Conductor 3 25 25 1 72
Aeration tank mixers 1 0 1 7.5 7.50 7.5 LV 0.4 3 14 16 MCCB DOL 0.901 0.88 9.46 0.80 1.00 7.57 y 7.57 Lead Sheath insulated
Cu. Conductor 3 25 25 1 72
Aeration tank mixers 1 0 1 7.5 7.50 7.5 LV 0.4 3 14 16 MCCB DOL 0.901 0.88 9.46 0.80 1.00 7.57 y 7.57 Lead Sheath insulated
Cu. Conductor 3 25 25 1 72
Aeration tank mixers 1 0 1 7.5 7.50 7.5 LV 0.4 3 14 16 MCCB DOL 0.901 0.88 9.46 0.80 1.00 7.57 y 7.57 Lead Sheath insulated
Cu. Conductor 3 25 25 1 72
44
01/19/2021
Aeration tank mixers 1 0 1 7.5 7.50 7.5 LV 0.4 3 14 16 MCCB DOL 0.901 0.88 9.46 0.80 1.00 7.57 y 7.57 Lead Sheath insulated
Cu. Conductor 3 25 25 1 72
Aeration tank mixers 1 0 1 7.5 7.50 7.5 LV 0.4 3 14 16 MCCB DOL 0.901 0.88 9.46 0.80 1.00 7.57 y 7.57 Lead Sheath insulated
Cu. Conductor 3 25 25 1 72
Aeration tank mixers 1 0 1 7.5 7.50 7.5 LV 0.4 3 14 16 MCCB DOL 0.901 0.88 9.46 0.80 1.00 7.57 y 7.57 Lead Sheath insulated
Cu. Conductor 3 25 25 1 72
Aeration tank mixers 1 0 1 7.5 7.50 7.5 LV 0.4 3 13.5 16 MCCB DOL 0.901 0.88 9.46 0.80 1.00 7.57 y 7.57 Lead Sheath insulated
Cu. Conductor 3 25 25 1 72
Mixed liquor recycling pumps 1 0 1 18.5 18.50 18.5 LV 0.4 3 33 63 MCCB DOL 0.922 0.88 22.80 0.80 1.00 18.24 y 18.24 Lead Sheath insulated
Cu. Conductor 3 16 16 1 56.16
Mixed liquor recycling pumps 1 0 1 18.5 18.50 18.5 LV 0.4 3 33 63 MCCB DOL 0.922 0.88 22.80 0.80 1.00 18.24 y 18.24 Lead Sheath insulated
Cu. Conductor 3 16 16 1 56.16
Mixed liquor recycling pumps 1 0 1 18.5 18.50 18.5 LV 0.4 3 33 63 MCCB DOL 0.922 0.88 22.80 0.80 1.00 18.24 y 18.24 Lead Sheath insulated
Cu. Conductor 3 16 16 1 56.16
Mixed liquor recycling pumps 1 0 1 18.5 18.50 18.5 LV 0.4 3 33 63 MCCB DOL 0.922 0.88 22.80 0.80 1.00 18.24 y 18.24 Lead Sheath insulated
Cu. Conductor 3 16 16 1 56.16
Mixed liquor recycling pumps 0 1 1 18.5 18.50 0 LV 0.4 3 33 63 MCCB DOL 0.922 0.88 0.00 0.80 1.00 0.00 y 0.00 Lead Sheath insulated
Cu. Conductor 3 16 150 1 194.4
Mixed liquor recycling pumps 0 1 1 18.5 18.50 0 LV 0.4 3 33 63 MCCB DOL 0.922 0.88 0.00 0.80 1.00 0.00 y 0.00 Lead Sheath insulated
Cu. Conductor 3 16 150 1 194.4
Mixed liquor recycling pumps 0 1 1 18.5 18.50 0 LV 0.4 3 33 63 MCCB DOL 0.922 0.88 0.00 0.80 1.00 0.00 y 0.00 Lead Sheath insulated
Cu. Conductor 3 16 16 1 56.16
Mixed liquor recycling pumps 0 1 1 18.5 18.50 0 LV 0.4 3 33 63 MCCB DOL 0.922 0.88 0.00 0.80 1.00 0.00 y 0.00 Lead Sheath insulated
Cu. Conductor 3 16 16 1 56.16
Clarifier scraper drive 1 0 1 3.7 3.70 3.7 LV 0.4 3 7 16 MCCB DOL 0.883 0.88 4.76 0.80 1.00 3.81 y 3.81 Lead Sheath insulated
Cu. Conductor 3 4 4 1 26.64
Clarifier scraper drive 1 0 1 3.7 3.70 3.7 LV 0.4 3 7 16 MCCB DOL 0.883 0.88 4.76 0.80 1.00 3.81 y 3.81 Lead Sheath insulated
Cu. Conductor 3 6 6 1 33.84
Clarifier scraper drive 1 0 1 3.7 3.70 3.7 LV 0.4 3 7 16 MCCB DOL 0.883 0.88 4.76 0.80 1.00 3.81 y 3.81 Lead Sheath insulated
Cu. Conductor 3 6 6 1 33.84
Clarifier scraper drive 1 0 1 3.7 3.70 3.7 LV 0.4 3 7 16 MCCB DOL 0.883 0.88 4.76 0.80 1.00 3.81 y 3.81 Lead Sheath insulated
Cu. Conductor 3 10 10 1 43.92
Clarifier scraper drive 0 1 1 3.7 3.70 0 LV 0.4 3 7 16 MCCB DOL 0.883 0.88 0.00 0.80 1.00 0.00 y 0.00 Lead Sheath insulated
Cu. Conductor 3 10 10 1 43.92
Scum pit pumps 1 0 1 3.7 3.70 3.7 LV 0.4 3 7 63 MCCB DOL 0.883 0.88 4.76 0.80 0.60 2.29 y 2.29 Lead Sheath insulated
Cu. Conductor 3 4 4 1 26.64
Scum pit pumps 0 1 1 3.7 3.70 0 LV 0.4 3 7 16 MCCB DOL 0.883 0.88 0.00 0.80 0.60 0.00 y 0.00 Lead Sheath insulated
Cu. Conductor 3 4 4 1 26.64
Scum pit mixers 1 0 1 2.2 2.20 2.2 LV 0.4 3 4 16 MCCB DOL 0.864 0.88 2.89 0.80 0.60 1.39 y 1.39 Lead Sheath insulated
Cu. Conductor 3 4 4 1 26.64
Scum pit mixers 0 1 1 2.2 2.20 0 LV 0.4 3 4 16 MCCB DOL 0.864 0.88 0.00 0.80 0.60 0.00 y 0.00 Lead Sheath insulated
Cu. Conductor 3 4 4 1 26.64
Spare - 1 0 1 1 NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA
Spare - 2 0 1 1 NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA
Spare - 3 0 1 1 NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA
Spare - 4 0 1 1 NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA
Spare - 5 0 1 1 NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA
Spare - 6 0 1 1 NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA
Spare - 7 0 1 1 NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA
Space - 1 0 1 1 NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA
Space - 2 0 1 1 NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA
Space - 3 0 1 1 NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA
Space - 4 0 1 1 NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA
MCC-4(Unit 6340)
Incomers
Incomer From PCC bus 2 1 0 1 930.20 930.20 421.50 LV 0.4 3 837 1000 ACB DIRECT NA NA NA NA NA NA NA NA
Included
Outgoings
Overflow pit pumps 1 0 1 75 75.00 75 LV 0.4 3 135 160 MCCB VSD 0.947 0.88 90.00 0.80 1.00 72.00 y 72.00 Lead Sheath insulated
Cu. Conductor 3 150 150 1 194.4
Overflow pit pumps 1 0 1 75 75.00 75 LV 0.4 3 135 160 MCCB VSD 0.947 0.88 90.00 0.80 1.00 72.00 y 72.00 Lead Sheath insulated
Cu. Conductor 3 150 150 1 194.4
45
01/19/2021
Overflow pit pumps 1 0 1 75 75.00 75 LV 0.4 3 135 160 MCCB VSD 0.947 0.88 90.00 0.80 1.00 72.00 y 72.00 Lead Sheath insulated
Cu. Conductor 3 150 150 1 194.4
Overflow pit pumps 1 0 1 75 75.00 75 LV 0.4 3 135 160 MCCB VSD 0.947 0.88 90.00 0.80 1.00 72.00 y 72.00 Lead Sheath insulated
Cu. Conductor 3 185 185 1 216
Overflow pit pumps 0 1 1 75 75.00 0 LV 0.4 3 135 160 MCCB VSD 0.947 0.88 0.00 0.80 1.00 0.00 y 0.00 Lead Sheath insulated
Cu. Conductor 3 150 150 2 194.4
Overflow pit pumps 0 1 1 75 75.00 0 LV 0.4 3 135 160 MCCB VSD 0.947 0.88 0.00 0.80 1.00 0.00 y 0.00 Lead Sheath insulated
Cu. Conductor 3 150 150 2 194.4
Overflow pit pumps 0 1 1 75 75.00 0 LV 0.4 3 135.3 160 MCCB VSD 0.947 0.88 0.00 0.80 1.00 0.00 y 0.00 Lead Sheath insulated
Cu. Conductor 3 150 150 2 194.4
Overflow pit pumps 0 1 1 75 75.00 0 LV 0.4 3 135 160 MCCB VSD 0.947 0.88 0.00 0.80 1.00 0.00 y 0.00 Lead Sheath insulated
Cu. Conductor 3 150 150 2 194.4
Overflow pit pumps 0 1 1 75 75.00 0 LV 0.4 3 135 160 MCCB VSD 0.947 0.88 0.00 0.80 1.00 0.00 y 0.00 Lead Sheath insulated
Cu. Conductor 3 185 185 2 216
Overflow pit pumps 0 1 1 75 75.00 0 LV 0.4 3 135 160 MCCB VSD 0.947 0.88 0.00 0.80 1.00 0.00 y 0.00 Lead Sheath insulated
Cu. Conductor 3 185 185 2 216
Sludge Recovery Pump Motor 1 0 1 55 55.00 55 LV 0.4 3 99 100 MCCB VSD 0.942 0.88 66.35 0.80 1.00 53.08 y 53.08 Lead Sheath insulated
Cu. Conductor 3 185 185 2 216
Sludge Recovery Pump Motor 1 0 1 55 55.00 55 LV 0.4 3 99 100 MCCB VSD 0.942 0.88 66.35 0.80 1.00 53.08 y 53.08 Lead Sheath insulated
Cu. Conductor 3 185 185 2 216
Sludge Recovery Pump Motor 0 1 1 55 55.00 0 LV 0.4 3 99 100 MCCB VSD 0.942 0.88 0.00 0.80 1.00 0.00 y 0.00 Lead Sheath insulated
Cu. Conductor 3 185 185 2 216
Methanol dosing pumps pkg 1 0 1 2.6 2.60 2.6 LV 0.4 3 4.7 16 MCCB DIRECT 0.874 0.88 3.38 0.80 1.00 2.70 y 2.70 Lead Sheath insulated
Cu. Conductor 3.5 4 4 1 26.64
Urea dosing pumps pkg 1 0 1 2.6 2.60 2.6 LV 0.4 3 5 16 MCCB DIRECT 0.874 0.88 3.38 0.80 1.00 2.70 y 2.70 Lead Sheath insulated
Cu. Conductor 3.5 4 4 1 26.64
Tri sodium phosphate dosing pump pkg 1 0 1 2.6 2.60 2.6 LV 0.4 3 5 16 MCCB DIRECT 0.874 0.88 3.38 0.80 1.00 2.70 y 2.70 Lead Sheath insulated
Cu. Conductor 3.5 4 4 1 26.64
Backwash pump 1 0 1 3.7 3.70 3.7 LV 0.4 3 7 16 MCCB DOL 0.883 0.88 4.76 0.80 0.60 2.29 y 2.29 Lead Sheath insulated
Cu. Conductor 3 10 10 1 43.92
Backwash pump 0 1 1 3.7 3.70 0 LV 0.4 3 7 16 MCCB DOL 0.883 0.88 0.00 0.80 0.60 0.00 y 0.00 Lead Sheath insulated
Cu. Conductor 3 10 10 1 43.92
PCC-6360
Incomers
BUS 1
Outgoings - Bus A
MCC-5(Unit 6360) 1 0 1 267.84 267.84 225.27 LV 0.4 3 447 630 ACB DIRECT NA NA NA NA NA 119.82 y #REF! Lead Sheath insulated
Cu. Conductor 3.5 240 240 3 252
Static Load 1 0 1 20 20.00 20 LV 0.4 3 36 63 MCCB DIRECT 1 0.8 25.00 1.00 1.00 25.00 y 25.00 Lead Sheath insulated
Cu. Conductor 4 25 25 1 72
Spare 0 1 1 NA NA NA NA NA NA NA 630 NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA
Bus B
MCC-6(Unit 6360) 1 0 1 211.10 211.10 193.20 LV 0.4 3 383 400 MCCB DIRECT NA NA NA NA NA 81.41 y #REF! Lead Sheath insulated
Cu. Conductor 3.5 240 240 2 252
Static Load 1 0 1 20 20.00 20 LV 0.4 3 36 63 MCCB DIRECT 1 0.8 25.00 1.00 1.00 25.00 y 25.00 Lead Sheath insulated
Cu. Conductor 4 25 25 1 72
Spare 0 1 1 NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA
46
01/19/2021
MCC-5(Unit 6360)
Incomers
Incomer From PCC bus 1 1 0 1 267.84 267.84 225.27 LV 0.4 3 447 630 ACB DIRECT NA NA NA NA NA NA NA NA
Included
Outgoings
Buffer pit pumps 1 0 1 1.5 1.50 1.5 LV 0.4 3 3 16 MCCB VSD 0.85 0.88 2.01 0.80 1.00 1.60 y 1.60 Lead Sheath insulated
Cu. Conductor 3 4 4 1 26.64
Buffer pit pumps 0 1 1 1.5 1.50 0 LV 0.4 3 3 16 MCCB VSD 0.85 0.88 0.00 0.80 1.00 0.00 y 0.00 Lead Sheath insulated
Cu. Conductor 3 4 4 1 26.64
Buffer pit Mixer 1 0 1 1.1 1.10 1.1 LV 0.4 3 2 16 MCCB DOL 0.85 0.88 1.47 0.80 0.60 0.71 y 0.71 Lead Sheath insulated
Cu. Conductor 3 4 4 1 26.64
CPI sludge centrifuge 1 0 1 18.5 18.50 18.5 LV 0.4 3 33 63 MCCB DOL 0.922 0.88 22.80 0.80 1.00 18.24 y 18.24 Lead Sheath insulated
Cu. Conductor 3 35 35 1 86.4
CPI sludge centrifuge 0 1 1 18.5 18.50 0 LV 0.4 3 33 63 MCCB DOL 0.922 0.88 0.00 0.80 1.00 0.00 y 0.00 Lead Sheath insulated
Cu. Conductor 3 35 150 1 194.4
CPI Sludge centrifuge belt conveyors 1 0 1 1.5 1.50 1.5 LV 0.4 3 3 16 MCCB DOL 0.85 0.88 2.01 0.80 1.00 1.60 y 1.60 Lead Sheath insulated
Cu. Conductor 3 4 150 1 194.4
Poly dosing pumps 1 0 1 0.37 0.37 0.37 LV 0.4 3 1 16 MCCB DOL 0.838 0.88 0.50 0.80 1.00 0.40 y 0.40 Lead Sheath insulated
Cu. Conductor 3 4 4 1 26.64
Poly dosing pumps 0 1 1 0.37 0.37 0 LV 0.4 3 1 16 MCCB DOL 0.838 0.88 0.00 0.80 1.00 0.00 y 0.00 Lead Sheath insulated
Cu. Conductor 3 4 4 1 26.64
Mixers for poly dosing 1 0 1 0.5 0.50 0.5 LV 0.4 3 1 16 MCCB DOL 0.838 0.88 0.68 0.80 1.00 0.54 y 0.54 Lead Sheath insulated
Cu. Conductor 3 4 4 1 26.64
DAF/ASP sludge thickner scraper drive 1 0 1 3.7 3.70 3.7 LV 0.4 3 7 16 MCCB DOL 0.883 0.88 4.76 0.80 1.00 3.81 y 3.81 Lead Sheath insulated
Cu. Conductor 3 6 6 1 33.84
DAF/ASP sludge thickner scraper drive 1 0 1 3.7 3.70 3.7 LV 0.4 3 7 16 MCCB DOL 0.883 0.88 4.76 0.80 1.00 3.81 y 3.81 Lead Sheath insulated
Cu. Conductor 3 6 6 1 33.84
DAF/ASP thickened sludge pumps 1 0 1 3.7 3.70 3.7 LV 0.4 3 7 16 MCCB DOL 0.883 0.88 4.76 0.80 1.00 3.81 y 3.81 Lead Sheath insulated
Cu. Conductor 3 6 6 1 33.84
DAF/ASP thickened sludge pumps 1 0 1 3.7 3.70 3.7 LV 0.4 3 7 16 MCCB DOL 0.883 0.88 4.76 0.80 1.00 3.81 y 3.81 Lead Sheath insulated
Cu. Conductor 3 6 6 1 33.84
DAF/ASP thickened sludge pumps 0 1 1 3.7 3.70 0 LV 0.4 3 6.7 16 MCCB DOL 0.883 0.88 0.00 0.80 1.00 0.00 y 0.00 Lead Sheath insulated
Cu. Conductor 3 6 6 1 33.84
DAF/ASP sludge centrifuge 1 0 1 18.5 18.50 18.5 LV 0.4 3 33 63 MCCB DOL 0.922 0.88 22.80 0.80 1.00 18.24 y 18.24 Lead Sheath insulated
Cu. Conductor 3 35 35 1 86.4
DAF/ASP sludge centrifuge 1 0 1 18.5 18.50 18.5 LV 0.4 3 33.4 63 MCCB DOL 0.922 0.88 22.80 0.80 1.00 18.24 y 18.24 Lead Sheath insulated
Cu. Conductor 3 35 35 1 86.4
DAF/ASP sludge centrifuge 0 1 1 18.5 18.50 0 LV 0.4 3 33.4 63 MCCB DOL 0.922 0.88 0.00 0.80 1.00 0.00 y 0.00 Lead Sheath insulated
Cu. Conductor 3 35 35 1 86.4
Power & Welding sockets 1 0 1 150 150.00 150 LV 0.4 3 271 315 MCCB DIRECT 1 1 150.00 1.00 0.30 45.00 y 45.00 Lead Sheath insulated
Cu. Conductor 3.5 150 150 2 194.4
Spare 1 0 1 1 NA NA NA LV 0.4 3 NA 315 MCCB DIRECT NA NA NA NA NA NA NA NA NA NA NA NA NA NA
Spare 2 0 1 1 NA NA NA LV 0.4 3 NA 63 MCCB DOL NA NA NA NA NA NA NA NA NA NA NA NA NA NA
Spare 3 0 1 1 NA NA NA LV 0.4 3 NA 16 MCCB VSD NA NA NA NA NA NA NA NA
NA NA NA NA NA NA
Space 0 1 1 NA NA NA LV 0.4 3 NA 315 NA NA NA NA NA NA NA NA NA NA
NA NA NA NA NA NA
Space 0 1 1 NA NA NA LV 0.4 3 NA 63 NA NA NA NA NA NA NA NA NA NA
NA NA NA NA NA NA
267.84 267.84 225.27 119.82 11.97
MCC-6(Unit 6360)
Incomers
Incomer From PCC bus 2 1 0 1 211.10 211.10 193.20 LV 0.4 3 383 400 MCCB DIRECT NA NA NA NA NA NA NA NA
Included
Outgoings
DAF/ASP sludge belt conveyor 1 0 1 1.5 1.50 1.5 LV 0.4 3 3 16 MCCB DOL 0.85 0.88 2.01 0.80 1.00 1.60 y 1.60 Lead Sheath insulated
Cu. Conductor 3 4 4 1 26.64
DAF/ASP sludge belt conveyor 0 1 1 1.5 1.50 0 LV 0.4 3 3 16 MCCB DOL 0.85 0.88 0.00 0.80 1.00 0.00 y 0.00 Lead Sheath insulated
Cu. Conductor 3 4 4 1 26.64
Mixer for dewatered sludge bin 1 0 1 3.7 3.70 3.7 LV 0.4 3 7 16 MCCB DOL 0.883 0.88 4.76 0.80 0.60 2.29 y 2.29 Lead Sheath insulated
Cu. Conductor 3 10 10 1 43.92
CPI & DAF/ASP dried sludge belt conveyors 1 0 1 1.5 1.50 1.5 LV 0.4 3 3 16 MCCB DOL 0.85 0.88 2.01 0.80 1.00 1.60 y 1.60 Lead Sheath insulated
Cu. Conductor 3 4 4 1 26.64
47
01/19/2021
CPI & DAF/ASP dried sludge belt conveyors 0 1 1 1.5 1.50 0 LV 0.4 3 3 16 MCCB DOL 0.85 0.88 0.00 0.80 1.00 0.00 y 0.00 Lead Sheath insulated
Cu. Conductor 3 4 4 1 26.64
Auto polymer metering pumps 1 0 1 0.55 0.55 0.55 LV 0.4 3 1 16 MCCB DOL 0.85 0.88 0.74 0.80 1.00 0.59 y 0.59 Lead Sheath insulated
Cu. Conductor 3 4 4 1 26.64
Auto polymer metering pumps 1 0 1 0.55 0.55 0.55 LV 0.4 3 1 16 MCCB DOL 0.85 0.88 0.74 0.80 1.00 0.59 y 0.59 Lead Sheath insulated
Cu. Conductor 3 4 4 1 26.64
Auto polymer metering pumps 0 1 1 0.55 0.55 0 LV 0.4 3 1.0 16 MCCB DOL 0.85 0.88 0.00 0.80 1.00 0.00 y 0.00 Lead Sheath insulated
Cu. Conductor 3 4 4 1 26.64
Mixer for poly dosing 1 0 1 1.1 1.10 1.1 LV 0.4 3 2 16 MCCB DOL 0.85 0.88 1.47 0.80 1.00 1.18 y 1.18 Lead Sheath insulated
Cu. Conductor 3 4 4 1 26.64
SWW Sludge thickner 1 0 1 1.1 1.10 1.1 LV 0.4 3 2.0 16 MCCB DOL 0.85 0.88 1.47 0.80 1.00 1.18 y 1.18 Lead Sheath insulated
Cu. Conductor 3 4 4 1 26.64
SWW thickned sludge pumps 1 0 1 0.37 0.37 0.37 LV 0.4 3 0.7 16 MCCB DOL 0.85 0.88 0.49 0.80 0.50 0.20 y 0.20 Lead Sheath insulated
Cu. Conductor 3 4 4 1 26.64
SWW thickned sludge pumps 0 1 1 0.37 0.37 0 LV 0.4 3 0.7 16 MCCB DOL 0.85 0.88 0.00 0.80 0.50 0.00 y 0.00 Lead Sheath insulated
Cu. Conductor 3 4 4 1 26.64
SWW sludge centrifuge 1 0 1 7.5 7.50 7.5 LV 0.4 3 14 16 MCCB DOL 0.85 0.88 10.03 0.80 0.50 4.01 y 4.01 Lead Sheath insulated
Cu. Conductor 3 16 16 1 56.16
SWW dewatered sludge screw conveyor 1 0 1 3.7 3.70 3.7 LV 0.4 3 6.7 16 MCCB DOL 0.85 0.88 4.95 0.80 0.50 1.98 y 1.98 Lead Sheath insulated
Cu. Conductor 3 16 16 1 56.16
SWW dewatered effulent recovery pumps 1 0 1 0.55 0.55 0.55 LV 0.4 3 1.0 16 MCCB DOL 0.85 0.88 0.74 0.80 0.50 0.29 y 0.29 Lead Sheath insulated
Cu. Conductor 3 4 4 1 26.64
SWW dewatered effulent recovery pumps 0 1 1 0.55 0.55 0 LV 0.4 3 1 16 MCCB DOL 0.85 0.88 0.00 0.80 0.50 0.00 y 0.00 Lead Sheath insulated
Cu. Conductor 3 4 4 1 26.64
Lime dosing screw 1 0 1 0.75 0.75 0.75 LV 0.4 3 1 16 MCCB DOL 0.85 0.88 1.00 0.80 0.50 0.40 y 0.40 Lead Sheath insulated
Cu. Conductor 3 4 4 1 26.64
Lime dosing screw 0 1 1 0.75 0.75 0 LV 0.4 3 1 16 MCCB DOL 0.85 0.88 0.00 0.80 0.50 0.00 y 0.00 Lead Sheath insulated
Cu. Conductor 3 4 4 1 26.64
Poly dosing pumps 1 0 1 0.18 0.18 0.18 LV 0.4 3 0 16 MCCB DOL 0.85 0.88 0.24 0.80 0.50 0.10 y 0.10 Lead Sheath insulated
Cu. Conductor 3 4 4 1 26.64
Poly dosing pumps 0 1 1 0.18 0.18 0 LV 0.4 3 0 16 MCCB DOL 0.85 0.88 0.00 0.80 0.50 0.00 y 0.00 Lead Sheath insulated
Cu. Conductor 3 4 150 1 194.4
Mixer for poly dosing 1 0 1 0.25 0.25 0.25 LV 0.4 3 0 16 MCCB DOL 0.85 0.88 0.33 0.80 0.50 0.13 y 0.13 Lead Sheath insulated
Cu. Conductor 3 4 150 1 194.4
Power & Welding sockets 1 0 1 150 150.00 150 LV 0.4 3 271 315 MCCB DOL 1 1 150.00 1.00 0.30 45.00 y 45.00 Lead Sheath insulated
Cu. Conductor 3.5 150 150 2 194.4
Spare 1 0 1 1 NA NA NA LV 0.4 3 NA 315 MCCB DIRECT NA NA NA NA NA NA NA NA NA NA NA NA NA NA
Spare 2 0 1 1 NA NA NA LV 0.4 3 NA 16 MCCB DOL NA NA NA NA NA NA NA NA
NA NA NA NA NA NA
Spare 3 0 1 1 NA NA NA LV 0.4 3 NA 16 MCCB DOL NA NA NA NA NA NA NA NA
NA NA NA NA NA NA
Spare 4 0 1 1 NA NA NA LV 0.4 3 NA 16 MCCB DOL NA NA NA NA NA NA NA NA
NA NA NA NA NA NA
Spare 5 0 1 1 NA NA NA LV 0.4 3 NA 16 MCCB DOL NA NA NA NA NA NA NA NA
NA NA NA NA NA NA
Space 0 1 1 NA NA NA LV 0.4 3 NA 315 NA NA NA NA NA NA NA NA NA NA
NA NA NA NA NA NA
Space 0 1 1 NA NA NA LV 0.4 3 NA 16 NA NA NA NA NA NA NA NA NA NA
NA NA NA NA NA NA
211.10 211.10 193.20 81.41 29.67
48
01/19/2021
Space
Limit on % Control heater
VD Cable Cable LPBS
2.5
Voltage drop
check for
Estimated minimum
Route Length Ampacity Ampacity Impedance of % Voltage length Cable Size in No of Cable Size
(in mtrs) Total Length match check selected cable drop considered Cable Gland Cable Lug No of cores Sq.mm Length Gland Lug cores in Sq.mm Length Gland Lug Qty
7 2.5 3 2.5
NA NA NA NA NA NA NA 2 6 NA NA NA NA NA NA NA NA NA NA NA
NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA
NA NA NA NA NA NA NA 2 6 NA NA NA NA NA NA NA NA NA NA NA
50 50 NA NA NA NA NA 2 6 NA NA NA NA NA NA NA NA NA NA NA
50 50 NA NA NA NA NA 2 6 NA NA NA NA NA NA NA NA NA NA NA
50 50 NA NA NA NA NA 2 6 NA NA NA NA NA NA NA NA NA NA NA
50 50 NA NA NA NA NA 2 6 NA NA NA NA NA NA NA NA NA NA NA
NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA
NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA
50 50 NA NA NA NA NA 2 6 NA NA NA NA NA NA NA NA NA NA NA
50 50 NA NA NA NA NA 2 6 NA NA NA NA NA NA NA NA NA NA NA
50 50 NA NA NA NA NA 2 6 NA NA NA NA NA NA NA NA NA NA NA
50 50 NA NA NA NA NA 2 6 NA NA NA NA NA NA NA NA NA NA NA
NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA
NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA
NA NA NA NA NA NA NA 2 6 NA NA NA NA NA NA NA NA NA NA NA
NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA
NA NA NA NA NA NA NA 2 6 NA NA NA NA NA NA NA NA NA NA NA
49
01/19/2021
330 330 4104 OK 0.15 0.03 OK 38 114 7 2.5 330 2 14 3 2.5 330 2 6 1
300 300 4104 OK 0.15 0.00 OK 38 114 7 2.5 300 2 14 3 2.5 300 2 6 1
280 280 4104 OK 0.15 0.00 OK 38 114 7 2.5 280 2 14 3 2.5 280 2 6 1
150 150 4104 OK 0.15 0.04 OK 38 114 7 2.5 150 2 14 3 2.5 150 2 6 1
NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA
NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA
330 330 4104 OK 0.15 0.03 OK 38 114 7 2.5 330 2 14 3 2.5 330 2 6 1
300 300 4104 OK 0.15 0.00 OK 38 114 7 2.5 300 2 14 3 2.5 300 2 6 1
280 280 4104 OK 0.15 0.00 OK 38 114 7 2.5 280 2 14 3 2.5 280 2 6 1
150 150 4104 OK 0.15 0.00 OK 38 114 7 2.5 150 2 14 3 2.5 150 2 6 1
NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA
NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA
10
10 NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA 0
NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA
10
10 NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA 0
NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA
0
15
15 NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA 0
NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA
NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA
50
01/19/2021
NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA
NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA
NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA
NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA
NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA 0
NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA
NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA
NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA
51
01/19/2021
NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA 0
NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA
NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA
NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA 0
52
01/19/2021
NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA
NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA
NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA
NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA
NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA
NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA
NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA
NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA
10 #VALUE! NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA 0
NA NA
#VALUE! #VALUE! #N/A #VALUE! #VALUE! #VALUE! #VALUE! 7 2.5 NA 2 14 3 2.5 NA 2 6 0
10
NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA 0
53
01/19/2021
NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA
NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA
NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA 0
NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA
NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA
NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA
NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA 0
54
01/19/2021
55
01/19/2021
NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA 0
NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA 0
NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA 0
NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA 0
NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA 0
NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA 0
NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA 0
NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA 0
NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA 0
NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA 0
NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA 0
NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA 0
NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA 0
NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA 0
NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA 0
NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA 0
NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA 0
NA NA NA NA NA NA NA 2 6 NA NA NA NA NA NA NA NA NA NA NA
NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA
56
01/19/2021
NA NA NA NA NA NA NA 2 6 NA NA NA NA NA NA NA NA NA NA NA
50 50 NA NA NA NA NA 2 6 NA NA NA NA NA NA NA NA NA NA NA
50 #VALUE! NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA 0
50 50 NA NA NA NA NA 2 6 NA NA NA NA NA NA NA NA NA NA NA
50 50 NA NA NA NA NA 2 6 NA NA NA NA NA NA NA NA NA NA NA
50 50 NA NA NA NA NA 2 6 NA NA NA NA NA NA NA NA NA NA NA
NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA
NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA
50 50 NA NA NA NA NA 2 6 NA NA NA NA NA NA NA NA NA NA NA
50 #VALUE! NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA 0
50 50 NA NA NA NA NA 2 6 NA NA NA NA NA NA NA NA NA NA NA
50 50 NA NA NA NA NA 2 6 NA NA NA NA NA NA NA NA NA NA NA
50 #VALUE! NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA 0
NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA
NA NA NA NA
NA NA NA NA NA NA
NA NA NA NA NA NA NA NA NA NA NA NA NA NA
NA NA NA NA NA NA NA 2 6 NA NA NA NA NA NA NA NA NA NA NA
NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA
NA NA NA NA NA NA NA 2 6 NA NA NA NA NA NA NA NA NA NA NA
NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA
50 50 NA NA NA NA NA 2 6 NA NA NA NA NA NA NA NA NA NA NA
550 10450 4788 OK 0.12 0.05 OK 38 114 7 2.5 550 2 14 3 2.5 550 2 6 1
550 10450 4788 OK 0.12 0.05 OK 38 114 7 2.5 550 2 14 3 2.5 550 2 6 1
550 10450 4788 OK 0.12 0.00 OK 38 114 7 2.5 550 2 14 3 2.5 550 2 6 1
550 10450 4788 OK 0.12 0.00 OK 38 114 7 2.5 550 2 14 3 2.5 550 2 6 1
100 1900 4788 OK 0.12 0.01 OK 38 114 7 2.5 100 2 14 3 2.5 100 2 6 1
220 4180 4788 OK 0.12 0.08 OK 38 114 7 2.5 220 2 14 3 2.5 220 2 6 1
NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA
57
01/19/2021
NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA
NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA
480 9120 4788 OK 0.12 0.04 OK 38 114 7 2.5 480 2 14 3 2.5 480 2 6 1
480 9120 4788 OK 0.12 0.04 OK 38 114 7 2.5 480 2 14 3 2.5 480 2 6 1
480 9120 4788 OK 0.12 0.00 OK 38 114 7 2.5 480 2 14 3 2.5 480 2 6 1
480 9120 4788 OK 0.12 0.00 OK 38 114 7 2.5 480 2 14 3 2.5 480 2 6 1
100 1900 4788 OK 0.12 0.00 OK 38 114 7 2.5 100 2 14 3 2.5 100 2 6 1
220 4180 4788 OK 0.12 0.08 OK 38 114 7 2.5 220 2 14 3 2.5 220 2 6 1
NA NA
#VALUE! #VALUE! #N/A #VALUE! #VALUE! #VALUE! #VALUE! 7 2.5 NA 2 14 3 2.5 NA 2 6 0
NA NA
#VALUE! #VALUE! #N/A #VALUE! #VALUE! #VALUE! #VALUE! 7 2.5 NA 2 14 3 2.5 NA 2 6 0
NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA
420 7980 4788 OK 0.12 0.04 OK 38 114 7 2.5 420 2 14 3 2.5 420 2 6 1
420 7980 4788 OK 0.12 0.04 OK 38 114 7 2.5 420 2 14 3 2.5 420 2 6 1
420 7980 4788 OK 0.12 0.04 OK 38 114 7 2.5 420 2 14 3 2.5 420 2 6 1
420 7980 4788 OK 0.12 0.04 OK 38 114 7 2.5 420 2 14 3 2.5 420 2 6 1
NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA
NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA
10
NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA 0
NA NA
#VALUE! #VALUE! #N/A #VALUE! #VALUE! #VALUE! #VALUE! 7 2.5 NA 2 14 3 2.5 NA 2 6 0
10
NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA 0
NA NA
#VALUE! #VALUE! #N/A #VALUE! #VALUE! #VALUE! #VALUE! 7 2.5 NA 2 14 3 2.5 NA 2 6 0
30
NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA 0
58
01/19/2021
NA NA
#VALUE! #VALUE! #N/A #VALUE! #VALUE! #VALUE! #VALUE! 7 2.5 NA 2 14 3 2.5 NA 2 6 0
NA NA
NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA 0
NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA
NA NA
#VALUE! #VALUE! #N/A #VALUE! #VALUE! #VALUE! #VALUE! 7 2.5 NA 2 14 3 2.5 NA 2 6 0
NA NA
NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA 0
NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA 0
59
01/19/2021
NA NA
#VALUE! #VALUE! #N/A #VALUE! #VALUE! #VALUE! #VALUE! 7 2.5 NA 2 14 3 2.5 NA 2 6 0
NA NA
#VALUE! #VALUE! #N/A #VALUE! #VALUE! #VALUE! #VALUE! 7 2.5 NA 2 14 3 2.5 NA 2 6 0
NA NA
#VALUE! #VALUE! #N/A #VALUE! #VALUE! #VALUE! #VALUE! 7 2.5 NA 2 14 3 2.5 NA 2 6 0
NA NA
#VALUE! #VALUE! #N/A #VALUE! #VALUE! #VALUE! #VALUE! 7 2.5 NA 2 14 3 2.5 NA 2 6 0
NA NA
#VALUE! #VALUE! #N/A #VALUE! #VALUE! #VALUE! #VALUE! 7 2.5 NA 2 14 3 2.5 NA 2 6 0
NA NA
#VALUE! #VALUE! #N/A #VALUE! #VALUE! #VALUE! #VALUE! 7 2.5 NA 2 14 3 2.5 NA 2 6 0
NA NA
#VALUE! #VALUE! #N/A #VALUE! #VALUE! #VALUE! #VALUE! 7 2.5 NA 2 14 3 2.5 NA 2 6 0
NA NA
#VALUE! #VALUE! #N/A #VALUE! #VALUE! #VALUE! #VALUE! 7 2.5 NA 2 14 3 2.5 NA 2 6 0
NA NA
NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA 0
NA NA
#VALUE! #VALUE! #N/A #VALUE! #VALUE! #VALUE! #VALUE! 7 2.5 NA 2 14 3 2.5 NA 2 6 0
NA NA
#VALUE! #VALUE! #N/A #VALUE! #VALUE! #VALUE! #VALUE! 7 2.5 NA 2 14 3 2.5 NA 2 6 0
NA NA
#VALUE! #VALUE! #N/A #VALUE! #VALUE! #VALUE! #VALUE! 7 2.5 NA 2 14 3 2.5 NA 2 6 0
NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA 0
60
01/19/2021
NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA
NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA
NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA
NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA 0
NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA
NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA 0
NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA
NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA
NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA
NA
NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA 0
61
01/19/2021
NA
NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA 0
NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA
NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA
NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA
NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA
NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA 0
500 1000 144 OK 0.93 2.63 CHECK 4 12 7 2.5 500 2 14 3 2.5 500 2 6 1
62
01/19/2021
NA NA
#VALUE! #VALUE! #N/A #VALUE! #VALUE! #VALUE! #VALUE! 7 2.5 NA 2 14 3 2.5 NA 2 6 0
NA NA
#VALUE! #VALUE! #N/A #VALUE! #VALUE! #VALUE! #VALUE! 7 2.5 NA 2 14 3 2.5 NA 2 6 0
NA NA
#VALUE! #VALUE! #N/A #VALUE! #VALUE! #VALUE! #VALUE! 7 2.5 NA 2 14 3 2.5 NA 2 6 0
NA NA
#VALUE! #VALUE! #N/A #VALUE! #VALUE! #VALUE! #VALUE! 7 2.5 NA 2 14 3 2.5 NA 2 6 0
NA NA
#VALUE! #VALUE! #N/A #VALUE! #VALUE! #VALUE! #VALUE! 7 2.5 NA 2 14 3 2.5 NA 2 6 0
NA NA
#VALUE! #VALUE! #N/A #VALUE! #VALUE! #VALUE! #VALUE! 7 2.5 NA 2 14 3 2.5 NA 2 6 0
NA NA
#VALUE! #VALUE! #N/A #VALUE! #VALUE! #VALUE! #VALUE! 7 2.5 NA 2 14 3 2.5 NA 2 6 0
NA NA
NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA 0
NA NA
#VALUE! #VALUE! #N/A #VALUE! #VALUE! #VALUE! #VALUE! 7 2.5 NA 2 14 3 2.5 NA 2 6 0
NA NA
NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA 0
NA NA
#VALUE! #VALUE! #N/A #VALUE! #VALUE! #VALUE! #VALUE! 7 2.5 NA 2 14 3 2.5 NA 2 6 0
NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA 0
63
01/19/2021
NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA 0
NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA 0
NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA 0
NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA 0
NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA 0
NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA 0
NA
NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA 0
NA
NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA 0
NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA 0
NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA 0
64
01/19/2021
NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA 0
NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA 0
NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA 0
NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA 0
NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA 0
NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA 0
NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA 0
65
01/19/2021
NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA 0
NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA 0
NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA 0
NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA 0
NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA 0
NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA 0
NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA 0
66
01/19/2021
From Specs. /
Vol 2A - Particular
Qty to be taken from the sheet Assumptuons /
Spec - Electrical
Qualifications
in Panels outgoing
8 APFC 20 % Spare Units
feeders
Doc. To be taken
2 Panel Schedule
3 TF Sizing calculation
11/3.3kV
415V DG Set
Transformer
67
01/19/2021
KVA After
KVA After considering
considering 20% 74.73 KVA #REF! KVA
10% contingency
contingency
Required TF
100 KVA Required TF capacity 800 KVA
capacity
TTB
68
01/19/2021
415V APFC
VFD 330.00 KW
69
01/19/2021
70
01/19/2021
Calculation to check the starting of Largest size motor Calculation to check the starting of Largest size motor
Rating of the largest size motor 375.00 kW Rating of the largest size motor 110.00
Effciency of Largest size motor 0.96 Effciency of Largest size motor 0.95
Load of of Largest size motor 0.8 Load of of Largest size motor 0.8
Demand of Largest size motor 1.00 Demand of Largest size motor 1.00
Rating of the largest size motor in kVA 348 kVA Rating of the largest size motor in kVA 105
Base load of Transformer before starting largest motor 4652 kVA Base load of Transformer before starting largest motor 2395
Motor starting kVA with DOL start 2436 kVA Motor starting kVA with DOL start 735
Motor starting kVA with SOFT/VFD start 1044 kVA Motor starting kVA with SOFT/VFD start 315
Fault level at Transformer secondary side 71.43 MVA Fault level at Transformer secondary side 40.00
Fault current at Transformer secondary side 12.50 kA Fault current at Transformer secondary side 57.74
71
01/19/2021
Voltage drop
at Voltage drop at
transformer transformer
terminal terminal when
10 within 10% 8
when largest largest motor
motor start start with DOL
with DOL starting
starting
Voltage
drop at Voltage drop
transforme at
r terminal transformer
when terminal
largest 8 within 10% when largest 7
motor start motor start
with S- with S-D/VFD
D/VFD starting
starting
TTB STB
72
01/19/2021
Calculation to check the starting of Largest size motor Calculation to check the starting of Largest size motor
kW Rating of the largest size motor 75.00 kW Rating of the largest size motor
kVA Rating of the largest size motor in kVA 72 kVA Rating of the largest size motor in kVA
kVA Base load of Transformer before starting largest motor 928 kVA Base load of Transformer before starting largest motor
kVA Motor starting kVA with DOL start 504 kVA Motor starting kVA with DOL start
kVA Motor starting kVA with SOFT/VFD start 216 kVA Motor starting kVA with SOFT/VFD start
MVA Fault level at Transformer secondary side 20.00 MVA Fault level at Transformer secondary side
kA Fault current at Transformer secondary side 28.87 kA Fault current at Transformer secondary side
73
01/19/2021
74
01/19/2021
Calculation to check the starting of Largest size motor Calculation to check the starting of Largest size motor
7500 kVA Rating of Transformer assumed 1500 kVA Rating of Transformer assumed
660.00 kW Rating of the largest size motor 110.00 kW Rating of the largest size motor
0.96 Effciency of Largest size motor 0.95 Effciency of Largest size motor
0.8 Load of of Largest size motor 0.8 Load of of Largest size motor
1.00 Demand of Largest size motor 1.00 Demand of Largest size motor
603 kVA Rating of the largest size motor in kVA 105 kVA Rating of the largest size motor in kVA
6897 kVA Base load of Transformer before starting largest motor 1395 kVA Base load of Transformer before starting largest motor
4222 kVA Motor starting kVA with DOL start 735 kVA Motor starting kVA with DOL start
1809 kVA Motor starting kVA with SOFT/VFD start 315 kVA Motor starting kVA with SOFT/VFD start
107.14 MVA Fault level at Transformer secondary side 24.00 MVA Fault level at Transformer secondary side
18.75 kA Fault current at Transformer secondary side 34.64 kA Fault current at Transformer secondary side
75
01/19/2021
76
01/19/2021
gest size motor Calculation to check the starting of Largest size motor
ng largest motor 1178 kVA Base load of Transformer before starting largest motor 382 kVA
501 kVA Motor starting kVA with DOL start 128 kVA
77
01/19/2021
Voltage drop at
transformer
terminal when
7 within 10% 6 within 10%
largest motor
start with DOL
starting
Voltage drop
at
transformer
terminal
6 within 10% when largest 5 within 10%
motor start
with S-D/VFD
starting
78
01/19/2021
Panel Name
Breaker
16
32
63
100
125
160
200
250
315
400
630
800
1000
1250
1600
2000
2500
3200
79
01/19/2021
4000
Total(Inclusive
of Spares
without
Marshalling
Panel)
Total
Total(Inclusive
of Spares and
Marshalling
Panel)
80
01/19/2021
81
01/19/2021
Total(Inclusive Total(Inclusive
of Spares of Spares
without without
Marshalling Marshalling
Panel) Panel)
Total(Inclusive Total(Inclusive
of Spares and of Spares and
Marshalling Marshalling
Panel) Panel)
82
01/19/2021
MCC-3(Unit MCC-2(Unit
2 0.33 267 16 38 6.33 5067 16 0
6300)16 6350)16
MCC-3(Unit MCC-2(Unit
4 0.67 533 32 0 0.00 0 32 0
6300)32 6350)32
MCC-3(Unit MCC-2(Unit
0 0.00 0 63 0 0.00 0 63 2
6300)63 6350)63
MCC-3(Unit MCC-2(Unit
0 0.00 0 100 0 0.00 0 100 0
6300)100 6350)100
MCC-3(Unit MCC-2(Unit
0 0.00 0 125 0 0.00 0 125 0
6300)125 6350)125
MCC-3(Unit MCC-2(Unit
0 0.00 0 160 0 0.00 0 160 0
6300)160 6350)160
MCC-3(Unit MCC-2(Unit
6 2.00 1600 200 0 0.00 0 200 0
6300)200 6350)200
MCC-3(Unit MCC-2(Unit
0 0.00 0 250 0 0.00 0 250 0
6300)250 6350)250
MCC-3(Unit MCC-2(Unit
2 0.67 533 315 4 1.33 1067 315 0
6300)315 6350)315
MCC-3(Unit MCC-2(Unit
0 0.00 0 400 0 0.00 0 400 0
6300)400 6350)400
MCC-3(Unit MCC-2(Unit
0 0.00 0 630 0 0.00 0 630 0
6300)630 6350)630
MCC-3(Unit MCC-2(Unit
0 0.00 0 800 1 1.00 800 800 7
6300)800 6350)800
MCC-3(Unit MCC-2(Unit
0 0.00 0 1000 0 0.00 0 1000 0
6300)1000 6350)1000
MCC-3(Unit MCC-2(Unit
0 0.00 0 1250 0 0.00 0 1250 0
6300)1250 6350)1250
MCC-3(Unit MCC-2(Unit
1 1.00 800 1600 0 0.00 0 1600 0
6300)1600 6350)1600
MCC-3(Unit MCC-2(Unit
0 0.00 0 2000 0 0.00 0 2000 0
6300)2000 6350)2000
MCC-3(Unit MCC-2(Unit
0 0.00 0 2500 0 0.00 0 2500 0
6300)2500 6350)2500
MCC-3(Unit MCC-2(Unit
0 0.00 0 3200 0 0.00 0 3200 2
6300)3200 6350)3200
83
01/19/2021
MCC-3(Unit MCC-2(Unit
0 0.00 0 4000 0 0.00 0 4000 0
6300)4000 6350)4000
Total(Inclusiv Total(Inclusiv
e of Spares e of Spares
without without
Marshalling Marshalling
Panel) Panel)
Total(Inclusiv Total(Inclusiv
e of Spares e of Spares
and and
Marshalling Marshalling
Panel) Panel)
84
01/19/2021
MCC-4(Unit MCC-6(Unit
Panel Name Panel Name
6320) 6320)
85
01/19/2021
Total(Inclusiv Total(Inclusiv
e of Spares e of Spares
without without
Marshalling Marshalling
Panel) Panel)
Total(Inclusiv Total(Inclusiv
e of Spares e of Spares
and and
Marshalling Marshalling
Panel) Panel)
86
01/19/2021
MCC-5(Unit
Panel Name Panel Name Err:509
6330)
MCC-6(Unit MCC-5(Unit
16 6 1.00 800 16 0 0.00 0 Err:509
6320)16 6330)16
MCC-6(Unit MCC-5(Unit
32 1 0.17 133 32 0 0.00 0 Err:509
6320)32 6330)32
MCC-6(Unit MCC-5(Unit
63 1 0.25 200 63 0 0.00 0 Err:509
6320)63 6330)63
MCC-6(Unit MCC-5(Unit
100 4 1.00 800 100 0 0.00 0 Err:509
6320)100 6330)100
MCC-6(Unit MCC-5(Unit
125 0 0.00 0 125 0 0.00 0 Err:509
6320)125 6330)125
MCC-6(Unit MCC-5(Unit
160 0 0.00 0 160 0 0.00 0 Err:509
6320)160 6330)160
MCC-6(Unit MCC-5(Unit
200 0 0.00 0 200 0 0.00 0 Err:509
6320)200 6330)200
MCC-6(Unit MCC-5(Unit
250 0 0.00 0 250 0 0.00 0 Err:509
6320)250 6330)250
MCC-6(Unit MCC-5(Unit
315 2 0.67 533 315 0 0.00 0 Err:509
6320)315 6330)315
MCC-6(Unit MCC-5(Unit
400 0 0.00 0 400 0 0.00 0 Err:509
6320)400 6330)400
MCC-6(Unit MCC-5(Unit
630 0 0.00 0 630 0 0.00 0 Err:509
6320)630 6330)630
MCC-6(Unit MCC-5(Unit
800 1 1.00 800 800 0 0.00 0 Err:509
6320)800 6330)800
MCC-6(Unit MCC-5(Unit
1000 0 0.00 0 1000 0 0.00 0 Err:509
6320)1000 6330)1000
MCC-6(Unit MCC-5(Unit
1250 0 0.00 0 1250 0 0.00 0 Err:509
6320)1250 6330)1250
MCC-6(Unit MCC-5(Unit
1600 0 0.00 0 1600 0 0.00 0 Err:509
6320)1600 6330)1600
MCC-6(Unit MCC-5(Unit
2000 0 0.00 0 2000 0 0.00 0 Err:509
6320)2000 6330)2000
MCC-6(Unit MCC-5(Unit
2500 0 0.00 0 2500 0 0.00 0 Err:509
6320)2500 6330)2500
MCC-6(Unit MCC-5(Unit
3200 0 0.00 0 3200 0 0.00 0 Err:509
6320)3200 6330)3200
87
01/19/2021
MCC-6(Unit MCC-5(Unit
4000 0 0.00 0 4000 0 0.00 0 Err:509
6320)4000 6330)4000
Total(Inclusiv Total(Inclusiv
e of Spares e of Spares
without without
Marshalling Marshalling
Panel) Panel)
Total(Inclusiv Total(Inclusiv
e of Spares e of Spares
and and
Marshalling Marshalling
Panel) Panel)
88
01/19/2021
MCC-1(Unit MCC-2(Unit
Panel Name PCC-6340 Panel Name Panel Name
6340) 6340)
MCC-1(Unit
16 0 0.00 0 PCC-634016 16 29 4.83 3867 16 36
6340)16
MCC-1(Unit
32 1 0.17 133 PCC-634032 32 0 0.00 0 32 11
6340)32
MCC-1(Unit
63 6 1.50 1200 PCC-634063 63 6 1.50 1200 63 10
6340)63
MCC-1(Unit
100 0 0.00 0 PCC-6340100 100 0 0.00 0 100 7
6340)100
MCC-1(Unit
125 2 0.50 400 PCC-6340125 125 0 0.00 0 125 0
6340)125
MCC-1(Unit
160 1 0.25 200 PCC-6340160 160 0 0.00 0 160 16
6340)160
MCC-1(Unit
200 0 0.00 0 PCC-6340200 200 3 1.00 800 200 0
6340)200
MCC-1(Unit
250 2 0.67 533 PCC-6340250 250 0 0.00 0 250 0
6340)250
MCC-1(Unit
315 7 2.33 1867 PCC-6340315 315 0 0.00 0 315 0
6340)315
MCC-1(Unit
400 0 0.00 0 PCC-6340400 400 0 0.00 0 400 0
6340)400
MCC-1(Unit
630 1 1.00 800 PCC-6340630 630 0 0.00 0 630 1
6340)630
MCC-1(Unit
800 4 4.00 3200 PCC-6340800 800 1 1.00 800 800 0
6340)800
PCC- MCC-1(Unit
1000 3 3.00 2400 1000 0 0.00 0 1000 0
63401000 6340)1000
PCC- MCC-1(Unit
1250 0 0.00 0 1250 0 0.00 0 1250 0
63401250 6340)1250
PCC- MCC-1(Unit
1600 0 0.00 0 1600 0 0.00 0 1600 0
63401600 6340)1600
PCC- MCC-1(Unit
2000 5 5.00 4000 2000 0 0.00 0 2000 0
63402000 6340)2000
PCC- MCC-1(Unit
2500 0 0.00 0 2500 0 0.00 0 2500 0
63402500 6340)2500
PCC- MCC-1(Unit
3200 0 0.00 0 3200 0 0.00 0 3200 0
63403200 6340)3200
89
01/19/2021
PCC- MCC-1(Unit
4000 0 0.00 0 4000 0 0.00 0 4000 0
63404000 6340)4000
90
01/19/2021
MCC-3(Unit
Panel Name PCC-6340 Panel Name
6340)
MCC-2(Unit
6.00 4800 16 0 0.00 0 PCC-634016 16 0 0.00 0
6340)16
MCC-2(Unit
1.83 1467 32 1 0.17 133 PCC-634032 32 0 0.00 0
6340)32
MCC-2(Unit
2.50 2000 63 6 1.50 1200 PCC-634063 63 0 0.00 0
6340)63
MCC-2(Unit
1.75 1400 100 0 0.00 0 PCC-6340100 100 0 0.00 0
6340)100
MCC-2(Unit
0.00 0 125 2 0.50 400 PCC-6340125 125 0 0.00 0
6340)125
MCC-2(Unit
4.00 3200 160 1 0.25 200 PCC-6340160 160 0 0.00 0
6340)160
MCC-2(Unit
0.00 0 200 0 0.00 0 PCC-6340200 200 0 0.00 0
6340)200
MCC-2(Unit
0.00 0 250 2 0.67 533 PCC-6340250 250 0 0.00 0
6340)250
MCC-2(Unit
0.00 0 315 7 2.33 1867 PCC-6340315 315 0 0.00 0
6340)315
MCC-2(Unit
0.00 0 400 0 0.00 0 PCC-6340400 400 0 0.00 0
6340)400
MCC-2(Unit
1.00 800 630 1 1.00 800 PCC-6340630 630 0 0.00 0
6340)630
MCC-2(Unit
0.00 0 800 4 4.00 3200 PCC-6340800 800 1 1.00 800
6340)800
MCC-2(Unit PCC-
0.00 0 1000 3 3.00 2400 1000 0 0.00 0
6340)1000 63401000
MCC-2(Unit PCC-
0.00 0 1250 0 0.00 0 1250 0 0.00 0
6340)1250 63401250
MCC-2(Unit PCC-
0.00 0 1600 0 0.00 0 1600 0 0.00 0
6340)1600 63401600
MCC-2(Unit PCC-
0.00 0 2000 5 5.00 4000 2000 0 0.00 0
6340)2000 63402000
MCC-2(Unit PCC-
0.00 0 2500 0 0.00 0 2500 0 0.00 0
6340)2500 63402500
MCC-2(Unit PCC-
0.00 0 3200 0 0.00 0 3200 0 0.00 0
6340)3200 63403200
91
01/19/2021
MCC-2(Unit PCC-
0.00 0 4000 0 0.00 0 4000 0 0.00 0
6340)4000 63404000
Total(Inclusiv Total(Inclusiv
e of Spares e of Spares
without without
Marshalling Marshalling
Panel) Panel)
Total(Inclusiv Total(Inclusiv
e of Spares e of Spares
and and
Marshalling Marshalling
Panel) Panel)
92
01/19/2021
MCC-4(Unit
Panel Name Panel Name PCC-6360
6340)
MCC-3(Unit MCC-4(Unit
16 1 0.17 133 16 0 0.00 0 PCC-636016
6340)16 6340)16
MCC-3(Unit MCC-4(Unit
32 0 0.00 0 32 0 0.00 0 PCC-636032
6340)32 6340)32
MCC-3(Unit MCC-4(Unit
63 0 0.00 0 63 2 0.50 400 PCC-636063
6340)63 6340)63
MCC-3(Unit MCC-4(Unit
100 2 0.50 400 100 0 0.00 0 PCC-6360100
6340)100 6340)100
MCC-3(Unit MCC-4(Unit
125 0 0.00 0 125 0 0.00 0 PCC-6360125
6340)125 6340)125
MCC-3(Unit MCC-4(Unit
160 3 0.75 600 160 0 0.00 0 PCC-6360160
6340)160 6340)160
MCC-3(Unit MCC-4(Unit
200 0 0.00 0 200 0 0.00 0 PCC-6360200
6340)200 6340)200
MCC-3(Unit MCC-4(Unit
250 0 0.00 0 250 0 0.00 0 PCC-6360250
6340)250 6340)250
MCC-3(Unit MCC-4(Unit
315 0 0.00 0 315 0 0.00 0 PCC-6360315
6340)315 6340)315
MCC-3(Unit MCC-4(Unit
400 0 0.00 0 400 2 1.00 800 PCC-6360400
6340)400 6340)400
MCC-3(Unit MCC-4(Unit
630 0 0.00 0 630 3 3.00 2400 PCC-6360630
6340)630 6340)630
MCC-3(Unit MCC-4(Unit
800 0 0.00 0 800 0 0.00 0 PCC-6360800
6340)800 6340)800
MCC-3(Unit MCC-4(Unit PCC-
1000 1 1.00 800 1000 3 3.00 2400
6340)1000 6340)1000 63601000
MCC-3(Unit MCC-4(Unit PCC-
1250 0 0.00 0 1250 0 0.00 0
6340)1250 6340)1250 63601250
MCC-3(Unit MCC-4(Unit PCC-
1600 0 0.00 0 1600 0 0.00 0
6340)1600 6340)1600 63601600
MCC-3(Unit MCC-4(Unit PCC-
2000 0 0.00 0 2000 0 0.00 0
6340)2000 6340)2000 63602000
MCC-3(Unit MCC-4(Unit PCC-
2500 0 0.00 0 2500 0 0.00 0
6340)2500 6340)2500 63602500
MCC-3(Unit MCC-4(Unit PCC-
3200 0 0.00 0 3200 0 0.00 0
6340)3200 6340)3200 63603200
93
01/19/2021
Total(Inclusiv Total(Inclusiv
e of Spares e of Spares
without without
Marshalling Marshalling
Panel) Panel)
Total(Inclusiv Total(Inclusiv
e of Spares e of Spares
and and
Marshalling Marshalling
Panel) Panel)
94
01/19/2021
MCC-5(Unit MCC-6(Unit
Panel Name Panel Name Breaker Size in each Compartment
6360) 6360)
No of Cubicles
Panel and Panel and
Breaker Quantity No of verticals 800 Breaker Quantity No of verticals 800 Breaker in each
Breaker Breaker Compartment
MCC-5(Unit MCC-6(Unit
16 40 6.67 5333 16 5 0.83 667 16 6
6360)16 6360)16
MCC-5(Unit MCC-6(Unit
32 0 0.00 0 32 0 0.00 0 32 6
6360)32 6360)32
MCC-5(Unit MCC-6(Unit
63 7 1.75 1400 63 0 0.00 0 63 4
6360)63 6360)63
MCC-5(Unit MCC-6(Unit
100 0 0.00 0 100 0 0.00 0 100 4
6360)100 6360)100
MCC-5(Unit MCC-6(Unit
125 0 0.00 0 125 0 0.00 0 125 4
6360)125 6360)125
MCC-5(Unit MCC-6(Unit
160 0 0.00 0 160 0 0.00 0 160 4
6360)160 6360)160
MCC-5(Unit MCC-6(Unit
200 0 0.00 0 200 0 0.00 0 200 3
6360)200 6360)200
MCC-5(Unit MCC-6(Unit
250 0 0.00 0 250 0 0.00 0 250 3
6360)250 6360)250
MCC-5(Unit MCC-6(Unit
315 3 1.00 800 315 3 1.00 800 315 3
6360)315 6360)315
MCC-5(Unit MCC-6(Unit
400 0 0.00 0 400 1 0.50 400 400 2
6360)400 6360)400
MCC-5(Unit MCC-6(Unit
630 1 1.00 800 630 0 0.00 0 630 1
6360)630 6360)630
MCC-5(Unit MCC-6(Unit
800 0 0.00 0 800 0 0.00 0 800 1
6360)800 6360)800
MCC-5(Unit MCC-6(Unit
1000 0 0.00 0 1000 0 0.00 0 1000 1
6360)1000 6360)1000
MCC-5(Unit MCC-6(Unit
1250 0 0.00 0 1250 0 0.00 0 1250 1
6360)1250 6360)1250
MCC-5(Unit MCC-6(Unit
1600 0 0.00 0 1600 0 0.00 0 1600 1
6360)1600 6360)1600
MCC-5(Unit MCC-6(Unit
2000 0 0.00 0 2000 0 0.00 0 2000 1
6360)2000 6360)2000
MCC-5(Unit MCC-6(Unit
2500 0 0.00 0 2500 0 0.00 0 2500 1
6360)2500 6360)2500
MCC-5(Unit MCC-6(Unit
3200 0 0.00 0 3200 0 0.00 0 3200 1
6360)3200 6360)3200
95
01/19/2021
MCC-5(Unit MCC-6(Unit
4000 0 0.00 0 4000 0 0.00 0 4000 1
6360)4000 6360)4000
Total(Inclusiv Total(Inclusiv
e of Spares e of Spares
Marshalling
without without Panel
1
Marshalling Marshalling
Panel) Panel)
Total(Inclusiv Total(Inclusiv
e of Spares e of Spares
and and
Marshalling Marshalling
Panel) Panel)
96
01/19/2021
in each Compartment
28,000.0
55,000.0
55,000.0
55,000.0
90,000.0
90,000.0
90,000.0
142,689.5
145,511.5
154,253.8
185,907.8
197,642.0
308,635.0
308,635.0
308,635.0
97
01/19/2021
98
Project: Muntinlupa STP
Client : Maynilad
6 LT Busduct - 2500 & 2000 A 2550000 LT Busduct - 2000 & 2000 A 2033600 Increase in rating &
length
8 415V, Capacitor bank , Cu. 665000 415V, Capacitor bank , Cu. 682500
busbar - 350kVAR busbar - 400kVAR
11 UPS (5kVA - 3 nos) 3000000 UPS (7.5kVA - 1 nos) 1000000 Increase in qty
18 Lighting & Small power 3491013 Lighting & Small power system 3287705
system
1 x 36W Batten Toilet block / Wash Room - Emergency back-up one hour Err:509 Nos
Emergency light unit working on 230 volts. A.C. with self containing battery
unit with 20 watts 600 mm long florescent lamp type ‘SWITCH ON MAIN
FAILTURE. It shall be electronic automatic fluorescent type which
incorporates a unit trickle charge circuit, which shall prevent over charging or 15 Nos
maintenance free battery to provide 1 hours illumination following power
failure. The units shall generally conform to IS 9583.
Outdoor Lights
Post top lantern type Gate lights , weather proof, suitable for Metal halide
lamp 70/150 watts and shall conform to IS 2149, Opel white one piece double
conical dome made of vandal proof high density polyethylene resistant to 12 Nos
ultra violet
radiation and heat with IP 43, die cast Aluminium MEV treated. The pressure
ring shall be dia cast Aluminium M.B.V. treated.
Post top lantern type Gate lights , weather proof, suitable for Metal halide
lamp 70/150 watts and shall conform to IS 2149, Opel white one piece double
conical dome made of vandal proof high density polyethylene resistant to
ultra violet
0 Nos
radiation and heat with IP 43, die cast Aluminium MEV treated. The pressure
ring shall be dia cast Aluminium M.B.V. treated. - Emergency back-up one
hour
1 x 70W HPSV type complete with all accessories and shall be Deep drawn
Aluminium reflector stove enameled grey outside and brightened and
55 Nos
anodized inside lined with felt gasket to prevent insect entry. - (Periphery
lighting)
1 x 70W HPSV type complete with all accessories and shall be Deep drawn
Aluminium reflector stove enameled grey outside and brightened and
5 Nos
anodized inside lined with felt gasket to prevent insect entry. - Emergency
back-up one hour
1 x 150W HPSV type complete with all accessories and shall be Deep drawn
Aluminium reflector stove enameled grey outside and brightened and
40 Nos
anodized inside lined with felt gasket to prevent insect entry. ( AREA lighting
near tanks and other outdoor structures)
Non integral 1x250W HPSV Fl. Ftg.- street light fittisng for Road illumination 10 Nos
Flood light of H.P.S.V. SON – 400 W / 250 V lamp complete with all
2 Nos
accessories with minimum of IP54
Fans
1200/900 mm sweep ceiling fan 25 Nos
600 mm sweep exhaust fan 35 Nos
Modular switches ,sockets ,fan regulators as required with modular plate
,switch socket and cover plates
5A Socket Outlet 250 Nos
15A Socket Outlet 100 Nos
20A, 240V, 50 Hz, 3 pin Power socket 80 Nos
32A, 240V, 50 Hz, 3 pin Power socket 55 Nos
63A, 240V, 50 Hz, 3 pin Power socket 30 Nos
Welding Socket 1 Nos
Wattage (unit) Wattage (Total)
72 7200
72 720
72 2880
72 Err:509
36 900
36 Err:509
20 300
70 840
70 0
70 3850
70 350
150 6000
250 2500
400 800
80 2000
30 1050
20 5000
35 3500
75 6000
100 5500
150 4500
200 200
Err:509