You are on page 1of 14
TOMY. | Servicelanua Michael's Collection CONTENTS TECHNICAL SPECIFICATIONS OMNIBOT CHANGE PARTS:--~ TROUBLESHOOTING~ ASSEMBLY DIAGRAM ~~ Michael's Collection TECHNICAL SPECIFICATIONS 1. CASSETTE RECORDER 4. RECHARGEABLE BATTERY Type: 2 track monaural ‘Type: sealed lead acid Tape Selection: normal bias only Output Rating: 6V, 4.0Ah Tape Speed: + 0.3% Physical Size: 2%°L x 134°W x 4"H Wow & Flutter: within 0.3% Terminals/Connectors: lead wires with coaxial “barre! 2. ALARM CLOCK mr Display: liquid crystal display 8. GENERAL Accuracy: + 3 sec/day Battery Life: 4 hours continuous at 5.5Voits (normal) Power Supply: 1.5V alkaline size UM-3, 2 required Battery Indicator: red light indicates when discharged Battery Life: 5.000 hours typical to 5.7 Volts Operating Tem °C ~40°C(41°F ~ 104°F) 3. BATTERY CHARGER So a ‘Type: plug-in AC adapter with 6-foot-cord and comial 6. ACCESSORIES “barrel type” connector, (negative center pole) Detachable Tray (included): 1kg maximum weight Output: 6.4VDC, 400 mA allowance External Auxiiary Microphone: Dynamic Microphone, {"mini-plug, 300~600 OHM impedance {not included) 7. OPERATING FREQUENCY: 49.860 MHz OMNIBOT CHANGE PARTS INDIVIDUAL CHANGE PARTS ASSEMBLY CHANGE PARTS No. PARTS: No. ASSEMBLY PARTS: ce [ercaes 2 | windatiota 2 | igh Arm Assombly | nemay Bo | Euarpains assarnty 4 Robot Antenna 4 | Clock Assembly 5 | eat cover 5) | veseeces ascoreay (with Truss Screw) {including the main board) 6 Arm Links (Large) 6 Base Assembly and (Small) (including the gear box) Are 0-neg 7 | vances asseouty | 7 8 | Speaker 9 | Sounducer 10 | Battery Recharger : 11 | Base Board 12. | Tray 13 | Transmitter Antenna 14 | Battery Cover Michael's Collection TROUBLE-SHOOTING SYMPTOM CAUSE REPAIR CLOCK PART * Does not function. © Change clock unit CASSETTE PART © Does not run (curves) '®No microphone sound during tracing © No sound when ‘external microphone is used © Tape cannot be recorded or played back ° Sound volume adjusting knob cannot be adjusted ° Noise ° Cassette section unit does not eject externally + Motor drive (chip) damage © Damaged relay * Shielded wire solder is removed © Damaged semi-fixed resistor (Microphone volume adjusting knob) ° Stained head ad life ° Broken recording lever © Damaged RECORD/PLAYBACK switch * Damaged sound volume adjusting knob ditto * Slipped spring * Check mechanical part motor © Change main board © Change main board ° Resolder © Change semi-fixed resistor (Microphone volume adjusting knob) * Clean head © Change mechanical parts ° Change lever * Change amplifier board * Change sound volume adjusting knob ditto BASE ASSEMBLY © Does not run ° Curves © Caster is not smooth ° Damaged motor ° Damaged motor © Wear, low oil, dust » Change gear box ® Change gear box ° Supply oil, clean or change base caster. TRANSMITTER ASSEMBLY © Wireless microphone is not functioning * Power cannot be fed * LED is not lit * Cannot be operated » Damaged talk switch * Damaged main switch ° Damaged LED ° Damaged joy stick © Change transmitter sot ditto ditto editto BATTERY CHARGER © Cannot be recharged * Damaged connector * Damaged adaptor ® Change battery charger ditto © Left arm cannot lift article * Damaged spring * Battery life | = Change battery T ‘ARM ASSEMBLY (Right and Left) ° Anticle cannot be lifted * Damaged link | * Change link * Loose tamping * Worn O-ring * Change O-ring Change left arm Michael's Collection -4 Michael's Collection CLOCK ASSEMBLY DIAGRAM CLOCK PLATE a INTERCONNECTOR \ Leo Dummy Connector CRYSTAL O.01uF Ls) 3-P FLAT CABLE: 4-P FLAT CABLE White Line (Be Cautious About Direction) Z White Line (Be Cau tious ‘To Main Board About Direction) To Main Board To cnt ToCN2 a6 Michael's Collection SEMI-FIXED BOARD DIAGRAM EARPHONE JACK ‘SEMI-FIXED VARIABLE RESISTOR Solder SEMI-FIXED. BOARD ajo Yo Main Board = To SEMLFIXED BOARD Gear (For Steering Correction) foe BATTERY t s ® cLock secrion 4-P FLAT CABLE | | CLOCK POWER ctock SECTION SPEAKER ‘Smal Flat HEAD LEO CABLE ‘SPEAKER ‘Lao? o-pn——+] B Main Unit HARNESS: B V7 VOLUME CONTROL BOARD. ‘SEMI-FIXED BOARD (For Tape Recorder) MAIN BOARD DETAIL Michael's Collection -T- SOUND VOLUME ADJUSTING BOARD Connection Positions between Amplifier Board and Volume Control Board. Amplifier Board | Volume Control Board (Black) — Right (Wie y 2-Conductor Shilded Wire (Brown) (Blacks —— To Main Board |\1-Conductor Shielded Wire (Grey) (wi 5 Amplifier Board (Front Side) NOTE: Dotted lines show jumper wires on back, NOTE: Parts are not shown : 9-PIN HARNESS Connection Positions of 9-pin Harness (Soldering) 3-89 Hares | Connection Postion | Cassette Mechaniom Red | leaf switch Brown Cetin tanta ‘Orange | Amplifier board No_3 Yellow | Amplifier board No. 4 Green [Amplifier board No. 5 Water Color | Amplifier board No.6 Purple Ampitier board No.7 Grey Ampitfor board No. 8 White 3 EARTH LUG (2) i SIGNAL wiRe| tus (1) ‘wie Connection Positions of Cassette Mechanism (Soldering) R/P Head (| tug (1) ‘Connect using CASSETTE MECHANISM en engi] een Front Sete Earth lug (1) Earth lug (2) pened Leaf switch (L) | Motor side Cord color (Red) f/P Hood (U) | Ampifer board 6 | t-candter AUP Head (RV —| Amir board € | Biel Michael's Collection MAIN BOARD AND RECORDER ASSEMBLY DIAGRAM. ? | 2 MAIN SWITCH — pa \. 8-Pin Harmess 1 J TAPE RECORDER STOPPER KNOB——> NS (left Lever (Righe a Spring 8 a RECORDER CASE (Top) xe | Sound Volume Acjust- ing Control Knob TAPE RECORDER ie CASE (Bottom) Michael's Collection 2618109) ong (svone207 2) aumova ass 7 usonannos wwounvo | 98400 (ps 09) pus te punos ssed :310N Guvepios OFA ONIddWL W ONIdd VL, vt F QNiddvL ONIddv Y ee IS SSS © YIM Gva1 dS. uanvads — (A— SS S— 738¥7 (vous) LINA NIV WV¥OVIG ATSWASSY aGIS VAY (10014) LIND NIV ens 738V7 (04S) LIND NIVW. Michael's Collection (01 060d se owes oun 5 eovonbes Burss900%0 ot ONIddvt 2PPS v + mauos oniddvim 9S) uv Vv = ¥OLI3NNOD 394VHO- ee = (wz-omwh Pra auIm ava dt 3UIM avai d= voos7—— (ez-omv) poy 3UIMGVST dL sepios © MAYS ONIddvL + —! U sepios YW MaHOS ONIddVL = uv TF iyz-omv) Se om wo19aNN HIM OVI) d-Z oe eed 3OWVHO WV¥OVIG ATEINaSSY 3GIS HWY (19°8) LIND NIV mana miu) EW (ops 0H, wou dors NOLO) 131343 (opis 1u03 woy dors Nounvo) 137343 ~4MaUDS ONIddvL — -4M3UDS ONIdd VL v ‘quvO8 G3XIs-IW3S Michael's Collection Quosg) LINA NIV (eeu) LIND NIV aa Michael's Collection BODY OVERALL ASSEMBLY = S Michael's Collection == TOMY TOMY KOGYO CO.,INC. 9-10. Tateishi, 7-chome, katsushika-ku, Tokyo, Japan Printed in Japan Michael's Collection

You might also like