Professional Documents
Culture Documents
STRS5703 PDF
STRS5703 PDF
Data Sheet
28114.1*
OFF-LINE SWITCHING REGULATOR
– WITH BIPOLAR SWITCHING TRANSISTOR
The STR-S5703 is specifically designed to meet the requirement
for increased integration and reliability in off-line quasi-resonant flyback
COLLECTOR 1 converters with indirect feedback. The device incorporates the primary
COMMON 2
control and proportional drive circuit with a third-generation high-voltage
FAULT bipolar switching transistor.
T
BASE 3
S Crucial system parameters such as maximum ON time and OFF
FAULT
C
SINK 4 DRIVE OSC. LATCH time are fixed during manufacture. Local control circuit decoupling and
.
R
OVER-CURRENT 5
layout are optimized within each device.
U
PROTECTION
Y
+
INHIBIT 6 +
Cycle-by-cycle current limiting, under-voltage lock-out with hyster-
D L
esis, over-voltage protection, and thermal shutdown protect these
REF.
32 V SENSE 7
devices during all normal and overload conditions. Over-voltage
O N
+
DRIVE 8
protection and thermal shutdown are latched after a short delay. A
UVLO
primary-side error amplifier with reference is included to facilitate
P E 03 Dwg. PK-004
required to establish quasi-resonant operation. The inhibit function has
also been expanded to initiate operation in stand-by mode in which the
D C
power supply delivers a small fraction of the steady-state output power.
ABSOLUTE MAXIMUM RATINGS
U E N -
6
Supply Voltage, VIN ........................... 15 V
S
Output Voltage, VCEX ....................... 500 V
impedance and steady-state thermal resistance are satisfied in an over-
molded single-in-line power package.
R
Proven in substantial volumes, this device and its fixed-frequency
N
VEBO ................................................ 7 V
I
Continuous Output Current,
T R counterparts represents a significant advance in off-line SMPS reliability
E
growth and integration. Similar devices with increased ratings are the
T
IC .................................................. 6.0 A
F
1 ms Single-Pulse Output Current,
S STR-S5707 and STR-S5708.
O N E b y
ICM ................................................. 12 A
Sink Current, IS ................................. 1.5 A
FEATURES
R
■ Quasi-Resonant Operation for Low EMI and High Efficiency
e d
Drive Current, ID .......................... -700 mA
C
Inhibit Voltage, VINH ........................... 15 V
■ Output Power to 140 W
R c
■ Low-Power Output Standby Mode
I S a
Over-Current Protection Voltage Range,
l
■ Indirect Feedback from Auxiliary Winding
D FO ep
VOCP ............................................ ±3.5 V Reduces External Component Count
Insulation Voltage, VWM(RMS) .......... 2000 V ■ Pulse-by-Pulse Over-Current Protection
Package Power Diss., PD ........ See Graph ■ Latched Over-Voltage and Thermal Protection
R
Output Junction Temperature, TJ .. +150°C ■ Third-Generation Switching Transistor with Proportional Drive
—
Internal Frame Temperature, TF ... +125°C
Operating Temperature Range,
TA ............................... -20°C to +125°C
■ Maximum ON Time and Off Time Set During Manufacture
■ Internal Under-Voltage Lockout with Hysteresis
■ Over-Molded SIP with Integral Isolated Heat Spreader
Storage Temperature Range,
Tstg ............................. -40°C to +125°C Always order by complete part number: STR-S5703 .
™
STR-S5703
OFF-LINE
QUASI-RESONANT FLYBACK
SWITCHING REGULATOR
FUNCTIONAL BLOCK DIAGRAM
V INHIBIT
IN
9 6
R
UVLO
SENSE 7 OVER-VOLT. FAULT PROPORTIONAL
PROTECT LATCH DRIVE
S Q 8 DRIVE
1 kΩ
REF.
4 SINK
TSD
OSC.
3 BASE
Rton
1500 pF
+ 1 COLLECTOR
0.75 V
+
2 COMMON
3300 pF Rtoff 1.4 V
-1 V
+
OVER-CURRENT
5
PROTECTION
+
5.1 V
Dwg. FK-001-1
30
60
MOUNTING SURFACE
ALLOWABLE PACKAGE POWER DISSIPATION in WATTS
54 W TEMPERATURE
10
COLLECTOR CURRENT in AMPERES
RECOMMENDED MAX.
40 FRAME TEMP. = +100°C 5.0
3.0
L = 6 mH
IB1 = 2.5 A
LIMITED BY FRAME IB2 = 0.8 A
TEMP. = +125°C MAX. ton = 100 µs
dc < 1%
20
1.0
FREE AIR
0.5
3.2 W
0 0.3
20 60 100 140 0 100 200 300 400 500 600 700
TEMPERATURE in °C COLLECTOR-EMITTER VOLTAGE in VOLTS
Dwg. GK-003-2 Dwg. GK-002-2A
™
115 Northeast Cutoff, Box 15036
Worcester, Massachusetts 01615-0036 (508) 853-5000
Copyright © 1994 Allegro MicroSystems, Inc.
STR-S5703
OFF-LINE
QUASI-RESONANT FLYBACK
SWITCHING REGULATOR
NOTES: Negative current is defined as coming out of (sourcing) the specified device terminal.
Typical Data is for design information only.
www.allegromicro.com
STR-S5703
OFF-LINE
QUASI-RESONANT FLYBACK
SWITCHING REGULATOR
TYPICAL CHARACTERISTICS
100
50
30
DC CURRENT GAIN
VCE= 4 V
10
5.0
3.0
1.0
0.01 0.03 0.1 0.3 1.0 3.0 10 30 100
COLLECTOR CURRENT in AMPERES
Dwg. GK-001-1
™
115 Northeast Cutoff, Box 15036
Worcester, Massachusetts 01615-0036 (508) 853-5000
STR-S5703
OFF-LINE
QUASI-RESONANT FLYBACK
SWITCHING REGULATOR
+ OUTPUT
+ +
7 9 6
R
+
S Q 8
FULL-BRIDGE
AC INPUT
RECTIFIER
+ 4
+
Ð OUTPUT
+ 1
+ 2
+
5
Dwg. EK-005A
APPLICATIONS INFORMATION
WARNING Ñ These devices are designed to be operated at lethal voltages and energy levels.
Circuit designs that embody these components must conform with applicable safety requirements.
Precautions must be taken to prevent accidental contact with power-line potentials.
Do not connect grounded test equipment.
The use of an isolation transformer is recommended during circuit development and breadboarding.
www.allegromicro.com
STR-S5703
OFF-LINE
QUASI-RESONANT FLYBACK
SWITCHING REGULATOR
Dimensions in Inches
(for reference only)
0.953 ±0.008
T REF.
0.610 M
±0.008 0.130 ¿ 0.216
0.118 ±0.008 ±0.008
1.49 ±0.012
0.709 ±0.008
0.130
±0.004
0.276
±0.016
0.216
1 9
0.016 0.100
0.033 0.026
±0.004
+0.008 +0.008
Ð0.004 Ð0.004
0.177
±0.028
PACKAGE LEAD
CENTER CENTER
Dwg. MK-003-9 in
NOTE: Exact body and lead configuration at vendorÕs option within limits shown.
™
115 Northeast Cutoff, Box 15036
Worcester, Massachusetts 01615-0036 (508) 853-5000
STR-S5703
OFF-LINE
QUASI-RESONANT FLYBACK
SWITCHING REGULATOR
Dimensions in Millimeters
(controlling dimensions)
24.2 ±0.2
T REF
15.5 ±0.2 M
3.3 ¿ 5.5
3.0 ±0.2 ±0.2
23.0 ±0.3
18.0 ±0.2
3.3
±0.1
7.0
±0.4
5.5
1 9
0.4 2.54
0.85 0.65
±0.1
+0.2 +0.2
Ð0.1 Ð0.1
4.5
±0.7
PACKAGE LEAD
CENTER CENTER
Dwg. MK-003-9 mm
NOTE: Exact body and lead configuration at vendorÕs option within limits shown.
www.allegromicro.com
STR-S5703
OFF-LINE
QUASI-RESONANT FLYBACK
SWITCHING REGULATOR
The products described here are manufactured in Japan by Sanken Electric Co., Ltd.
for sale by Allegro MicroSystems, Inc.
Sanken Electric Co., Ltd. and Allegro MicroSystems, Inc. reserve the right to make,
from time to time, such departures from the detail specifications as may be required to
permit improvements in the performance, reliability, or manufacturability of their
products. Therefore, the user is cautioned to verify that the information in this publication
is current before placing any order.
These products are not authorized for use as critical components in life-support
appliances, devices, or systems without express written approval.
The information included herein is believed to be accurate and reliable. However,
Sanken Electric Co., Ltd. and Allegro MicroSystems, Inc. assume no responsibility for its
use; nor for any infringements of patents or other rights of third parties which may result
from its use.
™
115 Northeast Cutoff, Box 15036
Worcester, Massachusetts 01615-0036 (508) 853-5000